Which parts fail
Components named in complaints (struts, shocks, control arms, ball joints, springs).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2008 Toyota Tundra owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact's husband owns a 2008 Toyota Tundra. The contact stated that while driving at an undisclosed speed, a fellow motorist alerted her husband that an unknown part had been hanging from underneath the vehicle. Upon inspection, the contact's husband discovered that the fuel tank had detached from the vehicle due to severe corrosion. The contact stated that several years prior, the vehicle had been subjected to an unknown recall related to corrosion. The contact stated that a special coating was sprayed on the vehicle to prevent corrosion; however, the recall remedy failed to prevent the corrosion. The dealer was notified of the failure but offered no assistance. The manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 171,000.
I was washing my truck October,1,2023 and while spraying the underside with water I noticed the fuel tank hanging extremely low from the back while further inspection I observed the rear fuel tank strap had rusted off and the tank was hanging by the front strap which is very corroded along with all inner structure and frame rails which is rusted corroded and completely rotted out. This truck has been very well maintained and has only 104354 miles on it.
The air injection pumps went out. Vehicle could not get out of limp mode, was very dangerous as I couldnt get up to speed while merging onto traffic. Had to put hazards on and drive vehicle home under 25mph. Vehicles were going around me. Vehicle is scheduled to be looked at by a dealer, but still recommend this be a safety issue!!
I'm writing regarding my 2008 Toyota Tundra and a recent rear axle wheel bearings failure. The truck itself is in meticulous condition and only has 58,000 miles on it. The reason for the note is that I've seen articles indicating there has been issues as well as located a related Toyota service bulletins. I was also told by the service technician that the bearings that were installed were upgraded bearings. Typically I wouldn't think twice, but knowing this is a safety issue as well as the other information we have found, I'm curious if NHTSA has done any investigation or has any additional information it can share? Toyota and my dealer ended up covering half the repair, but there was still quite a bit we had to cover. Beyond the bearing, we recently learned there May be issues with the frame. Anything you can share on that would also be appreciated. Thank you in advance. …
Leaf springs giving out, never put half of the max weight capacity, called Toyota they told me nothing they can do and they stand behind their product even though I personally know someone that had theirs repaired at no charge Toyota would not fix it for free if they did not know the product was bad and faulty. Noise coming from front end of vehicle while driving between 10 to 30 MPH. I was told needed entire new front end, and other components for the repair. I did not know Toyota did not care about the public so much to let unsafe vehicles to be out on the road. Cannot drive vehicle until these repairs are done for worry of safety for me and my family.
Frame mount for gas tank has rusted and fuel tank is dropping down. Last year an undercoating was applied by a Toyota dealer and is peeling off in certain areas. I believe pursuant to the class action lawsuit referred to as brian warner et al Toyota motor corporation my vehicle May be covered under warranty because the gas tank strap mounting is part of the frame. As of now, my mechanic advised me not to drive it as it is a safety hazard. I noticed the tank strap was hanging down from the frame and the gas tank was also hanging down while the vehicle was parked in my driveway.
Excessive rust build up all along the underside of the vehicle, frame, and all over the suspension components
Toyota Tundra 4wd truck with standard rims (steel) and Michelin tires. While driving interstate 80 at speed (fast lane) the entire truck began shaking. It was as bad as having a flat tire. I have a great deal of experience driving off road and I handled the problem without incident but I suspect many drivers would be frightened/panicked enough to result in an accident .my theory is the truck when driven at certain speeds on certain surfaces becomes unstable because of unfavorable harmonics which are generated by the suspension/tire/road surface interaction. I like the truck otherwise and intend to keep it but I think someone is going to lose their life or be seriously injured (if it has not happened already). Toyota May be liable and it would behoove Toyota to be proactive in this regard. …
2008 Toyota Tundra double cab 4x4 sr5 w/trd off road this truck is clearly unsafe to drive. When you drive the truck and hit a bump in the road, the truck bed bounces. It will actually affect the steering and ability to control the vehicle. While driving the truck at highway speeds, if you hit a large bump it is exceptionally hard to steer and control. I know truck beds can bounce, but this truck is way more than the norm!! The bounce has actually LED to my 1st Tundra's bed to be out of square 1 1/2 . Further more , if you measure from the back of the cab to the top of the bed, there was a difference of 1 3/4 inches from the left and right side. Please help! Toyota has recognized the problem of the bed bounce, but refuses to help. This is a problem is serious and needs to be looked into immediately. Please call if you guys have any questions I will be glad to help. Thank you
We recently bought an 2008 Toyota Tundra v6 4x2 double cab. I noticed a terrible bed bounce that makes us the passengers and driver dizzy and nauseated. I personally feel it is not a safe truck because this can cause road accidents. I went to the dealer and had this complaint but they say it is the trucks normal characteristic and nothing can be done. I don't think owning and driving an expensive truck just to feel dizzy and nauseated is normal. Can you please help us with this. Toyota should do something to correct this for safety. If I have a pregnant woman riding this car, she will probably have an abortion due to the bed bounce.
Suspension complaints in other Tundra years
Frequently asked questions
How common are suspension problems on the 2008 Toyota Tundra?
NHTSA has 29 complaints about the suspension of the 2008 Toyota Tundra, 9% of the model year's 327 complaints. The component named most often is rear (7 mentions).
Is there a recall for 2008 Toyota Tundra suspension problems?
No. NHTSA lists no suspension recall for the 2008 Toyota Tundra, though it has 12 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2008 Toyota Tundra suspension problems start?
Half of the complaints with a recorded mileage happened before about 1,000 miles, and 70% before 25,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.