Most common 2016 Mercedes-Benz Metris problems
Share of the 127 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Mercedes-Benz Metris complaints by model year
Best Metris years: 2015, 2021, 2019. Years to avoid: 2016. Compare all years →
2016 Mercedes-Benz Metris recalls (13)
Tires
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2018 Mercedes-Benz Metris vans. The value for the maximum combined load weight capacity of the tires is incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire and Loading Information."
Remedy: Dealers will install corrected labels on the B-pillar and fuel filler door. Dealers will also inspect and replace incorrect tires, as necessary. All repairs will be performed free of charge.
Back over prevention › Sensing system › Camera
Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2018 Mercedes-Benz Metris vehicles. A defective memory chip in the rearview camera may cause the display image to freeze.
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed February 10, 2023. Owners may contact DVUSA customer service at 1-877-762-8267.
Service brakes, hydraulic › Fluid
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2021 Mercedes-Benz Metris vehicles. The brake fluid reservoir may be incorrectly mounted, which can allow it to detach.
Remedy: Dealers will inspect and repair the brake fluid reservoir mounting, as necessary, free of charge. Owner notification letters were mailed on May 2, 2022. Owners may contact DVUSA customer service at 1-877-762-8267.
Electrical system › Software
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2020 Mercedes-Benz Metris and 2019-2020 Mercedes-Benz Sprinter vehicles. The software design of the communication module may fail to communicate the correct vehicle location for the emergency call system (eCall) in the event of a crash.
Remedy: DVUSA will notify owners, and dealers will update the software communication module for the automatic emergency call system, free of charge. The recall began on May 5, 2021.
Electrical system › 12V/24V/48V battery
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2019 Mercedes-Benz Metris vehicles. The integrated backup battery compartment located underneath the front passenger's seat may not have its own cover, potentially exposing the battery when the seat is moved forward.
Remedy: DVUSA will notify owners, and Mercedes-Benz dealers will install covers over the battery compartment area, free of charge. DVUSA issued owners an interim notification on December 2, 2019. The recall began March 9, 2020.
Steering › Electric power assist system
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2017 Metris vehicles sold, or ever registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, Washington…
Remedy: DVUSA will notify owners, and dealers will replace the aluminum bolts with steels bolts, free of charge. DTNA issued owners an interim notification on June 3, 2019. The recall began November 15, 2019.
Show 7 more recalls
Fuel system, gasoline › Delivery › Hoses, lines/piping, and fittings
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2017 Mercedes-Benz Metris vehicles. The fuel hose in the engine compartment may leak at the lower connecting point of the transition hose, between the underbody fuel line and the Schrader valve and/or where the fuel line connects to the fuel pump.
Remedy: DVUSA will notify owners, and dealers will replace the affected hose and clamp, free of charge. The recall is expected to begin January 25, 2019. Owners may contact DVUSA customer service at 1-877-762-8267.
Power train › Automatic transmission
Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2017 Mercedes-Benz Metris vehicles. The transmission support may not have been properly tightened to the vehicle body, potentially resulting in damage to the driveshaft.
Remedy: DVUSA will notify owners, and dealers will inspect the transmission support mounting bolts, replacing and tightening them as necessary, free of charge. The recall began July 11, 2018.
Steering › Electric power assist system
Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2015-2017 Mercedes-Benz Metris vans. These vehicles have electrical power steering control units with improperly welded contact pins.
Remedy: DVUSA will notify owners, and dealers will replace the electric power steering rack, free of charge. An interim notice is expected to be mailed on November 17, 2017.
Electrical system › Software
Daimler Vans USA, LLC (DVUSA) is recalling certain 2013-2014 Freightliner Sprinter and 2016 Mercedes-Benz Metris vehicles. During vehicle servicing, the affected vehicles received software updates that may conflict with some of the vehicle's computers.
Remedy: DVUSA will notify owners, and Mercedes-Benz and Freightliner dealers will update the affected control units on the vehicles, free of charge. An interim notice was sent to owners on July 12, 2017.
Seat belts › Pretensioner
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016 Mercedes-Benz Metris vehicles. The affected vehicles have front seat seatbelt pretensioners that may not function properly in the event of a crash.
Remedy: DVUSA will notify owners, and dealers will replace the front seat belts, free of charge. An interim notification was mailed to owners on June 9, 2017.
Lane departure › Blind spot detection
Daimler Vans USA LLC (DVUSA) is recalling certain 2016-2017 Mercedes-Benz Metris vehicles. These vans were to be equipped with the Blind Spot Monitoring (BSM) feature, however, the installed instrument cluster and steering wheel does not support the function, and thus, the BSM system does not work on the vehicle.
Remedy: DVUSA will notify owners, and dealers will install the correct instrument cluster and steering wheel to enable the BSM function, free of charge.
Power train › Axle assembly
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016 Mercedes Benz Metris vehicles manufactured from September 1, 2015, through December 31, 2015. The affected vehicles have rear differential gears that may have been improperly welded.
Remedy: DVUSA will notify owners, and dealers will replace the rear differential gears, free of charge. The recall began on August 11, 2016. Owners may contact DVUSA customer service at 1-877-762-8267.
NHTSA defect investigations
Federal safety investigators have looked into a possible defect involving the 2016 Mercedes-Benz Metris:
Low Pressure Fuel Supply Hose Leak
On November 27, 2018, Daimler Vans USA, LLC submitted a Defect Information Report (DIR) to NHTSA describing two engine compartment fuel hose connection defects in certain model year (MY) 2016 and 2017 Mercedes-Benz Metris vehicles (Recall 18V-837).The recall scope includes approximately 12,383 Metris vehicles manufactured from March 2, 2015 (SOP) to March 15, 2017.The defects may result in leakage from an upper hose…
What 2016 Mercedes-Benz Metris owners say
Fuel & propulsion system all 38 →
In 2019, the fuel line was recalled for my Mercedes Benz Metris. I had this fixed and it was ok for a while. In 2020, it started smelling like gas again. We moved out of state in 2020 and in 2021 I took it into my local dealership to have them look at it. They replaced the fuel line again. Since then, it has smelled like gas badly. It gives me headaches and I feel unsafe driving it. The dealership told me last time that this would not be covered under the initial recall from 2017 but they fixed it "goodwill." I do not understand how this could NOT be covered since the issue is still not rectified. I absolutely need to get this fixed correctly as the smell is very very bad and I worry that fuel may be leaking into compartments somewhere that could cause a fire. I am concerned for my safety every time I drive it for my business. …
There was a fuel smell emanating from the engine compartment during the vehicle pre-start routine (fuel pump priming). The dealership determined this to be a leak in the lower fuel hose to fuel line of the service connection per NHTSA Campaign Number 18V837000, however they refused to cover the cost of the repair because the recall work was previously completed in 2019. Corporate Mercedes Benz USA also refused to extend any goodwill toward this repair despite acknowledging it is the recall issue because the work was done once and is now considered out of warranty. Recall 18V-837 only requires authorized dealer to inspect and replace as necessary, so I don't know if the previously completed recall work on my van actually resulted in replaced parts or not (I bought this van used after the recall work order was completed). …
Windows, wipers & sunroof all 22 →
The right side of the vehicle has a terrible blind spot.no matter how diligently you look in the passenger mirror and over your right shoulder there is an area that is blind to the driver. This is due to the passenger side mirror being too small and not convex. It is not written on the mirror " objects appear closer than they actually are".this is a serious design flaw, I am surprised that that this made it through all of the safety regulations. Luckily, I have not been an accident yet due to this problem. I have mounted additional blindspot mirrors to the existing mirrors but they are no substitute for a properly designed mirror. I purchased this car new from the dealership in August and have returned several times complaining about the mirror but to no avail. …
First off, I have only had this car for approximately 1 week and spent considerable time driving in a large metropolitan area as well as on the interstate with the vehicle in this first week (1200 miles in total). I have adjusted the side mirrors as wide as they are capable of adjusting and still, an enormous blind spot remains for the driver that is both dangerous to myself and drivers around me. On two occasions this week, one (today) that was the worst yet, I was changing lanes and after checking the side mirrors and seeing absolutely nothing, I came extremely close to hitting a sedan that was driving in my blind spot. Fortunately, the other driver was paying attention and able to swerve away from my vehicle to avoid being hit. …
Wheels & tires all 21 →
The contact owns a 2016 Mercedes-Benz Metris. The contact received notification of NHTSA Campaign Number: 22V482000 (Tires) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that all four tires had no tread due to excessive tire wear in less than a year. The contact stated that all four tires were previously replaced; however, the failure recurred. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 47,000. VIN tool confirms parts not available.
There is an open recall for 3 months whereby there is a possibility that wheels are inappropriately specified and not able to carry body weight. My van is constantly have trouble with tires/wheels breaking, ripping within no time. I feel like I'm buying new tires every 1-1.5 years. It is a constant state of low tire pressure warnings followed by replacing tires. In May 2022, I had an incident where torn/leaking tire was filled with air by MB roadside assurance and incorrectly installed on my van. The result was that the tire flew off my van while in motion. I replaced all 4 tires with a slighter higher load tire because I was so scared by the incident. Less than 3 months later, one of those tires was torn on the interior. Replaced again. Today I am driving and again one of the new tires suddenly indicates dropped pressure to 34 compared to others at 41. …
2016 Mercedes-Benz Metris engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 2.0L 4-cyl turbo | 7-speed automatic | RWD | 20 / 23 / 22 |
EPA ratings. Class: —.
Frequently asked questions
Is the 2016 Mercedes-Benz Metris a good car?
Based on 127 owner complaints filed with NHTSA, the 2016 Metris rates avoid: 7.2× as many complaints as a typical year of the Metris at the same age. It is one of the Metris years we suggest avoiding. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2016 Mercedes-Benz Metris?
The fuel & propulsion system — 38 complaints, 30% of all complaints for this model year. Next are the windows, wipers & sunroof (22) and wheels & tires (21).
How many recalls does the 2016 Mercedes-Benz Metris have?
There are 13 recalls for the 2016 Mercedes-Benz Metris, the most recent from July 7, 2022 (tires). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Mercedes-Benz Metris?
The best years by complaints, compared at the same age, are 2015, 2021 and 2019. Years to avoid or approach with caution: 2016. See the full Mercedes-Benz Metris years comparison.
At what mileage do 2016 Mercedes-Benz Metris problems happen?
The median mileage reported in complaints is about 20,000 miles; 84% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.