Most common 2016 Hyundai Veloster problems
Share of the 223 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Hyundai Veloster complaints by model year
Best Veloster years: 2017, 2014, 2019. Years to avoid: 2013, 2012, 2016. Compare all years →
2016 Hyundai Veloster recalls (1)
Engine
Hyundai Motor America (Hyundai) is recalling certain 2015-2016 Veloster, 2012 Santa Fe, 2011-2013 Sonata Hybrid, and 2016 Sonata Hybrid vehicles. The connecting rod bearings inside the engine may wear prematurely, which over time can result in engine damage.
Remedy: Hyundai will notify owners, and dealers will inspect the engine. If bearing damage is found, the engine will be replaced. Dealers will also install a software update containing a new Knock Sensor Detection System…
NHTSA defect investigations
Federal safety investigators have looked into a possible defect involving the 2016 Hyundai Veloster:
Engine Fires
On March 29, 2019, the Office of Defects Investigation (ODI) opened two Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) to broadly investigate incidents of non-crash fires (regardless of origin or operational status of the vehicle) on various model year Hyundai and Kia vehicles.
What 2016 Hyundai Veloster owners say
Engine & cooling all 140 →
The contact owns a 2016 Hyundai Veloster. The contact stated that while driving approximately 55 MPH a loud booming sound from the engine compartment had occurred and a knocking noise followed along with white smoke from the exhaust pipes. The vehicle drove off the road before flames were present coming from under the hood. The fire department was called to the scene and extinguished the flames. A police report was taken and the vehicle was towed away. No injuries were reported. The cause of the failure was not yet determined. The local dealer and manufacturer were not yet contacted. The contact indicated that the vehicle had previously been serviced several times for a faulty engine and catalytic converter. The failure mileage was 100,000.
The contact owns a 2016 Hyundai Veloster. The contact stated while driving at 40 mph, the oil pressure warning light illuminated. The contact pulled the vehicle over to the side of the road and check the oil and noticed the oil was low. The driver placed oil in the vehicle to continue to drive to their residence. After few days the contact took the vehicle to an independent mechanic to have an oil change done on the vehicle but the failure persisted several times. The contact then received a recall notice for NHTSA campaign number: 20V746000 (Engine) which took their vehicle to a local dealer to have the vehicle inspected due to the contact concerns that the failure on the vehicle was related to the recall. The dealer inspected the vehicle and stated the vehicle was fine but they did not place the Knock sensor detection system software on the vehicle as part of the recall repair remedy. …
Transmission & drivetrain all 43 →
The contact owns a 2016 Hyundai Veloster. The contact stated that while driving from a complete stop and depressing the accelerator pedal, the vehicle hesitated and responded slowly. The contact stated that the failure had been recurring while driving. Additionally, the contact stated that while driving at an undisclosed speed, the vehicle decelerated independently. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where both catalytic converters were replaced, and the fuel lines were cleaned; however, the failure recurred. The vehicle was taken back to the independent mechanic, where the vehicle was test-driven, and the mechanic informed the contact that the failure could be related to the transmission. The vehicle was not repaired. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 150,000.
The contact owns a 2016 Hyundai Veloster. The contact stated while driving approximately 55 MPH and shifting to a higher gear, he attempted to depress the clutch pedal; however, the pedal was flat against the floorboard. The contact had to lift the clutch pedal with his foot several times to get the pedal back to position to respond to shifting gear. The contact stated no warning light was illuminated. Additionally, the vehicle was slow to respond to the accelerator when the contact attempted to accelerate. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that there was no issue with the clutch pedal. The vehicle had not been repaired. The contact stated that the failure of the clutch pedal was intermittent. The manufacturer had not been informed of the failure. The failure mileage was approximately 120,000.
Fuel & propulsion system all 22 →
The contact owns a 2016 Hyundai Veloster. The contact stated that gas fumes were entering inside the vehicle and exhaust fumes were present while driving the vehicle and while the vehicle was parked. The vehicle was taken to an independent mechanic on several occasions and to several dealers; however, the cause of the failure was not yet determined. The master cylinder was replaced, and the high-pressure fuel pump was replaced due to a reported internal fuel leak, but the failure persisted. The contact stated that while refueling the vehicle at a gas station, fuel leaked from the vehicle with a strong fuel odor. The manufacturer was notified of the failure. The approximate failure mileage was 19,000.
The contact owns a 2016 Hyundai Veloster. The contact stated while driving approximately 70 MPH, the vehicle lost motive power. The contact stated there was no warning light illuminated. The vehicle was taken to a Midas where it was diagnosed and determined that the fuel pressure regulator needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 119,000. The VIN was unavailable.
2016 Hyundai Veloster engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 1.6L 4-cyl | 6-speed dual-clutch | FWD | 28 / 35 / 31 |
| 1.6L 4-cyl | 6-speed manual | FWD | 27 / 34 / 30 |
| 1.6L 4-cyl turbo | 6-speed dual-clutch | FWD | 26 / 32 / 29 |
| 1.6L 4-cyl turbo | 6-speed manual | FWD | 25 / 33 / 28 |
EPA ratings. Class: Compact car.
Frequently asked questions
Is the 2016 Hyundai Veloster a good car?
Based on 223 owner complaints filed with NHTSA, the 2016 Veloster rates use caution: 1.7× as many complaints as a typical year of the Veloster at the same age. It is one of the Veloster years we suggest avoiding. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2016 Hyundai Veloster?
The engine & cooling — 140 complaints, 63% of all complaints for this model year, most often about exhaust system › emission control › catalytic convertor. Next are the transmission & drivetrain (43) and fuel & propulsion system (22).
How many recalls does the 2016 Hyundai Veloster have?
There is 1 recall for the 2016 Hyundai Veloster, the most recent from December 1, 2020 (engine). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Hyundai Veloster?
The best years by complaints, compared at the same age, are 2017, 2014 and 2019. Years to avoid or approach with caution: 2013, 2012 and 2016. See the full Hyundai Veloster years comparison.
At what mileage do 2016 Hyundai Veloster problems happen?
The median mileage reported in complaints is about 55,000 miles; 48% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.