2020 Mercedes-Benz Sprinter 2500 Electrical Problems

Which parts fail

• Ignition › Module
  1

Components named in complaints (battery, alternator, wiring, ignition, instrument cluster, infotainment).

Mileage when the problem started

• Under 25k
  480%
• 25k–50k
  00%
• 50k–75k
  120%
• 75k–100k
  00%
• 100k–150k
  00%
• 150k+
  00%

Owner reports

Selected complaints filed with NHTSA by 2020 Mercedes-Benz Sprinter 2500 owners, lightly cleaned up (personal details are redacted by NHTSA).

On November 28, 2025, I experienced a vehicle fire in my Mercedes 2020 Sprinter 2500 4WD van. The van engine was on and idling while heating up with the van heater blower on level 6 (out of 7). After about 45 minutes, I saw a haze first and then smelled smoke. Unsure of the source, I turned the vehicle off and exited with my dog. I opened the hood to look for smoke in the engine bay. No smoke under the hood. I contact Mercedes Roadside and open the driver side door where I see flames under the seat. I grabbed the fire extinguisher I installed and put the fire out within 20-25 seconds of seeing it. I believe the root cause of the fire was running the van blower at a high setting for a sustained 45 minutes. My dog and I were inside and definitely in danger. It scares me to think of a scenario where the van was idling with only my dog inside and something like this occurring. …

The contact owns a 2020 Mercedes-Benz Sprinter 2500. The contact stated while driving approximately 35 MPH, the instrument cluster lost functionality and the screen went blank. The contact stated no warning was illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle had not been diagnosed or repaired. Additionally, the contact stated that the vehicle had experienced cold start failures. The contact stated that occasionally several attempts were needed to start the vehicle. The contact stated that the failures were intermittent. The manufacturer had been informed of the failure. The contact researched online and related the instrument cluster failure to NHTSA Campaign Number: 23V204000 (Electrical System). The failure mileage was approximately 11,000.

The contact owns a 2020 Mercedes-Benz Sprinter 2500. The contact stated that while in reverse, the rearview camera failed to display a rearview image. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to provide a cause for the failure. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 21V411000 (Electrical System, Back Over Prevention); but the VIN was not included in the recall. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 51,000.

The contact owns a 2020 Mercedes-Benz Sprinter 2500. The contact stated that after inclement weather, the cruise control, Forward Collision Avoidance, and Automatic Emergency braking feature failed to operate as needed. The contact restarted the vehicle however, the vehicle would intermittently return to normal operation. The contact had taken the vehicle to various different dealers where the camera, unknown sensors, and other unknown parts were replaced; however, the failure persisted. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 10,000.

On Sept 6 2021 the engine suddenly stalled/stopped while driving on 194 west of Pullman Wa. A partial restart enabled me to move to a safer location. The Check Engine light came on. I used myOBD scanner to identify engine failure fault codes. Electrical sensor short circuits were identified. Vehicle was transported to a MB dealer in Spokane where a chaffed engine wiring harness was identified as the cause. MB engineers in Stuttgart Germany confirmed this diagnosis. I have now learned that the factory harness installation rubbing against engine components has been an ongoing problem in the Sprinter Van. This defect has contributed to engine failures as acknowledged by several MB technicians. Owners of all affected MB Sprinter Vans should receive notice of this potentially dangerous wiring harness defect. …

Here's what I wrote: The 2019+ Mercedes Sprinter EIS (Electronic Ignition System) module is bolted under the driver side dash board to the base of the A pillar where it meets with the firewall. The electrical connector of the module is pointing straight up - this is an issue because any liquids that might spill on the dash (dash cupholder) or any humidity from windshield interior condensation will drip right down the wiring and into the EIS module causing it to short out. _ If the EIS module shorts out, the vehicle will be inoperable until a new unit is fitted. _ The EIS module retails at $1800+ from Mercedes _ Had Mercedes installed the EIS module with the connector facing DOWNWARD - this moisture related issue would not exist. _ There is no drip loop provisions in the wiring. …

The 2019+ Mercedes Sprinter EIS (Electronic Ignition System) module is bolted under the driver side dash board to the base of the A pillar where it meets with the firewall. The electrical connector of the module is pointing straight up - this is an issue because any liquids that might spill on the dash (dash cupholder) or any humidity from windshield interior condensation will drip right down the wiring and into the EIS module causing it to short out. _ If the EIS module shorts out, the vehicle will be inoperable until a new unit is fitted. _ The EIS module retails at $1800+ from Mercedes _ Had Mercedes installed the EIS module with the connector facing DOWNWARD - this moisture related issue would not exist. _ There is no drip loop provisions in the wiring. …

The 2019+ Mercedes Sprinter EIS (Electronic Ignition System) module is bolted under the driver side dash board to the base of the A pillar where it meets with the firewall. The electrical connector of the module is pointing straight up - this is an issue because any liquids that might spill on the dash (dash cupholder) or any humidity from windshield interior condensation will drip right down the wiring and into the EIS module causing it to short out. _ If the EIS module shorts out, the vehicle will be inoperable until a new unit is fitted. _ The EIS module retails at $1800+ from Mercedes _ Had Mercedes installed the EIS module with the connector facing DOWNWARD - this moisture related issue would not exist. _ There is no drip loop provisions in the wiring. …

Since date of purchase, May 2022, the electrical components have not worked properly. The solar panels have never worked, the second alternator used to only charge while driving intermittently now it doesn't work at all, and plugging into shore power sometimes melts the cord. The chassis battery frequently drains requiring constant starting or a jump. It has been replaced four times. The cabin lights continue to flicker when turned on. I sought help from the dealer just weeks after purchasing the van. Due to parts and labor shortages, it wouldn't be for 5 months that they could work on the vehicle. Which they did on and off for five months before sending me from Oregon to Alabama to have the manufacturer work on it. They sent me 2300 miles to fix a brand new vehicle that they sold me. …

The 2020 Mercedes Sprinter EIS (Electronic Ignition System) module is placed directly to the base of A pillar. Its electrical connector is pointing straight up and cable entry does not have drop loop - this is an issue because any liquids that might spill on the dash (dash cupholder) or any humidity from windshield interior condensation will drip right down the wiring and into the EIS module causing it to short out. If the EIS module shorts out, the vehicle is inoperable and has to be towed to dealership for repair. MB retails EIS module at $1800+ MB knows it's a product defect. In its service bulletin of LI54.21-N-069524, They had a temporary solution by using an plastic bag (part number A 638 546 00 35) to cover the top connector. As of right now, Mercedes refuses to fix this issue preventatively. They will only repair it AFTER the EIS module has shorted out. …

Related recalls

Electrical complaints in other Sprinter 2500 years