Which parts fail
Components named in complaints (struts, shocks, control arms, ball joints, springs).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2011 Toyota Tacoma owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2011 Toyota Tacoma. The contact stated that while performing a routine engine oil change, extensive corrosion was observed across the entire undercarriage. The severe rust damage fully compromised the vehicle's structural frame, control arms, and several underbody components. The dealer was not notified of the failure, but the vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 200,000.
The contact owns a 2011 Toyota Tacoma. The contact stated that after taking the vehicle for repair, the contact was made aware of rust on the steering shaft and the support arms and the front end of the vehicle. The contact took the vehicle to the dealer and the contact was informed that there was no fix for the failure. The vehicle had not been repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 144,000.
I purchased the truck December 6th 2025 within a thousand Miles within the end of the year I experienced brake failure on the highway I laid under the truck to patch the brake failure and found a cracked leaf spring suspension component which there's already a recall for that exact make and model just not my VIN number for that cracked leaf spring there was a recall for frame rust and just rust in general and my brake lines rusted out but a certified technician from the used car dealership said it was safe and road Worthy I experienced a brake fire on the front calipers shortly after this brake failure the fire caused 7800 worth of damage I got quoted from Toyota to fix it and that doesn't cover the $2,000 worth of leaf springs which there was already an exact recall for this exact model of truck for the exact damage depicted but somehow my VIN is not applicable for this repair.
My vehicle failed the state of Maine safety inspection due to a broken leaf spring. I had the vehicle further inspected at a Toyota dealership and they reported the same issue. They gave me an estimate to replace the rear springs for a total cost to me of $2321.00. This an expense that I do not believe should have to bare, as this vehicle is only used for personal use. The heaviest load this vehicle has carried is a few bags of fertilizer.
The contact owns a 2011 Toyota Tacoma. While inspecting underneath the vehicle, the contact discovered that the vehicle was only equipped with three leaf springs instead of four. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and informed the contact that there was no recall for the failure associated with the VIN. The failure mileage was unknown.
2011 Tacoma, 4x4. Leaf spring is broken on the passenger side. 130,000 miles. According to Toyota my vin is not included under recall 14V-604. I do believe this is either an error or deliberate oversight to avoid responsibility. Manufacturer date 05/11 so according to the recall notice it falls within the date range but not the effected Vins.
Toyota Tacoma was sprayed in 2020 for frame rust. Rust has began again on the frame. Also the suspension and behind the two rear wheels rust is rampant. Lots and lots of rust but no new holes since was sprayed. Pictures attached of the 2011 Toyota Tacoma with 68,000 miles.
When servicing our truck, dealer has found both right and left rear leaf springs broken. There is a recall issued for 690,000 Tacoma trucks exactly like mine for the years of 2005 thru 2011 mine is a 2011 also, but they will not include my VIN #... As described by Toyota dealer and recall notices, this issue "could break , puncture the gas tank and cause a fire " . Dealer says " unsafe condition as if the remaining part of spring breaks the axle will no longer be secured under the vehicle" this truck is used under normal conditions w/no heavy hauling or towing why is it not being recalled ? This is not normal , putting myself and family in harms way ? What changed during production and assembly that my 2011 Tacoma was any different than the one behind it or in front of it during production , same model year ? Toyota will not answer that question , only to say " that VIN. …
Tl* the contact owns a 2011 Toyota Tacoma. While driving approximately 20 MPH, there was a loud unknown noise coming front the rear driver side of the vehicle. The contact coasted the vehicle to the side of the road a couple of times, but did not notice any failures. The contact stated that the failure recurred each time the brake pedal was depressed. The more the brake pedal was depressed, the louder the noise occurred. The vehicle was taken to an independent mechanic who diagnosed that the driver side leaf spring was detached and needed to be replaced. The vehicle was not repaired. The contact stated that the vehicle was taken to the rt 22 Toyota dealer (located on 109 us 22 hillside, nj), but was not diagnosed due to the diagnostic fees. The vehicle was not repaired. …
Tl* the contact owns a 2011 Toyota Tacoma. While the contact's wife was driving at unknown speeds, the driver heard clunking and banging noises. The contact looked underneath the vehicle and noticed that the middle leaf in the rear passenger side leaf spring failed and was fractured. The vehicle was taken to alderman's Toyota (33 seward rd, rutland, vt 05701) where it was diagnosed that the leaf failed and all four leaf springs needed to be replaced. The manufacturer was made aware of the failure and stated that the VIN was not included in NHTSA campaign number: 14V604000 (suspension); however, the contact would have to cover half of the repair cost.the vehicle was repaired. The approximate failure mileage was 64,500. Updated 08/24/17
Related recalls
Suspension › Rear › Springs › Leaf spring assembly › Leaf
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion.
Remedy: Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
Suspension complaints in other Tacoma years
Frequently asked questions
How common are suspension problems on the 2011 Toyota Tacoma?
NHTSA has 60 complaints about the suspension of the 2011 Toyota Tacoma, 32% of the model year's 186 complaints. The component named most often is rear (3 mentions).
Is there a recall for 2011 Toyota Tacoma suspension problems?
Yes — NHTSA recall 14V-604 (leaf, Sep 29, 2014). Recall repairs are free at authorized dealers.
At what mileage do 2011 Toyota Tacoma suspension problems start?
Half of the complaints with a recorded mileage happened before about 97,000 miles, and 6% before 25,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.