Which parts fail
Components named in complaints (fuel pump, injectors, fuel tank, hybrid and EV propulsion).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2008 Ford Edge owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2008 Ford Edge. The contact stated after refueling the vehicle, once he parked the vehicle in the garage, he smelled a strong odor of gasoline coming from the vehicle. The contact looked underneath the vehicle and became aware of a fuel leak. The vehicle was not diagnosed. The contact informed the dealer that the vehicle was experiencing the failure stated in NHTSA Campaign Number: 14V682000 (Fuel System, Gasoline). The contact was informed that the vehicle was inspected however, the vehicle had not experienced the failure at the time of inspection. The manufacturer was contacted, and a case was filed. The failure mileage was 213,000.
The contact owns a 2008 Ford Edge. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 14V682000 (Fuel System, Gasoline) on November 4, 2021. However, the vehicle experienced a fuel leak. The contact stated that the dealer applied a corrosion preventative to the fuel tank instead of replacing the fuel tank as expected. The dealer was not notified of the failure. The manufacturer was made aware of the failure. The failure mileage was 150,000.
The contact owns a 2008 Ford Edge. The contact stated that fuel was leaking from the fuel tank. The check engine warning light was illuminated. The manufacturer was contacted and referred the contact to the NHTSA. The contact related the failure to NHTSA Campaign Number: 14V682000 (Fuel System, Gasoline) however, the VIN was not included. The failure mileage was approximately 176, 000.
The contact owns a 2008 Ford Edge. The contact stated while driving at an undisclosed speed, the vehicle started to jerk, and the contact became aware of a burning odor. The contact pulled over off the roadway. The check engine warning light intermittently illuminated. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the water pump had failed. The water pump was replaced however, the failure recurred. The vehicle was taken back to the independent mechanic where it was diagnosed and determined that the brakes had failed and needed to be replaced; however, the failure recurred. The check engine warning light illuminated, and the low oil pressure warning light illuminated. The contact stated that after a week, the failure recurred, and the vehicle failed to shift into the intended gear. …
My vehicle 2008 Ford edge had a safety recall from 2012 and the gas tank that the previous owners never had taken care of it or resolved. I purchased a car in February. I filled the gas tank. I parked it in my condo and I used my secondary car to go to work that day. Well, the management called me and said that my gas tank exploded and that there was fuel all over the condo parking lot. Had the fire department come and secure the car they took care of the gasoline in the parking lot and then I had it towed to Miller Ford when we found out that there was a recall on that gas tank. This car has been at this dealership three times it's going tomorrow. This will be the fourth time for the same issue. I feel that this car is not safe. I feel that because nobody addressed this safety recall since 2012 that everything was corroded. …
Safety Recall [redacted] My vehicle falls into this recall yet the dealership and ford is saying it dose not. The vehicle was built at the Oakville Assembly Plant during the time of recall specs. I believe June 2007. The vehicle is in Wisconsin which also falls into the recall specs. The fuel tank has the leak in the areas spoke of in the recall, Ford is not doing anything about it. We received a case number 6 months ago and never heard back from them. This is a serious issue. The dealership gave us a estimate of almost $4000. something we can not afford. Please help.
Had 2008 Ford Edge Limited AWD looked at while servicing for oil etc. Fuel smell noted at rear of vehicle. When looked at noticed wet fuel tank. Fuel tank is still on vehicle. (Ford wants $4400 to replace it) Independent shop JP Automotive in North Haven CT and Bob Thomas Ford in Hamden CT confirm tank is leaking. Bob Thomas Ford says not part of Ford TSB #14S22 (NHTSA #10076517) or Ford TSB #14R02 (NHTSA #10076296) A fuel leak in the presence of an ignition source may result in a fire. Causing danger to myself, my passengers, and others on the road. No warning lamps etc. Just a fuel smell at the rear of the vehicle that started.
I just been told by koons that I would have to pay 1,300 to fix a throttle issue on my 2008 Ford Edge, which I purchased as a used vehicle labor day special 2014. The car stalls, stops, acceleration is affected. Ford knows the throttles are faulty and instead of recalling, they did a customer satisfaction and agreed to repair affected Edge from 2009-2014. This is bogus I have 2008, which that has this issue. I refuse to pay this and don't have the money to invest in junk. Koons told me because of my hesitation I was investigating in a car that has valued equity & would offer great trade. They knew..they yet put me in another dangerous car. I had accident as well, driving ca lost speed & stalled while crossing over in parking lot.
I was driving to my mothers house on 11/10/19. Whole is was driving on route 1a my air bag exploded and it caused me to crash and it totaled my car. The news reporters came to the seen it aired for 2 days on channel 5 news. There has been a recall on my air bags since 2017 and Ford didn't have the parts to my car to fix the issue they also didn't have the parts in 2018 as well and Ford just place another recall on my vechile as well in February 2019 for the air bags again. This issue almost cost me my life. The town the accident took place was in walpole, ma on main street.
Tl* the contact owns a 2008 Ford Edge. The contact stated that there were was a strong burning odor inside the vehicle. The vehicle was taken to the independent mechanic who diagnosed that the carburetor and the fuel line needed to be replaced. The vehicle was repaired, but the failure persisted. The vehicle was included in NHTSA campaign number: 14V682000 (fuel system, gasoline); however, the part to do the repair was unavailable. The manufacturer was not made aware of the failure. The approximate failure mileage was 30,000. Updated 4/15/15
Related recalls
Fuel system, gasoline › Storage › Tank assembly
Ford Motor Company (Ford) is recalling certain model year 2007-2008 Lincoln MKX, and Ford Edge vehicles, manufactured June 15, 2006, to September 22, 2008, and originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New…
Remedy: Interim notices were mailed to owners on December 12, 2014. The recall began on October 6, 2015. Dealers will inspect the vehicles and either clean and treat the fuel tank with a corrosion preventative or replace the…
Fuel system, gasoline › Storage › Tank assembly
Ford is recalling 142 my 2008 edge and Lincoln mkk all wheel drive vehicles. The fuel tank weld fixture May have been exposed to a contaminant during production which could cause a dimple in the bottom of the fuel tank at a spot weld.
Remedy: Dealers will inspect and, if necessary, replace the fuel tank free of charge. The recall began on July 11, 2008. Owners May contact Ford at 1-866-437-7332.
Fuel System complaints in other Edge years
Frequently asked questions
How common are fuel system problems on the 2008 Ford Edge?
NHTSA has 69 complaints about the fuel & propulsion system of the 2008 Ford Edge, 6% of the model year's 1,120 complaints. The component named most often is carburetor system (1 mentions).
Is there a recall for 2008 Ford Edge fuel system problems?
Yes — NHTSA recall 14V-682 (tank assembly, Oct 29, 2014); NHTSA recall 08V-301 (tank assembly, Jul 3, 2008). Recall repairs are free at authorized dealers.
At what mileage do 2008 Ford Edge fuel system problems start?
Half of the complaints with a recorded mileage happened before about 99,000 miles, and 5% before 25,000 miles.
Is it dangerous?
Owners linked 2 crashes, 1 fire and 3 injuries to fuel & propulsion system problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.