Which parts fail
Components named in complaints (wheels, lug nuts, original-equipment tires, TPMS).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2019 Ford F-250 SD owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owned a 2019 Ford F-250. The contact stated while driving 5MPH, the vehicle exploded and the fire was noticed by the neighbor. The fire was coming out the front wheel well and the engine. The contact stated no warning lights illuminated. The fire department extinguished the fire. The vehicle was not towed to the dealer. The vehicle remained at the contacts home unrepaired. The manufacturer was informed of the failure. The failure mileage was 13100.
The contact owns a 2019 Ford F-250 equipped with Cooper Tires, Tire Line: Discoverer AT3, Tire Size: 295/60/R20, DOT Number: (N/A). The contact stated that while driving 60 MPH and hauling a trailer, the vehicle jolted into oncoming traffic and started wobbling. The contact regained control of the vehicle and eventually steered to the side of the road and parked the vehicle. The contact became aware of a flat spot on the tire, and the spare tire was placed on the driver's side front. The contact continued driving, and the wobbling became controllable at speeds under 50 MPH. The vehicle was taken to the residence, where the contact observed that the driver's side front tire had tire separation in the middle of the tire. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The tire failure mileage was 37,000. The vehicle failure mileage was 52,000.
While driving this 2019 F-250 truck, all of a sudden the truck began to shake violently. Not only the whole truck, but the steering wheel was shaking violently as well. I was scared to death.This has happened on the interstate where I was in the left lane passing a tractor trailer and no sooner did I get passed then my truck began this "Death Wobble." I had no place to pull over to my left, so I had to pull right in front of the truck that I just passed, braking as hard as I could while moving to the right shoulder. An extremely dangerous situation. I can only imagine if this had happened to my wife! Fortunately, I had read about this condition prior to it happening. My truck only has 15,000 miles on it. This Death Wobble has been around since 2005 on Ford F-250 trucks, yet Ford and their dealers seem to pretend that they know nothing about it. …
Tire size LT285/75 R18 Component/System Failure: The front suspension and steering damper malfunctioned, leading to the "death wobble." This issue also caused excessive tire wear due to the violent vibrations and instability in the steering system. The components are available for inspection, and the worn tires and replaced parts can be provided if necessary. Safety Risk: The excessive tire wear, combined with the loss of steering control due to the wobble, significantly increased the risk of a blowout or loss of traction. At highway speeds, this made it difficult to control the vehicle, posing a serious risk to myself and others on the road. Problem Reproduced/Confirmed: Yes, the problem, including excessive tire wear and steering instability, was reproduced and confirmed by a Ford dealership service center during their inspection. …
I was driving on a 1200 mile trip with my 39ft camper. I came off an overpass bridge and my truck felt like both front tires had popped. My steering wheel was bouncing like crazy and luckily I was able to get the vehicle to a stop and off the road. My 2 children and fianc were also in the car and were lucky not to be killed. After stopping I looked over the truck and trailer and saw nothing wrong. We started to look up the death wobble on this model and it appears many people have also reported it. This truck only has 44k miles on it. I reported it to ford and they have made it clear that they will not be doing anything, other than allowing my extended service plan to replace the same parts if they find an issue. After talking with ford, I was driving my truck again without the trailer and the same thing happened. Luckily I was able to gain control of the truck again. …
My F250 started to shake uncontrollably while driving home from the airport on 26 September 2022. The vehicle has just over 20,000 miles on the odometer. The steering wheel shook out of my hands and I had to re-grab the steering wheel while driving at 50 mph. The shaking would not stop. I had to brake carefully because of traffic and pull off the to the shoulder. I merged back into traffic and it started to wobble uncontrollably again at 35 mph. I pulled over again and stopped. I merged back into traffic again and it did not happen again. Since it has just happened, I have not taken it to a Ford Dealership to get worked on. If traffic had not been lite, I am sure this issue would have caused an accident while I was driving 50 mph. I was very scared and was not anticipating this issue. There were no warnings. …
I was driving in the freeway approximately 70 mph when the truck drove over a small imperfection in the road and immediately started to shake violently and uncontrollably (often referred to as death wobble) I left off of the gas and as the vehicle slowed to 50 mph the shaking went away. This shaking is very violent and takes away from the drivers ability to control the vehicle in a safe manner amongst traffic on a busy freeway. Of the brake is pressed the shaking becomes worse until the vehicle slows. I took the truck to the dealer which the dealer advised that there was a recall on the steering dampener and replaced it stating that will relieve the truck of a death wobble . However, this did not fix the issue as I took it on the freeway and experienced the same exact issue. The truck has not been inspected by anyone other than the dealer. …
On 6/4/23 I was on SR 2 in Erie county ,Ohio. The speed limit was 70 mph and my cruise control was set at 70 mph & traffic was fairly heavy. I passed over an expansion joint and my steering wheel started shaking violently back and forth and the vehicle was nearly uncontrollable. The other vehicles near me fortunately saw I was having trouble and luckily they were able to steer clear of me. The only way I got it to quit was to veer to the shoulder, break hard and bring it to a complete stop. After gaining my composure I cautiously pulled back on highway with my warning lights on and did 40 mph to the next exit. Slowly made my way back home not knowing if it was going to reoccur. It was amazing that I or anyone near me wasn't injured or killed! If my wife would have been driving there is no way she would have been able to control it.
3rd time in a week- Death Wobbke while driving in heavy traffic. This is not safe!! No warning light ms our sounds- just starts violently shaking while driving out of the blue. In order to make it stop- you have to immediately slow down and pull over. This is challenging in that while driving at a high speed (within speed limits) on a major Hwy, you cannot just slow down immediately or pull over immediately. In addition, it happens so quickly and is so violent (major shaking and wobble) that you are taken off guard and driving becomes unsafe for ourselves and for drivers around you. Ford is aware of this problem. Our mechanics don't have a fix all solution. For the price you pay for this vehicle, the consumer should not have to pay for a fix like this, even if there was one. This is NOT safe.
Death Wobble: At speeds above 55mph the vehicle becomes uncontrollable after encountering bumps in the road that initiate the death wobble. The wobble becomes more uncontrollable until you can get the vehicle stopped - to zero mph. This was very dangerous in heavy Denver I25 traffic where your ability to stop was constrained by adjacent vehicles. It also occurred in construction zones with rough pavement and no shoulders or places to get off road. Having to hit the skids in the middle of freeway traffic posted with an 80mph speed limit, is life threatening, for my vehicle and the other drivers. Ford is well aware of this problem - the internet has many videos explaining how to fix it. Ford needs to get this done before someone is killed. I cannot drive the vehicle above 55mph.
Related recalls
Tires
Ford Motor Company (Ford) is recalling certain 2018 F-150, 2018-2020 F-250, F-350, and 2019 Escape vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.
Remedy: Ford will notify owners, and dealers will inspect the tires, and replace them as necessary, free of charge. The recall began on March 27, 2021. Owners may contact Ford customer service at 1-866-436-7332.
Wheel & Tire complaints in other F-250 SD years
Frequently asked questions
How common are wheel & tire problems on the 2019 Ford F-250 SD?
NHTSA has 91 complaints about the wheels & tires of the 2019 Ford F-250 SD, 8% of the model year's 1,165 complaints. The component named most often is rim (1 mentions).
Is there a recall for 2019 Ford F-250 SD wheel & tire problems?
Yes — NHTSA recall 21V-155 (tires, Mar 10, 2021). Recall repairs are free at authorized dealers.
At what mileage do 2019 Ford F-250 SD wheel & tire problems start?
Half of the complaints with a recorded mileage happened before about 20,000 miles, and 63% before 25,000 miles.
Is it dangerous?
Owners linked 1 crash, 1 fire and 0 injuries to wheels & tires problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.