Which parts fail
Components named in complaints (doors, hood, frame, rust, paint and trim).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2010 Toyota Tacoma owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2010 Toyota Tacoma. The contact stated that the vehicle was taken for State Inspection however, the vehicle failed the inspection due to cracks to the driver's and passenger's side sub frame, and corroded brake lines. The vehicle was taken to an independent mechanic where it was diagnosed that both the driver's and passenger's side sub frame and brake lines needed to be replaced. The vehicle was not repaired. An undisclosed dealer was notified of the failure. The manufacturer was notified of the failure and the contact was informed that an unstated recall had expired, and the previous vehicle owner was notified, but no further assistance was provided. The failure mileage was approximately 132,000.
The contact owns a 2010 Toyota Tacoma. The contact stated that while the vehicle was with an independent mechanic for a scheduled service, the contact was informed that the frame underneath the engine was rusted. The contact was advised to take the vehicle to the dealer. The vehicle was taken to the dealer, where the contact was informed that an unknown recall associated with the failure had expired. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 100,000.
The contact owns a 2010 Toyota Tacoma. The contact stated that while the vehicle was in for inspection, the mechanic informed the contact that the entire subframe was rusted. The contact was advised that the vehicle was unsafe to drive due to the rust on the subframe. The cause of the failure was not yet determined. The vehicle was not repaired. The manufacturer and local dealer were contacted and informed the contact that the extended warranty for the failure had expired. No additional assistance was provided. The failure mileage was 49,000.
The contact owns a 2010 Toyota Tacoma. The contact stated while having a routine service check, the independent mechanic noticed that the subframe underneath the vehicle was rusted. The dealer was contacted and stated that the vehicle needed to be diagnosed. The vehicle was not diagnosed. The manufacturer was contacted, and a case was filed. No further assistance was provided. The failure mileage was 160,000. The consumer is requesting the recall to be honored so the vehicle can be repaired or replaced at a reasonable rate.
The contact owns a 2010 Toyota Tacoma. The contact stated that upon previous ownership; the vehicle was repaired under an unidentified NHTSA Campaign Number; however, the failure failed to prevent the failure from occurring. The contact stated that upon further inspection, the main frame of the vehicle had rusted. The local dealer was contacted; however, the vehicle was not diagnosed or repaired due to the cost. The manufacturer was made aware of the failure. The failure mileage was approximately 160,000.
The contact owns a 2010 Toyota Tacoma. The contact stated that while upon taking the vehicle for an annual inspection, he was informed that the sub frame was excessively corroded. The contact stated that the vehicle failed the State Inspection and was deemed unworthy to be driven on the road. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 75,000.
The contact owns a 2010 Toyota Tacoma. The contact stated that while the vehicle was at the local service center, the mechanic discovered that the sub frame was severely rusted. The contact was informed that the vehicle would soon become unsafe to driving due to the severe rust. The vehicle was not repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 183,000. The VIN was not available.
The contact owns a 2010 Toyota Tacoma. The contact stated that the sub frame was extremely rusted underneath the vehicle. The vehicle was taken to the local dealer, who informed the contact that there was no warranty coverage for the failure. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 138,000.
The contact owns a 2010 Toyota Tacoma. The contact stated that while the vehicle was receiving a routine oil change, the mechanic observed that the frame was corroded and fractured near the front passenger's side wheel. The contact was informed that the frame needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 120,000.
After the truck failed inspection on 10/21/2021 due to underlying rust on the frame, we went researching to find out why a vehicle would experience a severe issue like this. This internet research revealed serious frame rust issues on Toyota Tacomas from 2003-2011 and that Toyota was actually replacing Tacoma frames because they knew of the problem. The next step was calling a local Toyota dealership, which told us that Toyota is replacing frames for rust under what they call a "warranty extension," but it had just expired on 10/13/2021... 8 days prior to the failed inspection and they would no longer fix the problem. Before the failed inspection, we were never aware of this severe frame issue with many years of trucks... …
Body complaints in other Tacoma years
Frequently asked questions
How common are body problems on the 2010 Toyota Tacoma?
NHTSA has 30 complaints about the body & structure of the 2010 Toyota Tacoma, 10% of the model year's 294 complaints. The component named most often is body (17 mentions).
Is there a recall for 2010 Toyota Tacoma body problems?
No. NHTSA lists no body & structure recall for the 2010 Toyota Tacoma, though it has 13 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2010 Toyota Tacoma body problems start?
Half of the complaints with a recorded mileage happened before about 104,000 miles, and 18% before 25,000 miles.
Is it dangerous?
Owners linked 1 crash, 0 fires and 0 injuries to body & structure problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.