Which parts fail
Components named in complaints (struts, shocks, control arms, ball joints, springs).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2012 Ford F-250 owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2012 Ford F-250. The contact stated that while driving approximately 20 MPH, the vehicle suddenly experienced a death wobble causing the vehicle to violently shake and vibrate. During the failure, the steering column failed as a result the driver lost control of the steering and drove off the road, and crash into a ditch. During the crash, the vehicle sustained damage to the subframe bracket. No injuries were reported. No police report was taken. The vehicle was towed away from the scene. The cause of the failure was not yet determined. The local dealer and manufacturer were not notified of the failure. The VIN was not available. The failure mileage was 206,000.
The contact owns a 2012 Ford F-250. The contact stated that since purchasing of the vehicle, the vehicle experienced the death wobble on two separate occasions. The contact stated that the failures occurred while driving at undisclosed speeds. The contact stated that after driving over bumps on the road the vehicle experienced a violent and uncontrollable shaking without warning. The contact stated that once the vehicle slowed down, the vehicle would resume normal operation. The contact had initially taken the vehicle to an independent mechanic who replaced the track bar and track bar ball joint; as well as, the front and rear shocks. Despite the repair, the failure recurred. The vehicle was taken back to the independent mechanic after the second failure and remained in the possession of the independent mechanic. …
The contact owned a 2012 Ford F-250. The contact stated that while driving approximately 60 mph when they came to a small unevenness in the road due to a merging of roads. The contact stated that when they passed that point the vehicle suddenly displayed the death wobble despite there being no significant bumping of the vehicle. The contact had to come to a complete stop then pull over to the side of the road. The contact stated the wobbling seized till they came to a similar uneven patch on the road at approximately 60 mph. Again, the contact had to pull over to seize the wobble. The contact had to drive at less than 50 mph to avoid the failure from reoccurring. The contact had not taken the vehicle to be diagnosed or repaired. The manufacturer was not made aware of the issue. The approximate failure mileage was 30,000.
The contact owns a 2012 Ford F-250. The contact stated that while driving 50 MPH, the vehicle drove over a bump and experienced the death wobble. The contact pulled over and slowed down to stabilize the vehicle. The vehicle was taken to the dealer, where it was diagnosed and repaired, however, the failure recurred. The contact stated the vehicle was repaired six times for the failure. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 128,000. The VIN was not available.
The contact owns a 2012 Ford F-250. The contact stated while driving 65 MPH, the vehicle drove over a bump in the roadway and started to experience the death wobble. The contact stated that there was no warning light illuminated. The contact was able to park on the side of the road, restarted the vehicle, and continued driving to his destination. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was 148,200.
The contact owns a 2012 Ford F-250. The contact stated that while driving at various speeds, the vehicle would shake abnormally without warning. Upon investigation, the contact linked the failure to the death wobble. The contact also stated that the EGR cooler was defective, causing the vehicle to downshift while driving at various speeds. The contact had the EGR cooler repaired by the dealer. The vehicle was not repaired for the death wobble. The manufacturer was not notified of the failure. The approximate failure mileage was 136,700.
The contact owns a 2012 Ford F-250. The contact stated upon making a turn, the wheel seized, and the vehicle failed to move. There was no warning light illuminated. The vehicle was towed to the dealer where it was diagnosed that the front passenger's side axle shaft had fractured at the wheel. The dealer diagnosed that the outer shaft and seals needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact the NHTSA hotline. The failure mileage was approximately 229,020.
The contact owns a 2012 Ford F-250. The contact stated that while driving at high speed, the front of the vehicle was shaking violently. The vehicle was taken to an independent mechanic where the failure was undetermined. The dealer was not contacted. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 170,000.
Over 1 year (2025) steering front end shaking began. Our dealership on oil changes did not tell us to watch for anything and we should have been warned. When the shaking occurred we changed Ford shock asborbers from Ford dealership. Problem still occured. We lost faith in Ford and our regular dealership. We then at Moore's tires purchased 4 Michelin premium tires for F250 heavy duty truck and told them about the severe shaking in front end that we will crash because we can't maintain control only to pull off the road with a prayer. Very difficult when this happens on the route 80 highway going 70 mph speed limit. So, Moore's tires store replaced with new tires and replaced some suspension parts thinking they fixed it but not sure. No recall to alert any Ford owners or repair shops... no warnings to anyone. We spent over $7,000. in trying to solve the front end shaking issue. …
The truck is experiencing what is commonly referred to as the "Death Wobble." At around 55 mph, the vehicle starts to violently shake. It shakes the whole vehicle, especially the steering--the steering wheel severely shakes until I slow the vehicle slows down below 40 mph. From my research, I've found this is a common issue among other Superduty owners. It seems like there are faulty front end suspension and/or steering parts at play: pitman arm, drag link, tie rod ends (and their bushings/ball joints), etc. The shaking happens on the freeway and is frightening to experience as it could potentially lead to losing control if unable to slow down in time to stop the shaking. Being at freeway speeds, my family and I are at risk as well as other vehicles on the road if we were to lose control. This issue did occur 1.5 years ago. …
Suspension complaints in other F-250 years
Frequently asked questions
How common are suspension problems on the 2012 Ford F-250?
NHTSA has 125 complaints about the suspension of the 2012 Ford F-250, 47% of the model year's 266 complaints. The component named most often is front (5 mentions).
Is there a recall for 2012 Ford F-250 suspension problems?
No. NHTSA lists no suspension recall for the 2012 Ford F-250, though it has 1 recall for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2012 Ford F-250 suspension problems start?
Half of the complaints with a recorded mileage happened before about 87,000 miles, and 12% before 25,000 miles.
Is it dangerous?
Owners linked 1 crash, 0 fires and 0 injuries to suspension problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.