2025 Toyota Tundra Fuel System Problems

Owner reports

Selected complaints filed with NHTSA by 2025 Toyota Tundra owners, lightly cleaned up (personal details are redacted by NHTSA).

The vehicle does not predictably respond to throttle inputs (if it responds at all), when you come off the brake pedal it will begin rolling at "idle" speed as normal but when you begin to increase throttle input NOTHING will happen for several very important seconds as you roll into an intersection or need the vehicle to accelerate to maneuver. This had happened multiple times before scheduling service appointments. The day BEFORE my appointment while trying to make a right hand turn from EB 13st St in Lemont IL to SB Bell Rd, i had stopped for the red light, verified clearance to make the turn, and began my maneuver. Once I came off the brake pedal the vehicle began to roll into the intersection but as I began to turn the vehicle and try to accelerate though the turn it did not respond WHATSOEVER. …

Vehicle: 2025 Toyota Tundra Component/System: Powertrain / Electronic Throttle Control / Transmission Response Complaint Description: I am reporting a serious safety defect involving delayed and inconsistent acceleration from a stop or low speed. What failed or malfunctioned: The vehicle exhibits a significant delay in throttle response. The electronic throttle and/or transmission fails to deliver engine power when the accelerator is pressed. The vehicle is available for inspection upon request. Safety risk: This failure creates a hazardous condition when entering intersections, turning across traffic, or merging. On multiple occasions, the truck failed to accelerate when commanded. In one incident, I pressed the accelerator approximately 75% and the vehicle did not respond for 2-3 seconds, nearly resulting in a collision. …

I have experienced a severe hesitation or delay in acceleration when accelerating from a stop or near-stop condition. While the issue has only occurred a few times over the past several months, on multiple occasions it happened while merging into traffic and nearly resulted in an accident. Toyota has issued Technical Service Bulletin (TSB-0032-26) addressing this condition. However, when I brought my vehicle to the dealership, Toyota documented that they were unable to reproduce or confirm the hesitation, and no repair was performed. This defect presents a significant safety risk. Unexpected loss of acceleration during traffic merges, intersections, or other situations requiring immediate power can place drivers and passengers in danger and could lead to serious injury or death. …

2025 Toyota Tundra with 2200 miles. Truck has developed an intermittent lag/hesitation when starting from a stop. At random times, when pulling out into fast moving traffic, hit the pedal to proceed and enter the roadway and it will take a second or two before there is any response from the engine. Oncoming traffic traveling at 50mph are now a second or two closer and need to brake hard to avoid collision. There seems to be a fault between the throttle pedal and the engine. No warning lamps. Difficult to reproduce as it only happens on occasion. Vehicle has not been inspected by a dealership. The issue has been reported to Toyota via online support, message # [redacted]

After dinner at a restaurant I went to pull out from the parking lot onto a road with a 40 mph speed limit. When I pressed the accelerator to turn, my truck felt like it was in a high gear and just barely moved forward. I let off the gas pedal and pressed again and the same thing. At this point I am drifting into on coming traffic without power. I hit the brake, moved to park, moved the setting to SPORT and then moved back into drive and only then was able to operated the vehicle properly and safely. Fortunately the person on the road did stop and did not hit me, but this is a VERY DANGEROUS situation and something is clearly not working properly.

Dead pedal incidents. At least 4 times in the 6months of ownership, I've experienced where when you press on the gas to go, there is no acceleration for approx 2 seconds. Its almost caused an accident 2x of the 4x times its happened. I feel it may be related to the transmission. Prior to this truck I had a 22' Lexus LS500 Fsport which I think also has the 10 speed trans and twice experienced similar conditions. It kind of feels like the trans is slow in downshifting, trying to figure out where it needs to be.

I was crossing two lanes of a 4-lane highway from a stop. I floored the accelerator to cross traffic and the truck hesitated for approximately 1-2 seconds in the middle of the highway before finally accelerating. During this time I was completely exposed to oncoming traffic with no ability to move the vehicle. This is not the first time I have experienced throttle hesitation on this vehicle but this was by far the most dangerous instance. The truck has ~17,000 miles and is a 2025 model year

Throttle lag / hesitation when pushing the gas pedal. This is a very serious issue. There are many many complaints about this issue but the toyota and the dealer is not doing anything about it. This hesitation has almost caused me several accidents because the gas pedal does not respond. Causing on coming traffic to swerve or brake to avoid me. Let's hope this issue get attention before it's too late. Just Google "tundra throttle lag" and see how many tundra owners have this serious issue.

Several times when accelerating around traffic or cutting across the highway to work I have been nearly t boned when I'll step on the gas and the truck hesitates or does nothing. It usually hesitates for 3 to 5 seconds and then starts spinning tires or other times it will just start lightly accelerating no matter how much gas I give it. It's dangerous because the vehicle is so unpredictable and will eventually result in an accident.

While starting to accelerate from a stop whether it is going straight or turning the truck hesitates and takes multiple seconds to start accelerating leading to a potentially dangerous situation especially when turning and you can't get out of oncoming traffics way. Also when at a slow roll trying to accelerate the truck just does not apply any power for multiple seconds delaying movement and potential to avoid an accident.

Fuel System complaints in other Tundra years