Most common 2018 Chrysler Pacifica Plug-In Hybrid problems
Share of the 224 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Chrysler Pacifica Plug-In Hybrid complaints by model year
Best Pacifica Plug-In Hybrid years: 2019, 2021, 2020. Years to avoid: 2022. Compare all years →
2018 Chrysler Pacifica Plug-In Hybrid recalls (6)
Hybrid propulsion system
Chrysler (FCA US, LLC) is recalling certain 2017-2018 Pacifica Plug-In Hybrid Electric (PHEV) vehicles that received a software update remedy under NHTSA recall number 22V-077. The battery pack may cause a vehicle fire when parked, even with the ignition in the "Off" position.
Remedy: Owners are advised not to charge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack control module (BPCM) software.
Hybrid propulsion system
Chrysler (FCA US, LLC) is recalling certain 2017-2018 Pacifica Plug-In Hybrid Electric Vehicles (PHEV). A vehicle fire can occur when parked, even with the ignition in the "Off" position.
Remedy: Owners are advised not to recharge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack control module (BPCM) software.
Electrical system › Wiring › Interior/under dash
Chrysler (FCA US LLC) is recalling certain 2017-2020 Pacifica Plug-in Hybrid Electric Vehicles ("PHEV"). The 12 volt isolator post located behind the driver's seat may develop high resistance.
Remedy: FCA will conduct a voluntary safety recall on affected vehicles to increase the torque and install a waterproof gasket to the 12v isolator post, the post will also be inspected for signs of contamination.
Suspension › Front › Control arm › Lower arm
Chrysler (FCA US LLC) is recalling certain 2018 Chrysler Pacifica and Pacifica hybrid vehicles. The right front lower control arm may separate from the steering knuckle.
Remedy: Chrysler will notify owners, and dealers will inspect the right front knuckle and lower control arm for damage, replacing the components as necessary.
Hybrid propulsion system
Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica Plug-in Hybrid Electric vehicles (PHEV). After the vehicle has been operating in PHEV propulsion mode, the gas-fueled engine may not restart properly resulting in unburned fuel entering the exhaust catalyst.
Remedy: FCA will notify owners, and dealers will update the powertrain controller module software, and inspect and replace the catalytic converter as necessary, free of charge. The recall began November 15, 2018.
Electrical system › Wiring › Front underhood
Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018…
Remedy: Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403.
NHTSA defect investigations
Federal safety investigators have looked into 4 possible defects involving the 2018 Chrysler Pacifica Plug-In Hybrid:
Loss of motive power due to an internal wiring connector short.
On July 22, 2022, the Office of Defects Investigation (ODI) opened investigation PE22-008 regarding complaints alleging a loss of motive power condition potentially due to a transmission malfunction in Model Years 2019-2021 Chrysler Pacifica Plug-In Hybrid Electric Vehicles (PHEV).
Ignition-off high voltage battery fire (Remedy effectiveness of Recall 22V-077)
On February 11, 2022, Fiat Chrysler Automobiles (FCA) issued a safety recall (NHTSA Recall 22V-077) on all 2017-2018 Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016 through August 7, 2018. The recall addresses ignition "OFF' fires that originate at the high voltage (HV) battery pack assembly.
Electrical arcing and thermal events, potentially leading to fires, while utilizing Enel X Way USA, LLC's JuiceBox residential charger.
On October 3, 2024, the Office of Defects Investigations (ODI) opened PE24028 to investigate alleged failures of Enel X Way's JuiceBox Level 2 residential EV chargers. The allegations were described as thermal incidents and electrical malfunctions, which could trip the circuit breakers in Juicebox owners' homes and disrupt electric vehicle charge cycles.
Transmission fault leading to loss of motive power
On July 22, 2022, the Office of Defects Investigation (ODI) opened PE22008 to investigate allegation of loss of motive power, potentially due to transmission malfunction, in certain Chrysler Pacifica vehicles. In a January 17, 2023 letter to NHTSA, Fiat Chrysler Automobiles (FCA) submitted recall notice 23V-010 involving a transmission motor wiring defect in 67,118 model year (MY) 2017-2023 Chrysler Pacifica plug-in…
What 2018 Chrysler Pacifica Plug-In Hybrid owners say
Fuel & propulsion system all 93 →
The contact owns a 2018 Chrysler Pacifica Hybrid. The contact stated that the vehicle was serviced under NHTSA Campaign Number: 22V077000 (Hybrid Propulsion System) however, after retrieving the vehicle from the dealer a failure was experienced. The contact stated that while his wife was parking the vehicle a warning light was illuminated with the "Check Hybrid System" message displayed. The contact stated that the vehicle was turned off and later restarted without issues. The contact stated that after his wife called him, he drove the vehicle home; however, while driving at approximately 35 MPH, the vehicle lost motive power without warning. The vehicle was able to restart 10 minutes later with no issues. The dealer was contacted, and the vehicle was taken back however, the failure could not be replicated. …
The contact owns a 2018 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 22V077000 (Hybrid Propulsion System). The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the dealer was contacted and confirmed that the part to do the recall repair was not available. The contact stated that the vehicle failed to charge while plugged in. The dealer was contacted but was unable to determine the cause of the failure, but stated that the failure might be related to the recall. The contact was informed that the vehicle could not be taken to the dealer for diagnostic testing because the recall remedy was not available. The contact stated that the vehicle was previously included and repaired under NHTSA Campaign Number: 20V334000 (Electrical System). …
Electrical system all 83 →
The contact owns a 2018 Chrysler Pacifica Hybrid. The contact stated that the vehicle was serviced under NHTSA Campaign Number: 22V077000 (Hybrid Propulsion System) however, after retrieving the vehicle from the dealer a failure was experienced. The contact stated that while his wife was parking the vehicle a warning light was illuminated with the "Check Hybrid System" message displayed. The contact stated that the vehicle was turned off and later restarted without issues. The contact stated that after his wife called him, he drove the vehicle home; however, while driving at approximately 35 MPH, the vehicle lost motive power without warning. The vehicle was able to restart 10 minutes later with no issues. The dealer was contacted, and the vehicle was taken back however, the failure could not be replicated. …
The contact owns a 2018 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 22V077000 (Hybrid Propulsion System). The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the dealer was contacted and confirmed that the part to do the recall repair was not available. The contact stated that the vehicle failed to charge while plugged in. The dealer was contacted but was unable to determine the cause of the failure, but stated that the failure might be related to the recall. The contact was informed that the vehicle could not be taken to the dealer for diagnostic testing because the recall remedy was not available. The contact stated that the vehicle was previously included and repaired under NHTSA Campaign Number: 20V334000 (Electrical System). …
Engine & cooling all 64 →
The contact owns a 2018 Chrysler Pacifica Hybrid. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The contact stated that the failure occurred immediately after the vehicle was repaired under NHTSA Campaign Number: 23V010000 (Electrical System, Hybrid Propulsion System). The vehicle was taken back to the dealer. The dealer requested that the vehicle be diagnosed and provided the cost for the diagnostic test. The contact declined to pay for a diagnostic test. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure and a case was filed. The failure mileage was 100,800.
The contact owns a 2018 Chrysler Pacifica Hybrid. The contact stated while driving at various speeds, the vehicle decelerated and failed to accelerate while depressing the accelerator pedal. The contact stated that the hybrid vehicle battery capacity warning light was illuminated. The contact stated that the check engine warning light also remained illuminated. The cause was not yet determined. The vehicle was not diagnosed or repaired. The manufacturer and local dealer were not notified of the failure. The failure mileage was 74,000.
Frequently asked questions
Is the 2018 Chrysler Pacifica Plug-In Hybrid a good car?
There isn't enough complaint history for the Pacifica Plug-In Hybrid to compare model years reliably. So far owners have filed 224 complaints with NHTSA.
What is the most common problem with the 2018 Chrysler Pacifica Plug-In Hybrid?
The fuel & propulsion system — 93 complaints, 42% of all complaints for this model year, most often about inverter. Next are the electrical system (83) and engine & cooling (64).
How many recalls does the 2018 Chrysler Pacifica Plug-In Hybrid have?
There are 6 recalls for the 2018 Chrysler Pacifica Plug-In Hybrid, the most recent from July 18, 2024 (hybrid propulsion system). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Chrysler Pacifica Plug-In Hybrid?
The best years by complaints, compared at the same age, are 2019, 2021 and 2020. Years to avoid or approach with caution: 2022. See the full Chrysler Pacifica Plug-In Hybrid years comparison.
At what mileage do 2018 Chrysler Pacifica Plug-In Hybrid problems happen?
The median mileage reported in complaints is about 7,000 miles; 89% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.