Most common 2011 Ford Explorer problems
Share of the 1,197 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Ford Explorer complaints by model year
Best Explorer years: 2024, 2023, 2019. Years to avoid: 2016, 2017, 2020, 2013, 2015. Compare all years →
2011 Ford Explorer recalls (6)
Structure › Body › Roof and pillars
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
Remedy: Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years.
Suspension › Rear
Ford Motor Company (Ford) is recalling certain 2011-2013 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode…
Remedy: Dealer will inspect for the presence of a CABJ. If a CABJ of any design is found, the dealer will inspect the tightness of the CABJ, and replace the CABJ, knuckle, and/or toe link as necessary, free of charge.
Suspension › Rear
Ford Motor Company (Ford) is recalling certain 2011-2017 Explorer vehicles. The rear suspension toe links may fracture due to stress on the rear suspension.
Remedy: Ford will notify owners, and dealers will replace the rear suspension toe links, and inspect both rear toe link ball joints, replacing the rear wheel knuckle(s), if necessary, free of charge.
Structure › Body › Door
Ford Motor Company (Ford) is recalling certain model year 2011-2013 Explorer vehicles. In the affected vehicles, the interior door handle return spring may unseat, resulting in interior door handle that does not return to the fully stowed position after actuation.
Remedy: Ford will notify owners, and dealers will inspect all four of the interior door handles and either repair or replace them, free of charge. The recall began on July 23, 2015.
Steering › Electric power assist system
Ford Motor Company (Ford) is recalling certain model year 2011-2013 Ford Explorer vehicles manufactured May 17, 2010, through February 28, 2012. The affected vehicles may experience an intermittent connection in the electric power steering gear, which can cause a loss of the motor position sensor signal resulting in a shut down…
Remedy: Ford will notify owners, and dealers will update the Power Steering Control Module (PSCM) software, free of charge. If a vehicle shows a history of a loss of motor position sensor signal when the vehicle is brought in…
Seats
Ford is recalling certain model year 2011 explorer vehicles manufactured from July 15, 2010, through December 13, 2010, equipped with second row 60% seats with manual recliner mechanisms that May have components that are out of dimensional specification.
Remedy: Ford will notify owners and dealers will repair the seats free of charge. The safety recall began on February 15, 2011. Owners May contact Ford motor company customer relationship center at 1-866-436-7332.
NHTSA defect investigations
Federal safety investigators have looked into 4 possible defects involving the 2011 Ford Explorer:
Windshield trim molding Item detachment
On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has received 671 VOQs regarding this failure, including 1 alleged crash and 2 alleged injuries.
Ford Explorer Exhaust Odor
During the National Highway Traffic Safety Administration?s (NHTSA?s) investigation into the Ford carbon monoxide allegations, the Office of Defects Investigation (ODI) identified additional Vehicle Owner Questionnaire (VOQ) reports with similar exhaust odor claims.Presently, ODI has identified 791 VOQs for Model Year 2011-2017 Ford Explorers pertaining to exhaust odor claims.ODI has identified three crashes and 41…
Electric power steering failure
On May 27, 2014 and amended June 2, 2014, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 179,027 model year (MY) 2011 through 2013 Ford Explorer vehicles equipped with electric power assisted steering (EPAS), including 82,328 MY 2011 Explorersthat are the subject of PE12-017.Ford has…
Exhaust Odor in Passenger Cab
During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields.
What 2011 Ford Explorer owners say
Steering all 742 →
The contact owns a 2011 Ford Explorer. The contact stated that occasionally after starting the vehicle, the power steering functionality would be inoperable. The contact stated that after the vehicle warmed up, the power steering functionality would return. The contact stated that the failure was intermittent. The contact stated that on one occasion while his wife was driving 60 MPH, the steering wheel lost power steering functionality and started drifting to the right unintendedly. The contact stated that the driver's side of the vehicle crashed into the guard rails. There was no injury sustained. There was no further information provided. The contact stated that the steering wheel regained power steering assist and his wife was able to drive to the residence. …
The contact owns a 2011 Ford Explorer. The contact stated that while driving at an undisclosed speed around a curb, the power steering had failed and the steering wheel had become difficult to steer. In addition, the contact had crashed under a bridge and the front passenger side tire had blown. The "power steering service now", "terrain management system fault", and "service advanced trac" warning lights were illuminated. During the crash, there was a 4-year-old seated in the rear of the seat. No injuries were sustained. No police report was filed. The vehicle was towed to the residents where the tire was replaced. The vehicle was taken to a local dealer where it was diagnosed that the failure was related to an unidentified recall. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 150,000.
Body & structure all 110 →
The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the air bag warning light was illuminated. The vehicle was taken to the dealer for the air bag warning light being illuminated and the dealer diagnosed that the front passenger's side air bag sensor had failed and needed to be replaced. The dealer informed the contact that the part was ordered; however, the vehicle was not repaired. The dealer was contacted regarding NHTSA Campaign Number: 24V031000 (Structure); in February 2024 and the contact was informed there were no parts available for the recall repair. …
The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated while driving at various speeds, the rubber gaskets underneath the front driver's side and passenger's side of the windshield A-Pillar trims were flapping against the windshield. The vehicle was taken to the dealer, where it was determined that both trims needed to be replaced; however, the parts were not yet available. The vehicle was not repaired. The contact used tape to secure the trims. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000. Parts distribution disconnect.
Engine & cooling all 100 →
The contact owns a 2011 Ford Explorer. The contact stated that while driving at 45 MPH, the engine temperature hot warning light illuminated as the vehicle began to stall. The contact pulled off to the side of the road as a white smoke started coming from the vehicle. The contact waited for the vehicle to cool down before opening the hood and discovering that the coolant reservoir was empty. The contact added coolant in the reservoir; however, the vehicle failed to restart. The contact then called a family member who was able to jumpstart the vehicle; however, after several miles of driving, the failure recurred. The contact coasted the vehicle into a Walmart parking lot where she purchased more coolant; however, the coolant immediately leaked out of the vehicle. …
The contact owns a 2011 Ford Explorer. The contact stated that while driving approximately 35 MPH while turning right and exiting a ramp, then when idle a message stated "Low Oil Pressure" illuminated on the instrument panel. Shortly after the vehicle lost motive power. A certified mechanic inspected the vehicle and diagnosed that the camshaft sensor needed to be replaced. The vehicle was repaired. The failure reoccurred while test-driving the vehicle to determine if the repair was successful. The vehicle was re-examined and diagnosed that the water pump had failed causing the engine coolant and oil into the engine causing the engine to seize completely. The engine needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure and referred them to the NHTSA Hotline. The approximate failure mileage was 152,000.
2011 Ford Explorer engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 3.5L 6-cyl | 6-speed automatic | FWD | 18 / 25 / 20 |
| 3.5L 6-cyl | 6-speed automatic | 4WD | 17 / 23 / 19 |
EPA ratings. Class: SUV.
Frequently asked questions
Is the 2011 Ford Explorer a good car?
Based on 1,197 owner complaints filed with NHTSA, the 2011 Explorer rates average: 27% fewer complaints than a typical year of the Explorer at the same age. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2011 Ford Explorer?
The steering — 742 complaints, 62% of all complaints for this model year, most often about electric power assist system. Next are the body & structure (110) and engine & cooling (100).
How many recalls does the 2011 Ford Explorer have?
There are 6 recalls for the 2011 Ford Explorer, the most recent from January 19, 2024 (roof and pillars). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Ford Explorer?
The best years by complaints, compared at the same age, are 2024, 2023 and 2019. Years to avoid or approach with caution: 2016, 2017, 2020, 2013 and 2015. See the full Ford Explorer years comparison.
At what mileage do 2011 Ford Explorer problems happen?
The median mileage reported in complaints is about 70,000 miles; 38% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.