Hyundai Veloster Brake Problems

Brake complaints by model year

Which parts fail

• Foundation components › Disc › Caliper
  1

Components named in complaints (service brakes, ABS, rotors and pads, parking brake).

Mileage when the problem started

• Under 25k
  1327%
• 25k–50k
  715%
• 50k–75k
  1021%
• 75k–100k
  919%
• 100k–150k
  919%
• 150k+
  00%

What owners report

Brakes intermittently malfunction - when issue occurs, brake pedal will loosely sink to floor without slowing the car down and will only engage suddenly when the pedal is pressed all the way to the bottom. Safety of driver, other drivers, and pedestrians are put at risk because the car cannot be reliably stopped. In the latest incident, the driver could not get the brakes to engage and had to swerve the vehicle into the sidewalk to avoid pedestrians. The malfunction occurs randomly, mostly in stop-and-go situations (traffic, stop signs, parking lot, traffic lights, etc.). Malfunction has persisted for the last 8 months. There has been 3 attempts to fix by the dealership from which the car was purchased - replacing brake pads and rotors, flushing the brake line, and replacing the ABS system. The dealership was able to replicate the issue. …

At approximately 37,000 miles currently and proper documented maintenance and check requests on vehicle, this car appears to not stop as it should while in motion whether at high speeds or low speeds and "surges" and requires a longer stopping distance which is apparent in any driving weather conditions. No obvious signs of brake wear or replacement needs. No indicator sounds.

The contact owns a 2015 Hyundai Veloster. The contact stated while driving at slower speeds and depressing the brake pedal, it seemed the ABS engaged, and the vehicle slowed down significantly. Additionally, the brakes were dragging. The contact stated that upon depressing the brake pedal again, the vehicle operated as needed. The contact stated that the failure occurred intermittently. The check engine warning light was illuminated. Additionally, the contact stated that the brake pads had shown premature wear and tear. The vehicle was taken to the dealer, where the brake calipers, rotors, and brake pads were replaced; however, the failure recurred after 4,500 miles driven. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 12,500

HVAC system wiring is melted, only works intermittently between knob #3-4. check engine light comes off and on for Wheel Speed Sensor (all 4) Invalid/No Signal. Fuses consistently blow. Multiple complains have been made by other 2015 Hyundai Veloster Turbo owners. In addition to these issues being a HUGE fire risk, there was a new fire risk safety recall issued in sept 2023 with no resolution. Hyundais only current resolution for this is to "park away from structures in the meantime", and will send a letter out once resolved. The HVAC system has been replaced once prior.

OFFICIAL REPORT: FRANCHISE FALSIFICATION OF MANDATORY SAFETY RECALL REMEDY I am filing this formal safety complaint because a licensed factory franchise, Causeway Hyundai (Manahawkin, NJ), officially documented and signed off that a mandatory federal safety campaign (NHTSA Recall 21V303 / Hyundai Recall 251: ABS Multi-Fuse Block Replacement) was successfully completed on my vehicle.This official safety record is completely falsified. The service department closed out the repair order and logged it into the manufacturer network as a finished repair. However, I have opened the under-hood engine junction box and taken photographic evidence proving that no physical labor was performed. …

There is a current recall since September, 2023, with no remedy to date. In addition, I have driven this vehicle very little after last having my car serviced at the dealership, just over a year now, which seemed to not be sounding right in the engine, so it alarmed me, and all started feeling overwhelming since going to the dealership for repairs. I see there is an engine recall on the 2015 Veloster, though not the 2014? Yet they are claiming that both issues can cause fires. My vehicle has less than 100K miles if I remember correct from when I last looked. it's been months since I've even driven the vehicle, as I've not felt safe or comfortable doing so. My vehicle seems to have a lot of the same symptoms as the 2015 Veloster recall. i have been nervous to take it back to the same dealer, though I've also been too nervous to let just any mechanic look at it. …

The contact's god-daughter owns a 2013 Hyundai Veloster. The contact stated that the ABS warning light and other unknown warning lights were illuminated. The vehicle was taken to the dealer, where the recall repair of NHTSA Campaign Number: 23V651000(Service Brakes, Hydraulic) was performed; however, the failure persisted. The contact stated that while inspecting the vehicle at the residence, the contact noticed that the ABS fuse was blown. The contact replaced the ABS fuse; however, the ABS motor made an abnormal whining and humming sound. The ABS motor then blew up and caught on fire. The contact stated that he was able to extinguish the 12 inch high flames with a bottle of water. The vehicle was towed to the dealer, where it was determined that the ABS unit and the wiring harness needed to be replaced. The vehicle was not repaired. …

The contact's daughter owns a 2013 Hyundai Veloster. The contact stated that while the vehicle was parked, it caught on fire. The vehicle became engulfed in flames, and the authorities were called to the scene. The Fire Department extinguished the fire. The vehicle was later towed to an impound lot where it was deemed a total loss. No injuries were reported. A police report was filed. A nearby roadside electrical box was damaged due to the heat from the fire. Prior to the fire, the vehicle was taken to the dealer to be repaired under NHTSA Campaign Number: 23V132000 (Electrical System). The contact was informed by the dealer that the vehicle did not have a parking sensor, and the recall repair would not apply to the vehicle. …

Related recalls (2)

NHTSA investigations