Ford F-250 Suspension Problems

Suspension complaints by model year

Which parts fail

• Front
  117
• Front › Springs › Torsion bar
  15
• Rear
  13
• Front › Control arm
  6
• Front › Shock absorber
  5
• Front › Control arm › Lower ball joint
  4
• Front › Stabilizer bar
  4
• Front › Wheel bearing
  3

Components named in complaints (struts, shocks, control arms, ball joints, springs).

Mileage when the problem started

• Under 25k
  7015%
• 25k–50k
  8518%
• 50k–75k
  8919%
• 75k–100k
  6514%
• 100k–150k
  10422%
• 150k+
  6714%

What owners report

The contact owns a 2014 Ford F-250. The contact stated that his vehicle would shake uncontrollably while driving approximately 60 MPH. The contact stated that to stop the vibration, he had to bring the vehicle to a complete stop. The contact stated that the failure also occurred whenever driving over a bump in the roadway. The vehicle was taken to the dealer and an unstated repair was performed; however, the failure recurred. The vehicle was taken back to the dealer and the contact was informed that the vehicle had been repaired; however, the failure persisted. The manufacturer was not notified of the failure. The approximate failure mileage was 130,000.

The contact owns a 2014 Ford F-250. The contact stated that while driving 60 MPH and attempting to change lanes, the contact felt a small bump. Shortly afterwards, the vehicle started to wobble violently, almost causing the contact to lose control of the vehicle due to the increased steering effort. The contact was able to pull over to the shoulder of the roadway to inspect the vehicle, but found no cause for the issue. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 116,668.

The contact owns a 2013 Ford F-250. The contact stated while driving 50 MPH, the front end of the vehicle started shaking with no warning lights illuminated. The vehicle was taken to the independent mechanic, where it was diagnosed with axle shafts needing to be replaced. The vehicle was repaired. The contact stated the failure recurred and the vehicle was taken back to the independent mechanic who then replaced an unknown steering part however, the failure recurred. The vehicle was not repaired. The manufacturer and dealer were not made aware of the failure. The approximate failure mileage was 34,000.

The contact owns a 2013 Ford F-250. The contact stated that while driving at an undisclosed speed, the vehicle experienced the death wobble. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 153,000.

The contact owns a 2012 Ford F-250. The contact stated that while driving approximately 20 MPH, the vehicle suddenly experienced a death wobble causing the vehicle to violently shake and vibrate. During the failure, the steering column failed as a result the driver lost control of the steering and drove off the road, and crash into a ditch. During the crash, the vehicle sustained damage to the subframe bracket. No injuries were reported. No police report was taken. The vehicle was towed away from the scene. The cause of the failure was not yet determined. The local dealer and manufacturer were not notified of the failure. The VIN was not available. The failure mileage was 206,000.

The contact owns a 2012 Ford F-250. The contact stated that since purchasing of the vehicle, the vehicle experienced the death wobble on two separate occasions. The contact stated that the failures occurred while driving at undisclosed speeds. The contact stated that after driving over bumps on the road the vehicle experienced a violent and uncontrollable shaking without warning. The contact stated that once the vehicle slowed down, the vehicle would resume normal operation. The contact had initially taken the vehicle to an independent mechanic who replaced the track bar and track bar ball joint; as well as, the front and rear shocks. Despite the repair, the failure recurred. The vehicle was taken back to the independent mechanic after the second failure and remained in the possession of the independent mechanic. …

The contact owns a 2011 Ford F-250. The contact stated that while driving over a bump at a high rate of speed, the contact experienced the death wobble and the contact temporarily lost control of the vehicle. The contact slowed down and the violent shaking ceased. The contact stated that the tie rods, ball joints, and other front-end parts were replaced to reduce the risk of the failure recurring. The contact stated that while driving 70 MPH and towing a trailer, the contact experienced the death wobble. The vehicle drifted from the far-left lane over to the far-right lane and the contact lost control of the vehicle. The contact called a local dealer and was informed that there were no recalls on the vehicle. The contact was then referred to the manufacturer and was provided a case number. The manufacturer advised the contact to report the failure to the NHTSA Hotline. …

The contact owns a 2011 Ford F-250. The contact stated while driving 65 MPH and switching lanes and depressing the brake, the vehicle started to shake abnormally. There was no warning light illuminated. The contact stated that after decelerating, the vehicle stopped shaking. The dealer was contacted and made aware of the failure. The contact was informed that the VIN was not under recall. The contact was referred to the manufacturer for assistance. The manufacturer was contacted and informed about the failure. The manufacturer confirmed that the VIN was not under recall and referred the contact to the NHTSA Hotline to file a complaint. The failure mileage was 160,000.

NHTSA investigations