Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2023 Ram Promaster owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owned a 2023 Ram Promaster 2500. The contact stated that the employee had reported that the front end of the vehicle had caught on fire immediately after parking the vehicle. The vehicle was unoccupied at the time of the incident. The fire was extinguished by the fire department, which reported that the fire originated from the front end of the vehicle. There was no injury sustained. The contact stated that the front end of the vehicle had completely burned. The contact stated that the fire seemed to have originated near the engine compartment. The vehicle was towed to the residence and was totaled. No police report was filed. The dealer and the manufacturer were notified of the failure. The manufacturer informed the contact that they were not liable for the failure. The failure mileage was approximately 30,000.
On December 23, 2025, a 2023 RAM ProMaster 2500 Van used as a commercial fleet delivery vehicle in [redacted] suffered an engine compartment fire. The vehicle was declared a total loss by the insurance carrier. At the time of the fire, the vehicle was subject to open Safety Recall 25V-720 / Manufacturer Recall 67C, issued by FCA US LLC for a defective cooling fan module with premature bearing wear and inadequate fuse protection on the 400W fan circuit - the exact defect identified as a known fire risk. No remedy was available at the time of the incident. The interim recall notification letter had been received but the vehicle could not be repaired as FCA had not yet developed or made available a fix. The vehicle was inspected by insurance representatives and declared a total loss. …
The contact owns a 2023 Ram ProMaster 2500. The contact stated that the emergency control system was inoperable. While driving 3 MPH over a bump in the roadway, the steering wheel locked up. While driving 65 MPH, the failure recurred. Additionally, while reversing, the vehicle stopped suddenly. Prior to and after the failures, an unknown yellow warning light illuminated accompanied by an abnormal dinging sound. Additional warning lights illuminated associated with the steering, hill assist, and emergency control system, and an abnormal brake odor emanated from the vehicle. The contact stated that the failure was scary and dangerous. The vehicle was taken to a local dealer, where the contact was informed that there was a reset switch, and that the contact might have jerked the steering wheel. The dealer informed the contact that the vehicle was fully inspected. …
The contact owns a 2023 RAM PROMASTER. The contact stated while driving the vehicle at an undisclosed speed, while changing lanes the steering wheel is trying to drive the vehicle into another lane and barriers at times without the Collison avoidance system activating. The contact stated the collision avoidance system is very delayed or sometimes does not show up at all, he also stated that the Collison avoidance waring states it needs maintenance, the contact stated that the vehicle feels like it is close to tipping over and requiring a "death grip" on the steering wheel enable to keep it in control. The vehicle was taken to multiple dealers were they would not diagnose the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 43,518.
The contact owns a 2023 Ram Promaster 2500. The contact stated that while driving approximately 65 MPH, the message "Power Steering Service" was displayed with a high-pitched whining sound coming from underneath the hood and the dashboard. The vehicle was taken to the dealer, who diagnosed that the steering gear EPS module and jumper harness needed to be replaced, and the vehicle needed an alignment. The vehicle was not repaired. The contact researched online and associated the failure with NHTSA Action Number: PE26002 (Steering, Electrical System). The manufacturer was not informed of the failure. The failure mileage was approximately 40,000.
Without any warning my steering wheel locked up and started jerking resulting in lack of steering and drivability. I was backing out of my driveway and started to turn onto the street when this happened. This could have been very dangerous if I had been driving on regular roads. The van is currently parked on the street and available for inspection as I was able to gently maneuver it to a safe spot. This has been looked at by a mobile mechanic who put an OBD2 scanner on it and couldn't bring up any codes. It has not been taken to a shop at this point. The dealer said over the phone that this is not a powertrain warranty because it is not engine or transmission. It has not been inspected by the manufacturer, police, insurance. There were warning lights on the panel when this happened but they didn't stay on. …
While driving, a "Service ESC" warning message appeared and the vehicle suddenly lost power steering assist, causing the steering to become extremely difficult and creating a serious safety risk while the vehicle was in motion. The vehicle was taken to a service center, where technicians found multiple loss-of-communication codes involving the electronic power steering system. Further inspection found the main electronic power steering connector full of water and corroded. The technician documented that water intrusion caused excessive damage to the electronic power steering terminals at the rack-and-pinion assembly. The water intrusion appears consistent with a failure or inadequacy of the sealing intended to protect the electronic power steering connection from moisture. …
From purchase the UConnect system has faulted out and have effected items like Navigation, etc but wasn't a real problem. On 7/18 I had my dealer perform recall # 66B/NHTSA 24V-436 On 7/20 the UConnect system began faulting out but this time it started Disabling the Automatic Emergency Braking while driving, Disabled the parking brake when it was set, Indicated that various lights were not working when they were. The dealership worked on it extensively with the Corp service system reflashing the system, etc and it worked Ok for about 100 miles when the above problems have all started again. I have reviewed several social media sites and notice the UConeect system is very problematic. …
The vehicle's power steering does not work properly, especially at slow speeds and when attempting to back up. However, it has also failed while traveling on the interstate highway at high speeds. When you attempt to make a turn, the power steering feels like it is fighting you and wants to pull the vehicle back in the opposite direction. I took the vehicle in to be serviced, and they replaced the battery which removed previous warning messages. On two occasions, while traveling at slow speeds and making a turn into a shopping center parking lot, the vehicle resisted my attempt to make the turn such that had a car been coming out of the parking lot, rather than complete the turn, I would have run directly into the side of the other vehicle. …
Sometimes while driving I experienced my powered steering cut out while taking a ramp on/off of the highway, and sometimes when i was trying to park and back up into a parking space while steering at the same time. When the power steering cut out I got lights for "Service Power Steering", "Service ESC", and "Service Hill Assist" all at the same time, and once i got a power steering light. I looked up the issue and found that there is an active preliminary investigation going on for the same issue on the same vehicle, the investigation coded PE26002. Once I handed the vehicle over to the dealer, they found that the power steering had an open circuit on the steering gear. Once they took the connector off they found that the connector was corroded and the wires were burned on the steering gear and main harness side. I had to have them replace both the steering rack, and the main harness.
NHTSA investigations
Loss of Power Steering Assist
The Office of Defects Investigation (ODI) has received 19 Vehicle Owner Questionnaires (VOQs) alleging an intermittent or complete failure of the power steering assist system in certain Model Year (MY) 2022-2023 RAM ProMaster 1500, 2500, and 3500 vehicles. Failure of the power steering assist system can result in increased steering effort required to control the vehicle.
Electrical complaints in other Promaster years
Frequently asked questions
How common are electrical problems on the 2023 Ram Promaster?
NHTSA has 25 complaints about the electrical system of the 2023 Ram Promaster, 26% of the model year's 95 complaints.
Is there a recall for 2023 Ram Promaster electrical problems?
No. NHTSA lists no electrical system recall for the 2023 Ram Promaster, though it has 6 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2023 Ram Promaster electrical problems start?
Half of the complaints with a recorded mileage happened before about 40,000 miles, and 25% before 25,000 miles.
Is it dangerous?
Owners linked 0 crashes, 4 fires and 0 injuries to electrical system problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.