Which parts fail
Components named in complaints (doors, hood, frame, rust, paint and trim).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2004 Toyota Tacoma owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2004 Toyota Tacoma. The contact stated while driving 20 MPH and making a right turn, the vehicle lost motive power and stalled. There was no warning light illuminated. The contact was able to veer to the side of the road. The vehicle failed to restart after several attempts. The vehicle was towed to the dealer, where it was diagnosed that the Electronic Fuel Injection (EFI) main fuse had blown due to a short circuit. The dealer replaced the Electronic Fuel Injection (EFI) main fuse; however, the failure persisted. Additionally, the dealer diagnosed that the subframe was severely corroded, including transmission components and fuel system components. The manufacturer was notified of the failure and informed the contact that they could not assist as unknown recalls had expired. The vehicle was not repaired. The failure mileage was approximately 150,000.
The contact owns a 2004 Toyota Tacoma. The contact had taken the vehicle to Kolosso Toyota (3000 W Wisconsin Ave, Appleton, WI 54914) to have his exhaust replaced. While there, he was informed that the entire sub frame was corroded with several cracks and holes had formed around both front leaf springs. The mechanic informed him that the vehicle was unsafe to drive due to the failure. Prior to the failure, the contact took the vehicle to another local dealer where the vehicle was inspected under NHTSA Campaign Number: 05V225000 (Suspension). The contact was informed that a special coating was sprayed onto the sub frame to prevent corrosion; however, the recall remedy failed to prevent the corrosion. The manufacturer was contacted but provided no assistance. The vehicle was not repaired. The failure mileage was 51,641.
The contact owns a 2004 Toyota Tacoma. The contact stated upon taking the vehicle to an independent mechanic for a tire replacement, he was informed that the passenger's side subframe was severely corroded. The contact notified several unknown dealers of the failure. The dealers informed the contact that there was no recall associated with the VIN. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 233,000.
The contact owns a 2004 Toyota Tacoma. The contact stated that the underside of the vehicle started to flake and fall off in pieces. The vehicle was taken to a local dealer where it was diagnosed with needing the frame replaced however, the vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 165,000.
The contact owns a 2004 Toyota Tacoma. The contact stated that while looking underneath the vehicle, he noticed that the subframe was rusted. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 176,000.
The vehicle has an open recall (NHTSA Recall #12V542) for the spare tire carrier lift plate. I brought the vehicle to a Toyota dealership to have the recall addressed, but the dealership refused to perform the repair, stating that the frame is too rusted to proceed safely. They recommended a full frame replacement due to severe rust damage, which includes holes and significant structural weakening. Toyota has refused to provide a replacement frame under any existing recall or warranty program. This means the recall cannot be completed, and the vehicle remains unsafe to drive. Additionally, I cannot locate a replacement frame for this vehicle through Toyota or the aftermarket, leaving no practical solution to address the safety risks. The refusal to honor the recall and the lack of available replacement parts put me and others at significant risk. …
What component or system failed or malfunctioned, and is it available for inspection upon request? The whole frame, the chassis, it is rusty specially in the front How was your safety or the safety of others put at risk? when the rusty becomes worse, it will compromise the entire vehicle estructure, even the suspension and wheel parts. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, I can see Toyota run a recall process until 2019 Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No, just regular shop service, on which they reported high damage for the suspension and frame parts. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear?. It is making bad noises and suspension parts are difficult to replace
This vehicles frame has rusted and broken. I feel lucky to have made it home just as the frame cracked wide open on one side making the truck un-drivable. Had this happened on the freeway or somewhere out in a rural setting I may have been killed, caused a problem for other drivers or been stranded away from any help. I have sent a photo of the damage to a frame shop but an independent inspection is not, in my opinion, needed since the rusted, broken member is clearly visible to any lay person. There were no warning lights or anything associated with this problem. What I did feel was some serious shaking and bumping as I moved down the road toward my house.
Bought the vehicle in May 2022 from a dealer. By November of 2022 it was discovered that the frame was totally rusted. The dealer won't help so I paid $10,000 for a truck that lasted 6 months. I then found out this was a common problem that Toyota knew about so I called them for assistance. They would not help. I have been renting a vehicle at a cost of $800 a month because I don't have the money to buy another vehicle.
Financed a 2004 Toyota Tacoma and found that frame of truck is rusted out and not sure what to do, can't afford new frame and still owe a little over 9 grand for it....please advise what to do next. Thank u
Body complaints in other Tacoma years
Frequently asked questions
How common are body problems on the 2004 Toyota Tacoma?
NHTSA has 203 complaints about the body & structure of the 2004 Toyota Tacoma, 49% of the model year's 414 complaints. The component named most often is body (128 mentions).
Is there a recall for 2004 Toyota Tacoma body problems?
No. NHTSA lists no body & structure recall for the 2004 Toyota Tacoma, though it has 3 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2004 Toyota Tacoma body problems start?
Half of the complaints with a recorded mileage happened before about 119,000 miles, and 3% before 25,000 miles.
Is it dangerous?
Owners linked 5 crashes, 1 fire and 4 injuries to body & structure problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.