Most common 2026 Ford Explorer problems
Share of the 42 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Ford Explorer complaints by model year
Best Explorer years: 2024, 2023, 2019. Years to avoid: 2016, 2017, 2020, 2013, 2015. Compare all years →
2026 Ford Explorer recalls (14)
Air bags › Frontal
Ford Motor Company (Ford) is recalling certain 2026 Explorer vehicles. The active vent on the passenger side may not open as intended, preventing the air bag from deploying properly.
Remedy: Dealers will replace the passenger air bag module, free of charge. Owner notification letters were mailed September 16, 2026. Owners may contact Ford customer service at 1-866-436-7332.
Engine and engine cooling › Engine › Hard parts internal/mechanical
Ford Motor Company (Ford) is recalling certain 2026 Explorer, Bronco, Bronco Sport, Mustang, and Ranger vehicles. The engine piston domes may have been manufactured incorrectly, which can result in piston dome failure and lead to a loss of drive power.
Remedy: Dealers will inspect the engine pistons and replace the engine long block, if necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed September 3, 2026.
Engine and engine cooling › Engine › Hard parts internal/mechanical
Ford Motor Company (Ford) is recalling certain 2026 Explorer vehicles equipped with a 2.3L engine. The engine connecting rod bearings may seize, which can result in engine failure.
Remedy: Dealers will replace the engine long blocks, free of charge. Owner notification letters were mailed August 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S58.
Seats › Front assembly › Power adjust
Ford Motor Company (Ford) is recalling certain 2025-2027 Explorer and Lincoln Aviator vehicles. An unoccupied driver's seat may recline unintentionally during certain scenarios, such as remote unlock or remote start.
Remedy: Dealers will disable the driver seat module (DSM) feature until parts are available. Once available, the motor will be replaced. Repairs will be performed free of charge.
Seats › Mid/rear assembly
Ford Motor Company (Ford) is recalling certain 2020-2027 Aviator and 2020-2026 Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, tipping, or sliding unexpectedly.
Remedy: Dealers will inspect and replace the bezel around the switch as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years.
Engine and engine cooling › Engine › Hard parts internal/mechanical
Ford Motor Company (Ford) is recalling certain 2025-2026 Explorer, Ranger, and Bronco vehicles. The engine may fail, which can result in a loss of drive power.
Remedy: Dealers will replace the engine long block, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 5, 2026.
Show 8 more recalls
Engine and engine cooling › Engine › Hard parts internal/mechanical
Ford Motor Company (Ford) is recalling certain 2026 Explorer and Mustang vehicles. The engine piston circlips may have been incorrectly installed during manufacturing, which can result in piston failure and engine damage, leading to a loss of drive power.
Remedy: Dealers will inspect the engine for missing or mis-installed circlips and replace the engine as necessary, free of charge. Owner notification letters were mailed April 10, 2026.
Visibility › Defroster/defogger/HVAC system › Fan/motor
Ford Motor Company (Ford) is recalling certain 2026 Lincoln Aviator and Explorer vehicles. The heating, ventilation and air-conditioning (HVAC) system may fail, which can cause the defrosting and defogging system to become inoperative.
Remedy: Dealers will inspect and secure the instrument panel joints as necessary, free of charge. Owner notification letters were mailed April 10, 2026. Owners may contact Ford customer service at 1-866-436-7332.
Seat belts
Ford Motor Company (Ford) is recalling certain 2020-2026 Explorer and Lincoln Aviator vehicles. The seat belt anchor bolts at the second-row outer seating positions may be improperly secured.
Remedy: Dealers will inspect the second-row outer seat belt lower anchor bolts and replace or repair them as necessary, free of charge. Owner notification letters were mailed March 30, 2026.
Exterior lighting › Headlights
Ford Motor Company (Ford) is recalling certain 2025-2026 Explorer vehicles. The Dynamic Bending Light (DBL) system software may cause the passenger-side headlight to turn in the wrong direction when driving through curves in the road.
Remedy: The headlight control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 23, 2026.
Visibility › Windshield
Ford Motor Company (Ford) is recalling certain 2026 Explorer vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash.
Remedy: Dealers will remove and replace the windshield, free charge. Owner notification letters were mailed January 30, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C02.
Engine
Ford Motor Company (Ford) is recalling certain 2026 Explorer, Mustang, Lincoln Corsair, and 2025 Maverick vehicles. The cylinder head may have been improperly manufactured, which can cause the ball plugs to fail, resulting in an oil leak.
Remedy: Dealers will replace the cylinder head assembly, free of charge. All affected vehicles are still within dealership inventory and therefore no owner notification letters will be mailed.
Visibility › Windshield
Ford Motor Company (Ford) is recalling certain 2025-2026 Lincoln Corsair, Lincoln Aviator, and Explorer vehicles. The windshield glass may have visible air bubbles, which can obscure the driver's visibility.
Remedy: Dealers will inspect and replace the windshield as necessary, free of charge. Owner notification letters were mailed November 6, 2025. Owners may contact Ford customer service at 1-866-436-7332.
Trailer hitches
Ford Motor Company (Ford) is recalling certain 2024-2026 Explorer and 2024-2026 Lincoln Aviator vehicles. The trailer hitch assembly bolts may be loose.
Remedy: Dealers will inspect and tighten the trailer hitch bolts, or replace them as necessary, free of charge. Owner notification letters were mailed October 29, 2025.
What 2026 Ford Explorer owners say
Electrical system
The contact owns a 2026 Ford Explorer. While the contact's wife was driving 60 MPH, the instrument cluster independently turned off. The vehicle was taken to the dealer where it was diagnosed with a software malfunction. The contact was informed that the unknown software needed to be updated. The vehicle was repaired; however, the failure reoccurred. In addition, the contact stated that only the fuel gauge and the speed odometer operated as needed. The vehicle was taken back to the dealer where the vehicle was diagnosed with an unknown software malfunction. The contact was informed that the software needed to be updated. The vehicle was repaired. The contact was informed that the software update was completed, and the system was rebooted. The contact was not satisfied with the repair. …
I had my car in drive in a parking spot. I was ready to go, put the car in drive, DID NOT MOVE but needed to put it in park fast to assist to a child in the back seat. I put it in park pretty fast. Took my seatbelt off and assisted child. It must have not engaged. Car rolled into my office metal mailbox. I 100% put it in park. I took my seatbelt off after so I seen it. It was fast with the gear shift though. Should this have been an issue? I feel like if it was any other car you with a manual gear shifter , not electrical, it's fine. I feel this was not my fault at all and was a malfunction of the car. The car did not automatically stop either. It hit the mailbox at like 3-4mph. I have never been in an accident of my fault in 10 years of driving. I've never made a crazy mistake like that. It should've never happened. I drive all types of cars/ and trucks. …
Seats
The contact owns a 2026 Ford Explorer. The contact stated that while attempting to make a left or right turn, the front passenger's side seat was moving from side to side. A dealer was contacted. The vehicle was taken to the dealer to be diagnosed; however, the diagnostic result was unknown. The contact was informed that that bolts were all connected. The vehicle was not repaired. The contact stated that the failure had occurred on several occasions. The manufacturer was notified of the failure and informed the contact he would receive a call back within 24 hours. The approximate failure mileage was 2,600.
The driver's memory seat has a serious malfunction. Whenever I enter the vehicle or switch between memory presets, the driver's seat unexpectedly reclines completely backward. This also crushes anyone sitting in the rear driver's-side seat, making it essentially unusable until we can return the driver's seat to its upright position. Even more concerning, the seat can begin reclining while I am driving, creating an obvious safety hazard. I recently learned that Ford has issued a recall for this exact issue. However, my vehicle was somehow excluded from the recall despite exhibiting the very same defect. My local dealership acknowledged that my car does show the problem listed on the recall and attempted to repair it by replacing the seat back and seat motor. Unfortunately, the replacement parts Ford supplied had the exact same malfunction. …
Engine & cooling
While driving my new Ford explorer, with 638 miles on it, on the highway I heard a loud pop, and lost power steering. I was barely able to pull the vehicle over to the shoulder to get off the highway. If I would have been on an interstate or a busier highway it could have been very dangerous. I believe that this has put me in danger having to maneuver the vehicle to the side of the highway and sit there while waiting for a tow truck. The Vehicle was towed to the dealership where we bought it. the service manager told us that the engine had blown, it was a catastrophic failure. There were holes in the oil pan as well as through the top part of the engine from it exploding. I believe that we are lucky that the engine wasn't hot enough to start a fire, as we were only a few miles from the start of our drive. there were no warning lamps or messages prior to the engine exploding. …
Description On your vehicle, it may be possible that one or more engine camshaft roller finger followers were not properly installed at the time of engine assembly. Safety Risk An improperly installed engine camshaft roller finger follower may result in engine failure, resulting in a no-start condition or a loss of motive power. A loss of motive power increases the risk of a crash. Your vehicle may also experience engine ticking or tapping noise, and or a low-volume oil leak due to this condition. Remedy A remedy is not yet available. Ford Motor Company is working to provide parts for this repair. When the remedy becomes available, Ford Motor Company will notify you via mail to schedule a service appointment with your dealer for repairs to be completed free of charge. The remedy is anticipated to be available 4TH quarter of 2026. …
2026 Ford Explorer engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 2.3L 4-cyl turbo | 10-speed automatic | RWD | 20 / 29 / 24 |
| 2.3L 4-cyl turbo | 10-speed automatic | 4WD | 20 / 27 / 23 |
| 3.0L 6-cyl turbo | 10-speed automatic | RWD | 18 / 25 / 21 |
| 3.0L 6-cyl turbo | 10-speed automatic | 4WD | 18 / 25 / 20 |
EPA ratings. Class: SUV.
Frequently asked questions
Is the 2026 Ford Explorer a good car?
Based on 42 owner complaints filed with NHTSA, the 2026 Explorer rates average: 19% fewer complaints than a typical year of the Explorer at the same age. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2026 Ford Explorer?
The electrical system — 9 complaints, 21% of all complaints for this model year, most often about instrument cluster/panel. Next are the seats (7) and engine & cooling (6).
How many recalls does the 2026 Ford Explorer have?
There are 14 recalls for the 2026 Ford Explorer, the most recent from September 9, 2026 (frontal). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Ford Explorer?
The best years by complaints, compared at the same age, are 2024, 2023 and 2019. Years to avoid or approach with caution: 2016, 2017, 2020, 2013 and 2015. See the full Ford Explorer years comparison.
At what mileage do 2026 Ford Explorer problems happen?
The median mileage reported in complaints is about 3,000 miles; 100% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.