Which parts fail
Components named in complaints (doors, hood, frame, rust, paint and trim).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2018 Ford Edge owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2018 Ford Edge. The contact stated while the vehicle was parked, the driver's front door was opened, and the contact noticed a popping sound. The contact's husband inspected the vehicle and noticed that there were cracks within the door well where the check arm was connected. The vehicle was taken to the dealer; however, the contact was informed that the repair was not covered under recall repair or special programs. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact was concerned about the failure, because four grandchildren were regular occupants in the vehicle. The contact was afraid that the doors would detach while the grandchildren were inside the vehicle. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 68,000.
The contact owns a 2018 Ford Edge. The contact stated that the dashboard lights were abnormally dim. The contact stated that after the vehicle was parked, the vehicle failed to restart. After waiting for a while the contact was able to restart the vehicle with the Push to Start button. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the electrical wiring underneath the rear panel was damaged due to water leaking into the compartment. The rear panel was replaced to prevent further failure. The contact was unsure if the wiring had been replaced. The manufacturer was made aware of the failure and confirmed the VIN was not under recall. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 119,000.
The contact owns a 2018 Ford Edge. The contact stated while opening the front driver's side door, there was a squeaking sound and the contact had to hold the door to keep if from bending towards the front of the vehicle. No warning light was illuminated. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the door needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was not notified of the failure. The failure mileage was approximately 78,000.
The contact's daughter owns a 2018 Ford Edge. The contact stated that the dashboard was fractured near the front passenger's side air bag housing. The dealer was notified of the failure and informed the contact that the vehicle was not covered under warranty. The Manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 35,000.
POWER LIFTGATE FAILURE Recently, I put my hand on car to steady myself while my wife got my walker from the back of the car. she closed the hatch, but I had not lifted my hand and my finger was caught by the hatch. My wife immediately pushed the button on the hatch but it would not open. She then tried the dash button. It did not open. she started the car and tried the button and the hatch did not open, but did release just enough to release my finger. What if had been alone. 30,000 get their hands in car doors each year. what if this were a child and the hatch would not open. There are times where the hatch WILL NOT OPEN! There is no way to open the hatch manually. This very SERIOUS. There must be RECALL and Ford must replace existing controls with fail safe controls
Floor board got flooded with water! The back seam that is in the roof is faulty. The seam is above opening when lift gate is up ( not the seal around the gate). Front, midde and compartment with the spare was drenched. Water ran down the pillars ( nose was angled up). Ford refused to give any assistance. My concern is all the electrical components can be dangerous and the possibility of mold on the inside. Our 3/36 warranty has expired 4,000 miles ago and out on the time by around 6 mos. We have owned the ford less than a year and it has a clean history report. This is a part that should seal the roof. We have never touched it and until pointed out, wasn't aware of it. Other owners should be aware of this. What other damages can not be seen?
The trim pieces surrounding the front and sides of the moon roof fly off vehicle when driving. Has happened 3 times now, twice at speed when a large truck passed from opposite direction and once at medium speed it with no passing vehicle. These flying pieces pose a threat to nearby vehicles, motorcyclists and pedestrians. Dealer repair and body shop employees have seen the results when repairing. No warning lights or messages. In initial Ford Case # CAS24094836 (May, 2019) repair was covered under warranty. Second repair 8/13/2019 I had to escalate thru Ford Customer Care to get covered under extended warranty. This time the parts flew off soon after leaving dealer body shop so had to go back for 3rd repair. Fourth repair done 9/6/2022 done by local body shop.
The power lift gate on the back of my vehicle will unexpectedly shut or quickly drop closed. On multiple occasions I was removing items from the back of my vehicle when this happened, and I was struck by the lift gate causing injury. The first time I brought this to the dealer's attention was July 2019. They were unable to replicate the problem. This week, while once again removing items from the back of my car, the lift gate shut suddenly, this time crushing and cutting my wrist. My wrist immediately bruised and began bleeding. This was incredibly painful and days later is still not healed. This is a problem that is well documented by other Ford Edge owners in online forums, but that the dealer has still failed to acknowledge.
1. The lift gate has come down on top of me several times. I've had bruising on my legs and a headache because of the gate hitting me in the head. 2. There is an anti-freeze odor inside the car intermittently. The dealer tested for leaks but it was inconclusive. I'm taking it back to be tested again this week. 3. On two occasions, the navigation system has given verbal directions different than what it shows on the screen. The first time I thought I heard wrong. But the second time it happened I knew it wasn't my hearing. I have an appointment with the dealer to address this.
The glass sunroof has spontaneous wavy cracking throughout 50% of the front portion. I am concerned about the integrity of the glass, as well as the safety of myself and passengers in the vehicle. There was no apparent point of impact; it appears to be a tempering/temperature issue. No warning lights, messages, etc. were present. I noticed the issue upon opening the shade screen below the roof, which I haven't opened for a few weeks. I am not sure of the exact date that the cracking began. I will keep a close eye on it to see if the surface area increases.
Body complaints in other Edge years
Frequently asked questions
How common are body problems on the 2018 Ford Edge?
NHTSA has 20 complaints about the body & structure of the 2018 Ford Edge, 2% of the model year's 846 complaints. The component named most often is body (13 mentions).
Is there a recall for 2018 Ford Edge body problems?
No. NHTSA lists no body & structure recall for the 2018 Ford Edge, though it has 7 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2018 Ford Edge body problems start?
Half of the complaints with a recorded mileage happened before about 22,000 miles, and 56% before 25,000 miles.
Is it dangerous?
Owners linked 1 crash, 0 fires and 6 injuries to body & structure problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.