Most common 2009 Ford F-250 SD problems
Share of the 23 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Ford F-250 SD complaints by model year
Best F-250 SD years: 2013, 2014, 2012. Years to avoid: 2019, 2017, 2018, 2020, 2016. Compare all years →
What 2009 Ford F-250 SD owners say
Engine & cooling
We own a 2009 Ford f250 super duty 4x4, with low miles (21478). This vehicle has run great since we purchased it new. As we were driving, the engine began to run poorly and loose power. The engine light then came on. The mechanic scanner the engine codes p0012-p0018-p0022-p0341-p052d, indicating faulty cam phasers and tensioners, and that the engine was out of time. This pickup has low mileage and all the recommended maintenance has always been done. The Ford parts department stated that they keep these parts stocked because it is a common repair issue.
My f-250 has had every brake caliper lock up and cause total brake system failure and repair. Starting at 40K miles it is out of warranty but there is an obvious defect in the design if every caliper has had this problem. My shop did a repair history search and found that the 2009s had a higher failure rate than other years. I also had the manifold warp and needed replacement at just 40K miles. Thanks - dan
Steering
Tl* the contact owns a 2009 Ford f-250 SD. The contact stated that the front end of the vehicle was unstable shook and vibrated excessively with an extreme wobble. The dealer was notified of the failure and was unable to provide a repair solution to prevent the failure. The contact took the vehicle to more than five different repair shops for various repairs, but the failures continued in the front and rear ends. The vehicle was not repaired and the contact was waiting to determine if the manufacturer would be able to provide a permanent repair solution. The approximate failure mileage was 180,000.
Tl* the contact owns a 2009 Ford f-250 SD. While driving 55 MPH over a pothole, the vehicle started to shake violently without warning. Once the speed was reduced, the vehicle stopped shaking. The vehicle was taken to the dealer. The technician replaced the track bar, ball joint, bushing, and the steering damper. The remedy failed to repair the issue. The manufacturer was made aware of the failure. The vehicle was not repaired. The failure mileage was 98,000.
Suspension
Tl* the contact owns a 2009 Ford f-250 SD. The contact stated that the front end of the vehicle was unstable shook and vibrated excessively with an extreme wobble. The dealer was notified of the failure and was unable to provide a repair solution to prevent the failure. The contact took the vehicle to more than five different repair shops for various repairs, but the failures continued in the front and rear ends. The vehicle was not repaired and the contact was waiting to determine if the manufacturer would be able to provide a permanent repair solution. The approximate failure mileage was 180,000.
Tl* the contact owns a 2009 Ford f-250 SD. While driving 55 MPH over a pothole, the vehicle started to shake violently without warning. Once the speed was reduced, the vehicle stopped shaking. The vehicle was taken to the dealer. The technician replaced the track bar, ball joint, bushing, and the steering damper. The remedy failed to repair the issue. The manufacturer was made aware of the failure. The vehicle was not repaired. The failure mileage was 98,000.
Frequently asked questions
Is the 2009 Ford F-250 SD a good car?
Based on 23 owner complaints filed with NHTSA, the 2009 F-250 SD rates better than average: 84% fewer complaints than a typical year of the F-250 SD at the same age. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2009 Ford F-250 SD?
The engine & cooling — 7 complaints, 30% of all complaints for this model year, most often about engine. Next are the steering (7) and suspension (7).
How many recalls does the 2009 Ford F-250 SD have?
NHTSA lists no recalls for the 2009 Ford F-250 SD. You can still confirm with your VIN using our VIN recall check.
What are the best and worst years of the Ford F-250 SD?
The best years by complaints, compared at the same age, are 2013, 2014 and 2012. Years to avoid or approach with caution: 2019, 2017, 2018, 2020 and 2016. See the full Ford F-250 SD years comparison.
At what mileage do 2009 Ford F-250 SD problems happen?
The median mileage reported in complaints is about 31,000 miles; 62% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.