Most common 2019 Ford Explorer problems
Share of the 299 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Ford Explorer complaints by model year
Best Explorer years: 2024, 2023, 2019. Years to avoid: 2016, 2017, 2020, 2013, 2015. Compare all years →
2019 Ford Explorer recalls (6)
Structure › Body
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The roof rail covers may come loose and detach from the vehicle.
Remedy: Dealers will inspect the roof rail covers and as necessary, repair or replace the push-pins, rail clips, or roof rail covers, free of charge.
Suspension › Rear
Ford Motor Company (Ford) is recalling certain 2017-2019 Explorer vehicles. The rear suspension toe links may fracture.
Remedy: Dealers will replace the toe links, free of charge. Owner notification letters were mailed on March 16, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S08.
Equipment › Electrical › Engine block heater
Ford Motor Company (Ford) is recalling certain 2016-2018 Focus, 2019 Explorer, and 2024 Explorer vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge.
Structure › Body › Roof and pillars
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
Remedy: Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years.
Structure › Body
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The retention pins could loosen and allow the roof rail covers to detach from the vehicle.
Remedy: Dealers will install push-pins and replace any damaged rail clips and roof rail covers, as necessary, free of charge. The interim owner notification letter was mailed on June 22, 2021.
Seats › Mid/rear assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019.
NHTSA defect investigations
Federal safety investigators have looked into a possible defect involving the 2019 Ford Explorer:
Windshield trim molding Item detachment
On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has received 671 VOQs regarding this failure, including 1 alleged crash and 2 alleged injuries.
What 2019 Ford Explorer owners say
Body & structure all 150 →
The contact called on behalf of the owner of a 2019 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (STRUCTURE) and 26V101000 (SUSPENSION). The contact stated that after the vehicle was stopped at a traffic light, the vehicle stalled. The battery warning light was illuminated. The contact was able to restart the vehicle. The contact stated that the failure was occurring every other day. The vehicle was taken to an independent mechanic. The independent mechanic replaced the Manifold Absolute Pressure (MAP) sensor and an unknown sensor; however, the failure persisted. The contact stated that on a separate occasion, while the vehicle was idling, the vehicle stalled. The vehicle was restarted. The contact stated that while the temperature gauge was midway, the vehicle stalled. The battery warning light was illuminated. …
The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the driver's side windshield exterior A-pillar trim had detached. The vehicle was taken to the dealer, who inspected the vehicle and advised the contact to apply tape on the windshield trim. The contact stated that the trim was taped; however, while driving 65 MPH, the driver's side windshield exterior A-pillar trim separated from the vehicle. Additionally, the contact stated that the weather stripping around the windshield was detaching. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. …
Transmission & drivetrain all 35 →
The contact owns a 2019 Ford Explorer. While the contact's husband was driving at various speeds, the transmission was slipping. The contact stated that the failure mostly occurred while driving and depressing the accelerator pedal with the transmission shifting between second and third gear. There was no warning light illuminated. The vehicle was taken to the dealer and was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced; however, the vehicle was not repaired due to the cost. The vehicle was then taken to Pioneer Transmission Services, where the transmission was replaced. The contact stated that the transmission warning light illuminated while driving at an undisclosed speed. The vehicle was taken back to Pioneer Transmission Services, where the torque converter was replaced. The vehicle was repaired. …
The contact owns a 2019 Ford Explorer. The contact stated while driving approximately 60 MPH, the vehicle began making abnormal noises from under the floorboards. The contact stated that the vehicle was losing forward momentum. The contact depressed the accelerator pedal and the vehicle only revved and was not gaining forward momentum. The contact stated numerous warning lights were illuminated. The contact stated that he was able to reach his destination, but was not able to exceed 30 MPH. The contact was able to drive the vehicle to a dealer; however, the vehicle was not diagnosed or repaired. The contact stated that the transmission had been replaced a year prior and felt that the failure was related to the transmission. The manufacturer was not informed of the failure. The failure mileage was approximately 52,000.
Engine & cooling all 25 →
The contact owns a 2019 Ford Explorer. The contact stated that upon acceleration from a stop, the vehicle experienced a loss of automotive power. There were no warning lights illuminated. The vehicle was towed to a local dealer where it was diagnosed, and the contact was informed that the fuel pump and the fuel injectors were faulty and needed to be replaced. The vehicle was repaired; however, the failure persisted. The contact stated that on another occasion while driving 63 MPH, the vehicle lost automotive power. There were no warning lights illuminated. The vehicle was towed to a local dealer where it was diagnosed, and the contact was informed that the fuel pump and fuel injectors were faulty and needed to be replaced. The vehicle was repaired; however, the failure reoccurred while driving 72 MPH, and the vehicle lost automotive power. There was no warning light illuminated. …
The contact called on behalf of the owner of a 2019 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (STRUCTURE) and 26V101000 (SUSPENSION). The contact stated that after the vehicle was stopped at a traffic light, the vehicle stalled. The battery warning light was illuminated. The contact was able to restart the vehicle. The contact stated that the failure was occurring every other day. The vehicle was taken to an independent mechanic. The independent mechanic replaced the Manifold Absolute Pressure (MAP) sensor and an unknown sensor; however, the failure persisted. The contact stated that on a separate occasion, while the vehicle was idling, the vehicle stalled. The vehicle was restarted. The contact stated that while the temperature gauge was midway, the vehicle stalled. The battery warning light was illuminated. …
2019 Ford Explorer engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 2.3L 4-cyl turbo | 6-speed automatic | FWD | 19 / 27 / 22 |
| 2.3L 4-cyl turbo | 6-speed automatic | AWD | 18 / 25 / 21 |
| 3.5L 6-cyl | 6-speed automatic | FWD | 17 / 24 / 20 |
| 3.5L 6-cyl | 6-speed automatic | AWD | 16 / 22 / 19 |
| 3.5L 6-cyl turbo | 6-speed automatic | AWD | 16 / 22 / 18 |
EPA ratings. Class: SUV.
Frequently asked questions
Is the 2019 Ford Explorer a good car?
Based on 299 owner complaints filed with NHTSA, the 2019 Explorer rates better than average: 61% fewer complaints than a typical year of the Explorer at the same age. It is one of the best Explorer years by this measure. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2019 Ford Explorer?
The body & structure — 150 complaints, 50% of all complaints for this model year, most often about body. Next are the transmission & drivetrain (35) and engine & cooling (25).
How many recalls does the 2019 Ford Explorer have?
There are 6 recalls for the 2019 Ford Explorer, the most recent from July 14, 2026 (body). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Ford Explorer?
The best years by complaints, compared at the same age, are 2024, 2023 and 2019. Years to avoid or approach with caution: 2016, 2017, 2020, 2013 and 2015. See the full Ford Explorer years comparison.
At what mileage do 2019 Ford Explorer problems happen?
The median mileage reported in complaints is about 54,000 miles; 44% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.