Which parts fail
Components named in complaints (doors, hood, frame, rust, paint and trim).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2011 Toyota Tacoma owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2011 Toyota Tacoma. The contact stated that while working underneath the vehicle, he noticed a hole in the frame rail, passenger's side, rear of the vehicle. The vehicle was taken to a local dealer where it was inspected under a Service Bulletin however, the vehicle was not repaired. The manufacturer was made aware of the failure; however, the manufacturer confirmed that the vehicle was no longer under Warranty for the repair and a case was opened. The vehicle was not repaired. The failure mileage was approximately 150,000.
The contact owns a 2011 Toyota Tacoma. The contact stated that while attempting to have an inspection completed on the vehicle, the contact was informed by the mechanic that the inspection could not be completed due to several holes in the underbody frame of the vehicle. The dealer was not contacted. The vehicle was not repaired. The manufacturer was informed of the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 168,000.
The contact owns a 2011 Toyota Tacoma. The contact stated that while performing a routine engine oil change, extensive corrosion was observed across the entire undercarriage. The severe rust damage fully compromised the vehicle's structural frame, control arms, and several underbody components. The dealer was not notified of the failure, but the vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 200,000.
The contact owns a 2011 Toyota Tacoma. Upon purchase of the vehicle, the contact received a Carfax report from the independent dealer that the vehicle had been placed under a service campaign for frame corrosion. The contact took the vehicle to a dealer where he was denied the service campaign because his vehicle was in a non-cold climate state. The manufacturer was also notified, and also denied his claim. The contact stated that he had discovered corrosion on the sub frame of the vehicle. The vehicle was not repaired. The failure mileage was unknown.
The underside of my 2011 Toyota Tacoma is experiencing tremendous rust. Dealer said since there was not perforation, nothing to be done. Brackets holding wiring, body panels and now gas tank have rusted and failed. The gas tank strap is a major concern. It is available for inspection. The gas tank is held up now by one unrusted strap and rubber bungee cords I applied. Dealer or independence service center has not seen it. Nearest dealer is a ferry ride away, I live on an island. No inspection by manufacturer etc. No warning lights or messages.
Toyota Tacoma was sprayed in 2020 for frame rust. Rust has began again on the frame. Also the suspension and behind the two rear wheels rust is rampant. Lots and lots of rust but no new holes since was sprayed. Pictures attached of the 2011 Toyota Tacoma with 68,000 miles.
This VIN number was totaled due to a bent frame after being rear ended on June 10th. I fear my insurance company (USAA) will attempt to commit fraud by not reporting the title as salvage.
The horn in my 2011 Toyota Tacoma quit working. I went to use it my horn, and it did not work. I've taken my truck to several places to see if it could be fixed. I have been reading where this is a common problem for many Toyota owners. Also, the white paint on my car is starting to flake off. The truck isn't even 10 years old and has been maintained. Yet again, there are thousands of consumers affected by this. Apparently there are two types of white paint that Toyota knows to be an issue on certain year models, but they have not issued a recall. Having a paint job is an expense that most can not afford! I could see if it was something that was caused from an accident or the owners fault, but this is ridiculous. Mine is starting to peel and flake on my passengers side door around the window. …
Tl* the contact owns a 2001 Toyota Tacoma. The contact stated that while driving approximately 15 MPH, the frame of the chassis fractured. The contact stated that the vehicle hit a bump in the road. The contact exited the vehicle to examine the failure. The contact noticed that the driver side of the chassis beam [frame] had become severely rusted and corroded to the point of fracture. The contact stated that the rust and corrosion was premature. The vehicle was taken to sloan Toyota of glenside (503 north easton road, glenside, pennsylvania 19038, [phone]) to be assessed. The dealer stated that the vehicle could not be lifted in the air for repair due to the significant damage of the chassis which would worsen the condition of the vehicle and cause potential risk to the service technician. The vehicle was not diagnosed or repaired. …
Tl* the contact owns a 2011 Toyota Tacoma. The contact stated that the vehicle's frame was rusted all the way around. The vehicle was taken to the dealer (Toyota of melbourne, 24 n harbor city blvd, melbourne, fl 32935, [phone]) where it was diagnosed and confirmed that the frame had rusted. The vehicle was not repaired. The manufacturer was notified of the failure and stated that it was fine for now, but would be an issue later. The contact was provided case number: 1807201377. The failure mileage was approximately 106,000.
Body complaints in other Tacoma years
Frequently asked questions
How common are body problems on the 2011 Toyota Tacoma?
NHTSA has 21 complaints about the body & structure of the 2011 Toyota Tacoma, 11% of the model year's 186 complaints. The component named most often is body (10 mentions).
Is there a recall for 2011 Toyota Tacoma body problems?
No. NHTSA lists no body & structure recall for the 2011 Toyota Tacoma, though it has 9 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2011 Toyota Tacoma body problems start?
Half of the complaints with a recorded mileage happened before about 86,000 miles, and 23% before 25,000 miles.
Is it dangerous?
Owners linked 2 crashes, 0 fires and 1 injury to body & structure problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.