Which parts fail
Components named in complaints (doors, hood, frame, rust, paint and trim).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2019 Ford F-250 SD owners, lightly cleaned up (personal details are redacted by NHTSA).
Tailgate has opened over 30 times while driving. Recall 19s48 was preformed but problem persists. Dealer has attemped to repair 7 times. Tailgate opened on freeway leaving dealership 5 minutes after tailgate recall rewiring service. A computer memory box was installed until tailgate opened again then dash mounted tailgate switch was replaced twice. Tailgate has been damaged and repaired by dealer when opened at highway speeds while towing and contacted my trailer turning to get off the road. Very unsafe condition since truck is used primarily for towing. When tailgate drops down on highway I cannot turn vehicle of will damage tailgate and/or trailer. This forces me to pull over in emergency lane and close tailgate while vehicles drive by at speed. …
The contact owns a 2019 Ford F-250. The contact stated that after he had parked his vehicle at a campsite, he had noticed that the heat shield was hanging off his vehicle. The contact then called the dealer and made an appointment to have the heat shield replaced. The contact was also informed that the heat shield had rubbed against the driveshaft which resulted in minor damage; however, the dealer determined that the vehicle was safe to be driven. The manufacturer had yet to be notified of the failure. The vehicle had been repaired. Recently, the contact discovered a recall for 2021 Ford F-150 vehicles which he linked to the failure; NHTSA Campaign Number: 21V986000 (Power Train, Structure) however, neither the VIN nor the Year/Make/Model were included. The failure mileage was 16,566.
The contact owns a 2019 Ford F-250. The contact stated that while driving approximately 15 MPH, the rear sliding glass window suddenly fell from the window frame and made contact with the granddaughter who was in a booster seat positioned in the middle of the rear seat. During the incident, the granddaughter sustained a head contusion that did not require medical attention. The cause of the failure was not determined. The vehicle was not yet repaired. The local dealer and manufacturer were notified of the failure. The failure mileage was 55,000.
The black plastic "roof rails" on the roof of my truck began cracking several months ago - I reported this to the dealership and just got excuses. I showed this to my dealership again on Friday and they said they would look into it. Today while driving the truck the entire roof rail came off and flew into traffic on the highway.. luckily no one hit it or did it cause a crash, etc. However when I did look this issue up on the internet it seems Ford already has an active recall for this type of problem on another model car, however google searching the issue with my truck I found hundreds of complaints on different bulleting boards, and the other problem is apparently Ford is not covering the replacement of this part, and the only way to replace it is to remove the rear window (which has also resulted in MANY shattered windows) Ford did a recall for a similar issue with the Ford Explorer …
I had the recall for the unintended tailgate opening fixed at the dealer in July of 2020. However on multiple occasions I noticed the the tailgate would open unintentionally. I thought it was my key fob in my pocket getting activated , but soon dismissed that theory. The tailgate would sometimes open when I am shifting from Park to Drive. Several times it would open when I release the E brake. I have contacted the dealer, but all they can offer is " we'll take a look at it"
The tail gate of my F250 drops inadvertently. It dropped while I was hauling a trailer and was severely damaged. Ford is repairing this damage and has replace the latch and wiring harness to prevent it from happening again however 1 day after the recall repairs were completed, the tail came down on its own yet again. The fix did not work. I notified the dealership and they said they would notify Ford.
When I left work my tailgate was closed and had not been opened for several days. When I got home, my tailgate was open and all my tools had fallen out of the truck. My truck was serviced 2 years ago for this type of issue. The repair needed to be done twice as the first time my tailgate would no longer open at all.
The back window shattered after turning on the rear window defroster. This put back seat occupants in harm. It impaired my vision. There were no warnings to this failure. My insurance company has been notified. Independent auto repair & glass repair shops have inspected the damage. Window must be replaced.
My tailgate has opened on its own twice in the last few weeks. Once while parked and locked in a parking lot. The second time I was driving while pulling a trailer and the tailgate bounced on the trailer jack for over an hour.
This is a new 2019 Ford 250 super duty truck. In February 2019 traveling at about 75 MPH( on a major highway) & I hit a groove and my front end went in to a horrible heavy head shake.it was not the first time but this was the worst by far. In dallas traffic surrounded on all sides. The only way to stop this head shake is by hitting the brakes hard. To do that on a major highway with traffic on all sides is horrifying. Took it to north central Ford and there is a damper recall (among others). They replaced the damper. These dampers are not much bigger than a golf club. Are not made or rated to support a truck with over a 10,000 lb weight limit. Now here we are in July and its back in the shop. Since March there has been 2/3 more upgrades to this damper. Because of the strong head shake? It ruined other things connected to damper (drag link/bushing). …
Related recalls
Structure › Frame and members › Underbody shields
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022.
NHTSA investigations
Power Tailgate Release Systems
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019.
Body complaints in other F-250 SD years
Frequently asked questions
How common are body problems on the 2019 Ford F-250 SD?
NHTSA has 21 complaints about the body & structure of the 2019 Ford F-250 SD, 2% of the model year's 1,165 complaints. The component named most often is body (17 mentions).
Is there a recall for 2019 Ford F-250 SD body problems?
Yes — NHTSA recall 22V-087 (underbody shields, Feb 16, 2022). Recall repairs are free at authorized dealers.
At what mileage do 2019 Ford F-250 SD body problems start?
Half of the complaints with a recorded mileage happened before about 17,000 miles, and 64% before 25,000 miles.
Is it dangerous?
Owners linked 1 crash, 0 fires and 1 injury to body & structure problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.