Most common 2023 Mercedes-Benz Sprinter 2500 problems
Share of the 19 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Mercedes-Benz Sprinter 2500 complaints by model year
Best Sprinter 2500 years: 2012, 2010, 2017. Years to avoid: 2020, 2019, 2021, 2022, 2014. Compare all years →
2023 Mercedes-Benz Sprinter 2500 recalls (7)
Structure › Frame and members
Daimler Vans USA, LLC (DVUSA) is recalling certain 2023-2024 Mercedes-Benz Sprinter 2500 vehicles. The right longitudinal frame member may not be reinforced properly, decreasing the structural integrity of the third-row seats.
Remedy: Dealers will inspect and repair the frame, as necessary, free of charge. Owner notification letters were mailed December 17, 2025. Owners may contact DVUSA customer service at 1-877-762-8267.
Suspension › Rear › Springs › Leaf spring assembly › U-bolt, leaf spring to axle
Daimler Vans USA, LLC (DVUSA) is recalling certain 2023-2024 Mercedes-Benz Sprinter vehicles. The spring U-bolts for the rear axle may have reduced strength due to improper heat-treatment, which can cause the rear axle to shift out of position.
Remedy: Dealers will replace the spring U-bolts, free of charge. Owner notification letters were mailed August 23, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3FEDERB.
Electrical system › Wiring
Daimler Vans USA, LLC (DVUSA) is recalling certain 2023 Mercedes-Benz Sprinter vehicles. A 12-Volt ground connection may not be secured properly, which can result in the ground connection overheating and a loss of drive power.
Remedy: Dealers will inspect and repair the 12-Volt ground connection, as necessary free of charge. Owner notification letters were mailed May 3, 2024. Owners may contact DVUSA customer service at 1-877-762-8267.
Electrical system › Wiring
Daimler Vans USA, LLC (DVUSA) is recalling certain 2023 Mercedes-Benz Sprinter vehicles. The main wiring harness may chafe against the drive shaft and short circuit, which can result in a loss of drive power, power steering, and brake system control.
Remedy: Dealers will inspect the routing of the main wiring harness and correct it, as necessary, free of charge. Owner notification letters were mailed April 5, 2024.
Structure › Critical fasteners
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2023 Mercedes-Benz Sprinter and 2019-2021 Freightliner Sprinter vehicles. The partition wall may be missing bolts, allowing the wall to detach during a crash.
Remedy: Dealers will inspect and secure the partition wall as necessary, free of charge. Owner notification letters are expected to be mailed February 16, 2024. Owners may contact DVUSA customer service at 1-877-762-8267.
Suspension › Front
Daimler Vans USA, LLC (DVUSA) is recalling certain 2023 Mercedes-Benz Sprinter vehicles. The front left suspension strut bolt may not be secured properly, which can result in a loss of steering control.
Remedy: Dealers will inspect the front left suspension strut bolt connection and repair the body contact surface as necessary, free of charge. Owner notification letters were mailed January 31, 2024.
Show 1 more recall
Structure › Body
Daimler Vans USA, LLC (DVUSA) is recalling certain 2021-2023 Mercedes-Benz Sprinter and 2021 Freightliner Sprinter vehicles. The topcoat paint formula may cause the windows and interior lashing rails to be insufficiently bonded to the vehicle.
Remedy: Dealers will inspect the paint adhesion and repair it as necessary, free of charge. Depending on the extent of any damage, DVUSA may offer to repurchase the vehicle.
What 2023 Mercedes-Benz Sprinter 2500 owners say
Engine & cooling
Occasionally, the idle speed of the engine will drop to 400 rpm. When this happens, the vehicle does not respond to throttle input. If it happens in a parking lot, you can shift into park and coax the rpm higher, then shift to drive and move on. When it happens in the middle of an intersection while waiting to make a left turn, the story is very different. You can end up in a very dangerous situation. This has happened to me multiple times. I have not had an accident, but I have upset other drivers when I failed to clear an intersection in a timely manner. Knowing that the car will move when you press on the accelerator is critical for safely operating a vehicle. I purchased the vehicle new in October 2024, but did not start driving it until February 2025. The first incident happened about a week after hitting the road. It has happened many times since then. …
I had tuned up my sprinter van around 64000 miles. I put new ngk spark plugs and ignition coils on it. Ran for a day then. The codes said the number one ignition coil was bad. Change that out and it ran for about 8000 miles. Then stated to go in lymph mode again. I decided to replace them with original Mercedes spark plugs and Ignition coils. But when I put them in the van had no power and was jerking. It was doing this before I changed them out. It had no power and would barely go up a hill. I researched and seen certain Merecedes Sprinter vans from 2021 to 2023. Had a recall on the fuel pump. But I don't understand why my van wasn't included. It's showing all the systems them the fuel pump or something to do with the fuel pump is going bad. I changed the spark plugs and ignition coils twice in less than 3 months.
Transmission & drivetrain
The front driveshaft for the vehicle referenced has a safety design flaw that makes it too short. There is a risk of the front driveshaft separating from the front differential splines completely and wrecking havoc to the vehicles essential driving components like steering rack, wiring harness, and potentially causing an accident. Mercedes Benz has increased wait times at their shops and are currently 5-6 weeks out to even look at the vehicles issue. Currently my vehicle is experiencing major vibrations due to the front driveshaft barely hanging on to the front differential splines as the manufactures design is not robust enough for simply driving on the road and allows the front driveshaft to simply slip off what is designed to retain the shaft to the front differential. …
At 3,000 miles, my 2023 Van (purchased new) developed significant reduction in power and acceleration. The transmission also shifts incorrectly (too late, resulting in higher then normal RPM's) and then abruptly downshifts upon stopping. When going uphill, the van obtains a max speed of about 35-40MPH, forcing me to travel on the local Interstates on the shoulder with my hazards flashing so other vehicles know to pass me. Van was left at Mercedes Dealership for 1 month. Van was not repaired, no plan or remedy was communicated. Van has only been inspected by the dealership where it was purchased. A check engine light came on about 1 week after van lost power.
Fuel & propulsion system
Occasionally, the idle speed of the engine will drop to 400 rpm. When this happens, the vehicle does not respond to throttle input. If it happens in a parking lot, you can shift into park and coax the rpm higher, then shift to drive and move on. When it happens in the middle of an intersection while waiting to make a left turn, the story is very different. You can end up in a very dangerous situation. This has happened to me multiple times. I have not had an accident, but I have upset other drivers when I failed to clear an intersection in a timely manner. Knowing that the car will move when you press on the accelerator is critical for safely operating a vehicle. I purchased the vehicle new in October 2024, but did not start driving it until February 2025. The first incident happened about a week after hitting the road. It has happened many times since then. …
I had tuned up my sprinter van around 64000 miles. I put new ngk spark plugs and ignition coils on it. Ran for a day then. The codes said the number one ignition coil was bad. Change that out and it ran for about 8000 miles. Then stated to go in lymph mode again. I decided to replace them with original Mercedes spark plugs and Ignition coils. But when I put them in the van had no power and was jerking. It was doing this before I changed them out. It had no power and would barely go up a hill. I researched and seen certain Merecedes Sprinter vans from 2021 to 2023. Had a recall on the fuel pump. But I don't understand why my van wasn't included. It's showing all the systems them the fuel pump or something to do with the fuel pump is going bad. I changed the spark plugs and ignition coils twice in less than 3 months.
Frequently asked questions
Is the 2023 Mercedes-Benz Sprinter 2500 a good car?
Based on 19 owner complaints filed with NHTSA, the 2023 Sprinter 2500 rates use caution: 2.3× as many complaints as a typical year of the Sprinter 2500 at the same age. It is one of the Sprinter 2500 years we suggest avoiding. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2023 Mercedes-Benz Sprinter 2500?
The engine & cooling — 6 complaints, 32% of all complaints for this model year. Next are the transmission & drivetrain (5) and fuel & propulsion system (5).
How many recalls does the 2023 Mercedes-Benz Sprinter 2500 have?
There are 7 recalls for the 2023 Mercedes-Benz Sprinter 2500, the most recent from October 24, 2025 (frame and members). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Mercedes-Benz Sprinter 2500?
The best years by complaints, compared at the same age, are 2012, 2010 and 2017. Years to avoid or approach with caution: 2020, 2019, 2021, 2022 and 2014. See the full Mercedes-Benz Sprinter 2500 years comparison.
At what mileage do 2023 Mercedes-Benz Sprinter 2500 problems happen?
The median mileage reported in complaints is about 2,000 miles; 100% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.