Airbag complaints by model year
Which parts fail
Components named in complaints (front, side and curtain air bags, sensors and inflators).
Mileage when the problem started
What owners report
We have an airbag warning light that keeps coming on. It's been reset by a repair garage, but has returned this week. Techniction Stating the following: on technical service bulletin they state inspect and install a jumper harness in the front seats. Why do I have to reroute electrical. This should be a recall for repair because Chrysler has wired it incorrectly to start with. other information: symptom/condition: Right and left seat deployment squib 1 circuit open I am notifying you before a crash happens so all chyrsler 200 can be repaired.
Airbag warning light came on intermittently at first the remained on. Vehicle was taken to the dealer to be checked on 9/2/21. Dealer stated passenger seat airbag wiring harness was defective and replaced at a cost of $1179.29. 1/18/23 Airbag warning light steadily on. Dealer advised driver side airbag squib harness connector pins open. Replaced harness at no charge due to second incident with harness.
The contact owns a 2016 Chrysler 200. The contact stated that whenever the front passenger's seat was occupied, the "Service Airbag" warning light illuminated. The contact stated that the failure occurred when the occupants placed their feet near the front passenger footwell area, where the airbag module and wiring harness were located. The contact routinely disconnected and reconnected the airbag wiring harness to reset and clear the warning light from the instrument panel; however, the failure recurred when the front passenger seat was occupied. The vehicle was taken to the dealer for a diagnostic inspection, but the dealer was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 132,073.
The contact owns a 2016 Chrysler 200. The contact stated that the air bag warning light was illuminated, and the message "Service Air Bag" was displayed. The vehicle was taken to the dealer, where the contact was informed that the failure might be a factory defect; however, the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 97,000.
I was driving to take my vehicle to the car dealer that I bought it from and started having problems with the car. As I was driving the car started smoking really bad, and soon as I pulled into the the car dealer lot the bottom of my car was in flames. I had to hurry put the car in park jump out and grab my daughter out the car. Every since my daughter has been having really bad coughing issues. I took my car to have it looked at and checked and the dealer let me know that it was nothing they can do that they would not switch me to another car. I feel it's unsafe and unfair for my children as well as my self to continue having to drive in and pay for a car that has caught on fire. Every since I have been having unstoppable problems with the car, from a starting issue, air bag issue, engine issue and so many more problem.
The contact owns a 2015 Chrysler 200. The contact stated that while operating the vehicle, the front passenger's side air bag warning light would remain illuminated and would turn off and on without a passenger being in the seat. The vehicle was taken to the local dealer who replaced the electrical wiring, but the failure reoccurred. Also, while attempting to accelerate from a stationary position, the accelerator pedal needed to be depressed almost to the floor before the vehicle responded. Occasionally, the vehicle experienced unintended acceleration and the vehicle would suddenly lurch forward. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure. The failure mileage was 53,000.
My wife and daughters almost died in a car accident due to the apparent failure of this vehicle. We were driving on an HWY at night and the car just died out of nowhere. Dash started to flash and just died. We initially thought that it was the mechanic that had just fixed the car but after an investigation concluded that it was not anything they could have done. My family sustained life-threatening injuries and almost did not make it out alive as thee were rear-ended by a truck. Then on top of it when they were hit no airbags deployed which is what caused the injuries to be so much worse. After reading multiple complaints on NHTSA about the same issue for the same year and make I am baffled that this issue has not been addressed. I almost lost my family.
A couple of years ago my passenger head restraint deployed while parked and would not reset. I was charged $652.00 to re place. Chrysler later reimbursed me for this expense and extended my warranty for this for one year. Two days ago the driver side activated while the car was parked. That means the warrant extension had passed. Did some research and this is a common problem caused by the weakening of the plastic that is under pressure of the retaining springs. This problem not only affects the Chrysler 200, but 300s and several keep and Dodge vehicles manufactured between 2010 and 2015. It is just by the grace of God no one has been injured. Mileage was 78000 the first time and 106500 the second time
Related recalls (3)
Air bags
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017.
Air bags › Sensor › Occupant classification
Chrysler (FCA US LLC) is recalling certain model year 2015 Chrysler 200 vehicles manufactured April 7, 2014, to August 3, 2015. During service work, the affected vehicles may have had either the Occupant Classification Module (OCM) or the Seat Cushion Foam (SCF) of the front passenger seat replaced instead of the both pieces…
Remedy: Chrysler will notify owners, and dealers will install a new OCM-SCF seat service kit, free of charge. The recall began on May 27, 2016. Owners may contact Chrysler customer service at 1-800-853-1403.
Air bags
Chrysler is recalling certain model year 2011-2013 Sebring and 200 vehicles manufactured June 28, 2011, through December 13, 2012; model year 2011-2013 Dodge Avenger vehicles manufactured June 25, 2011, through January 14, 2013; model year 2011-2012 Dodge Nitro vehicles manufactured June 17, 2011, through December 15, 2011; and…
Remedy: Chrysler will notify owners, and dealers will flash the Totally Integrated Power Module (TIPM) or replace the occupant restraint control module, as needed, free of charge. The recall began on November 19, 2013.
Frequently asked questions
Which Chrysler 200 years have airbag problems?
By NHTSA complaints, the 2015 (327), 2013 (171), 2012 (136), 2016 (88) and 2014 (68) model years. Airbag complaints make up 16% of all complaints for the 2015.
Is there a recall for Chrysler 200 airbag problems?
Yes — 3 recalls, including 16V-668 (air bags, Sep 15, 2016); 16V-114 (occupant classification, Feb 26, 2016); 13V-282 (air bags, Jul 2, 2013). Recall repairs are free at authorized dealers; check a specific car with the VIN recall check.
At what mileage do Chrysler 200 airbag problems start?
Across all years, half of the complaints with a recorded mileage happened before about 58,000 miles; 40% happened before 50,000 miles.
What part fails most often?
Owners most often name the frontal › driver clockspring/spiral cassette (2 mentions), followed by the frontal › sensor/control module (1).
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.