Which parts fail
Components named in complaints (fuel pump, injectors, fuel tank, hybrid and EV propulsion).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2016 Volkswagen Jetta owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owned a 2016 Volkswagen Jetta. The contact stated that while driving at 15-25 MPH, she smelled a strong burning gas odor. The contact veered to the side of the road. The contact felt an intense heat on her legs. The contact saw a flame on the driver's side of the hood and quickly exited the vehicle. The contact stated that there was also fire underneath the driver's side of the hood. The fire was extinguished with the assistance of the fire department. There were no injuries sustained. A fire department report was filed. The vehicle was towed to a tow lot, where it was totaled. A police report was not filed. The contact became aware that her VIN was included in NHTSA Campaign Number: 20V648000 (FUEL SYSTEM, GASOLINE). An unknown dealer was notified of the failure. The manufacturer was notified of the failure but did not provide any assistance. …
The contact owns a 2016 Volkswagen Jetta. The contact stated upon entering the vehicle, there was a strong gasoline odor. Additionally, the vehicle experienced a rough start. The electronic power control (EPC) and check engine warning lights were illuminated. The contact was able to drive the vehicle; however, the gasoline odor became stronger and stronger while driving and the vehicle would not exceed 20 MPH. The contact veered to the side of the road. The contact's father met her on the side of the road and upon inspecting the vehicle, he noticed that gasoline was leaking out of the fuel rail upon starting the vehicle. The vehicle was towed to the dealer, where it was diagnosed that the fuel rail needed to be replaced. …
The contact owns a 2016 Volkswagen Jetta. The contact stated while driving approximately 65 MPH, the vehicle lost motive power and stalled. The contact stated that the check engine warning light and EPC warning light was illuminated. The contact pulled over to the side of the roadway. The contact was able to restart the vehicle however, the vehicle would not accelerate above 15 MPH. The contact stated that there was an abnormally strong gasoline odor inside the cabin of the vehicle. The contact had the vehicle towed to a dealer where it was diagnosed and determined that the fuel rail and fuel injectors needed to be replaced. The vehicle had been repaired; however, the failure recurred. The contact had the vehicle towed to the same dealer. The vehicle had not been repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 160,000.
The contact owns a 2016 Volkswagen Jetta. The contact stated that the vehicle failed to exceed 30 MPH while driving. The ignition, the check engine, the ABS, and the camshaft warning lights were illuminated. Additionally, the contact stated that after refueling the vehicle, the vehicle failed to restart as needed. The contact stated that the vehicle started temporarily and shut off after several attempts. The vehicle was towed to the residence. The contact notified the dealer the vehicle was purchased from of the failure. The dealer informed the contact that the warranty had expired. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 71,000.
The contact owns a 2016 Volkswagen Jetta. The contact stated while driving 25 MPH and attempting to merge into another lane, the accelerator pedal was depressed but the vehicle hesitated to respond. There was no warning light illuminated. The contact stated that the failure reoccurred while driving. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed nor repaired. The failure mileage was approximately 52,000.
My car started on fire as driving to work January 21 2022 at 7:30 am.After researching after the fire Not knowing how and why that happened car had been perfectly fine no warning signs or any difference with the way it drove , I came to find out about fuel rail recall on my car that will cause car to start on fire .I almost and could have got stuck in the car which as i panicked was having trouble getting safety belt off and the door is so heavy that it had always closed back on me getting my leg smashed.I have not got any update from Manny the VW Man he ignores my calls and only left a message in response to my request to customer service i have lost my job because i do not have a car now my son has been missing school now about to be getting evicted as soon as the eviction lift is up i have 5 children i am a single widowed mother and need a car i was still paying on my car for 3 and a …
The problem happens when the car is on, and when attempting to accelerate the car will feel like it was put into neutral and you cannot do anything other than coast. The car has done this a few times while driving. Also, when trying to accelerate from a stop at a signal light, the car can suddenly stall, and you won't be able to do anything. From a safety standpoint, this is very bad since if you had to quickly accelerate to avoid a collision or other possible scenario and the car won't move, or accelerate, to reach speeds on a freeway or highway. Problem occurred last night when attempting to accelerate and merge onto the highway, felt like the car was in neutral ('D' light was blinking as well as the 'Hybrid' light). What is concerning is that VW did know about this problem and they only did a recall for very small number of vehicles. …
I brought my car in for the 60k service and the check engine light had just turned on. After being told they had to run a diagnostic and keep my car for several days, the dealership came back with "it had a fault for a purge valve. Tested the purge valve with a vacuum tester and found it would not hold a vacuum." I was asked if my emissions was due soon, but I had emissions completed two months ago with no problems. This issue is a big deal and I know VW has had many public issues with their emissions. I barely drive this car and to have such a major issue occur is mind blowing. The dealership quoted me $890. for this repair when I see the average cost of this repair is about $300-400 with parts. I had it completed, but no one wants to talk to me about why I was charged so much when this technically should be a recall.
When driving the car, it will randomly stall, lose power or not accelerate. Sometimes the EPC light and oil light will illuminate other times it gives no warning. It shut off on the interstate while going 72mph. I have taken it to the dealership since a month after I got it and they keep telling me nothing is wrong with it. I have to get oil changes every month despite not driving it much and the gas consumption is 3tines what it should be. I'm having to fill the tank up three times a week despite going to and from work which is 9 miles from my home. I have taken it to the dealership and had to pay $1000s of dollars only for it to start having the same issues within a week
Even after having the fuel system replaced due to recall, I'm still smelling gas inside of my car. My EPC light and Check Engine light keep coming on and don't always stay on but when it comes on, while driving... my car will tell me to downshift and then there is no throttle, you can mash the gas pedal to the floor and only dash lights. It has also skipped the downshift indicator and just cut completely off while driving.
Related recalls
Fuel system, gasoline › Fuel injection system › Fuel rail
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2016-2018 Jetta vehicles. The fuel rail bolts may become loose over time, allowing fuel to leak.
Remedy: Volkswagen will notify owners, and dealers will replace the fuel rail bolts and, as necessary, the fuel rail. The recall began March 31, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298.
Fuel system, gasoline › Fuel injection system › Fuel rail
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2016 Jetta vehicles manufactured October 31, 2015, to January 21, 2016, 2016 Passat vehicles, equipped with 1.8T engines manufactured November 13, 2015, to December 9, 2015, and 2016 Golf vehicles manufactured November 5, 2015, to November 11, 2015.
Remedy: Volkswagen will notify owners, and dealers will replace the cylinder heads, free of charge. The manufacturer has not yet provided a notification schedule.
Fuel System complaints in other Jetta years
Frequently asked questions
How common are fuel system problems on the 2016 Volkswagen Jetta?
NHTSA has 35 complaints about the fuel & propulsion system of the 2016 Volkswagen Jetta, 22% of the model year's 161 complaints. The component named most often is fuel injection system › fuel rail (1 mentions).
Is there a recall for 2016 Volkswagen Jetta fuel system problems?
Yes — NHTSA recall 20V-648 (fuel rail, Oct 21, 2020); NHTSA recall 16V-403 (fuel rail, Jun 6, 2016). Recall repairs are free at authorized dealers.
At what mileage do 2016 Volkswagen Jetta fuel system problems start?
Half of the complaints with a recorded mileage happened before about 47,000 miles, and 18% before 25,000 miles.
Is it dangerous?
Owners linked 2 crashes, 2 fires and 1 injury to fuel & propulsion system problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.