Which parts fail
Components named in complaints (wheels, lug nuts, original-equipment tires, TPMS).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2015 Ford Edge owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2015 Ford Edge. The contact stated while driving at 10 MPH, the vehicle's front driver's side wheel detached from the body which resulted in the contact losing control of the vehicle and crashing it into parked vehicles. No air bags deployed. The contact sustained neck and back pain. A police report was filed. The contact stated no warning lights were illuminated. The vehicle was towed to the insurance lot where it was not diagnosed. The vehicle was not repaired. The manufacturer was informed of the failure and was awaiting a response. The failure mileage was approximately 87,000.
The contact owns a 2015 Ford Edge. The contact stated that while driving 40 MPH, the rear passenger's side tire became flat, and the front passenger's side tire lost a significant amount of air pressure. The contact was able to drive to the residence. The vehicle was taken to the dealer, where all four tires were replaced with brand new tires; however, the failure recurred a week later. The vehicle was taken back to the dealer, where the deflated tires were resealed; however, the failure recurred a month later. The vehicle was taken to the dealer, where it was diagnosed and determined that the rims were corroded. The dealer cleaned the corroded rims and resealed the tires; however, the failure persisted. The vehicle was taken back to the dealer, where the contact was informed that the rims and the seal on the rims were defective, causing the tires to deflate. …
The contact owns a 2015 Ford Edge. The contact stated that while the vehicle was in for service, the mechanic discovered that the lug nuts were deformed and very difficult to remove from the wheels. The failure was present on the lug nuts on all four wheels. The cause of the failure was not yet determined. The manufacturer and local dealer were not contacted. The failure mileage was 48,000.
After experiencing a flat tire on an Interstate, we discovereed the Ford-supplied lug wrench could not fit over the lug nuts without the person helping laying across a lane on the interestate and kicking the lug wrench over the lug nut. And, then, disengaging the lug wrench took extreme effort. The person helping me could have been killed by traffic ignoring the position of my car. There is ample reference to the lug nut problem on Google'd Web pages. The lug nuts on our Edge have not been inspected, yet. No warning lamps apply to this problem.
My vehicle only has 74K miles and the Ford dealership told me I need to replace all lug nugs because they are swollen and will need to be broken off. This is a $200 cost at the dealership for replacement. If purchased at store it is $60 plus someone to change them out. No way at $74k miles this should happen. I've seen many other posts about the same this with this years model. Also since I have aluminum rims, the lugs are hard to locate anywhere. They must have the "mushroom" offset with long attachment.
Ford dealer told me the lug nuts were a bad two piece design and he has had to replace many of them by drilling out the studs and replacing them. Encouraged proactively replacing the 2 piece lug nuts with a new one piece design for a cost of $128 for 4 tires. Not covered by warranty/extended but this seems ridiculous for a vehicle that's 6 yrs old. I see lots of references on the internet to this issue. Seems like a straightforward bad design and obvious recall issue.
Ford dealer told me the lug nuts were a bad two piece design and he has had to replace many of them by drilling out the studs and replacing them. Encouraged proactively replacing the 2 piece lug nuts with a new one piece design for a cost of $128 for 4 tires. Not covered by warranty/extended but this seems ridiculous for a vehicle that's 6 yrs old. I see lots of references on the internet to this issue. Seems like a straightforward bad design and obvious recall issue.
the lug nut caps will not come off and no tire store in our area can get them off without charging an arm and a leg. what if we were on the road with a flat tire? my husband is [redacted] and i'm [redacted] . there is no way we'd be able to get the wheel off to change it. what if we had no cell service and a driver who is a criminal stops to "help".
According to Bob Tomes Ford in McKinney, Texas, they are unable to rotate the tires on my vehicle because the lug nuts are swollen and would have to be cut off and replaced to fix. This leaves me with an unsafe vehicle and an inability to change the tire should I have a flat.
The factory installed lugs nuts have become swollen and now the lug nut wrench which is provided by Ford does NOT fit the lug nuts! If I tried to change a flat tire I would be unable to do this since the lug nut wrench does NOT fit the lug nuts!!!!
Wheel & Tire complaints in other Edge years
Frequently asked questions
How common are wheel & tire problems on the 2015 Ford Edge?
NHTSA has 24 complaints about the wheels & tires of the 2015 Ford Edge, 3% of the model year's 731 complaints. The component named most often is lugs/nuts/bolts/studs (6 mentions).
Is there a recall for 2015 Ford Edge wheel & tire problems?
No. NHTSA lists no wheels & tires recall for the 2015 Ford Edge, though it has 7 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2015 Ford Edge wheel & tire problems start?
Half of the complaints with a recorded mileage happened before about 76,000 miles.
Is it dangerous?
Owners linked 1 crash, 0 fires and 1 injury to wheels & tires problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.