Most common 2016 Toyota Tacoma problems
Share of the 324 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Toyota Tacoma complaints by model year
Best Tacoma years: 2014, 2015, 2020. Years to avoid: 2024, 2016, 2025, 2012, 2017. Compare all years →
2016 Toyota Tacoma recalls (4)
Equipment
Southeast Toyota Distributors, LLC (SET) is recalling certain 2011-2016 Toyota Tacoma and 4Runner vehicles equipped with accessory hood scoops installed by SET or SET dealers. The adhesive attaching the hood scoop may weaken, allowing the hood scoop to detach from the vehicle.
Remedy: SET will notify owners, and dealers will mechanically fasten the scoop to the hood, free of charge. The recall began on September 1, 2017. Owners may contact SET customer service at 1-954-429-2000.
Engine
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2016-2017 Tacoma vehicles equipped with a six-cylinder engine. The affected vehicles have a crank position sensor that may malfunction, potentially resulting in an engine stall.
Remedy: Toyota will notify owners, and dealers will replace the crank position sensor with an improved design, free of charge. The recall began July 26, 2017. Owners may contact Toyota customer service at 1-800-331-4331.
Power train › Driveline › Differential unit
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2016-2017 Tacoma vehicles. Oil may leak from the area where the rear differential carrier is assembled to rear axle housing.
Remedy: Toyota will notify owners, and dealers will inspect the rear differential for oil leakage. Based on the inspection, dealers will either tightening the fastening nuts or replace the fastening nuts and gasket.
Air bags › Knee bolster
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2016 Tacoma trucks manufactured August 20, 2015, to September 10, 2015. In the affected vehicles, incorrect bolts were used to install the driver's knee air bag module.
Remedy: Toyota will notify owners, and dealers will install the correct driver's knee air bag module mounting bolts, free of charge. The recall began on November 19, 2015.
NHTSA defect investigations
Federal safety investigators have looked into a possible defect involving the 2016 Toyota Tacoma:
Electrical overstress
The Office of Defects Investigation (ODI) opened this investigation to determine if the failure of airbags to deploy during severe crashes, in certain vehicles, was the result of a safety related defect. During the investigation a complex failure was studied that can result in non-deployment of subject vehicle air bags and other restraint system devices in severe crash events.
What 2016 Toyota Tacoma owners say
Transmission & drivetrain all 136 →
The contact owns a 2024 Ford Edge. The contact stated that the vehicle was shaking while driving. The contact noticed there was fluid emerging from the rear of the vehicle near the tire. There were no warning lights illuminated. The vehicle was taken to the local dealer, who confirmed there was no recall or leak. The vehicle was not repaired. The manufacturer was contacted, who referred to the local dealer. The failure mileage was approximately 100,000.
I have three signifcant issues with my Tacoma: 1. A few months after purchasing my Tacoma in 2016 Toyota (no accidents to date & 95% highway driving) and one outside alignment shop had never been able to get the truck aligned properly so it would never keep its alignment more than 3-4 months; repeated visits to Toyota maintence for alignment over the years became as routine as an oil change, sometimes more frequently; the unaligned suspension constantly was causing unsafe handling and unintentional swerving. 2. Toyota missed, and maybe purposefully, identifying major engine, transfer case, and transmission leaks during regular and routine serivces (always serviced at Toyota dealerships) until my mileage exceeded 60,000 miles. Then when I asked the dealership to recheck a recent transfer case refresh because I saw leaks, I needed and got over $3,000 in repairs e.g. …
Engine & cooling all 47 →
I have three signifcant issues with my Tacoma: 1. A few months after purchasing my Tacoma in 2016 Toyota (no accidents to date & 95% highway driving) and one outside alignment shop had never been able to get the truck aligned properly so it would never keep its alignment more than 3-4 months; repeated visits to Toyota maintence for alignment over the years became as routine as an oil change, sometimes more frequently; the unaligned suspension constantly was causing unsafe handling and unintentional swerving. 2. Toyota missed, and maybe purposefully, identifying major engine, transfer case, and transmission leaks during regular and routine serivces (always serviced at Toyota dealerships) until my mileage exceeded 60,000 miles. Then when I asked the dealership to recheck a recent transfer case refresh because I saw leaks, I needed and got over $3,000 in repairs e.g. …
Upper Intake manifold flap actuator ( part: Toyota 17190-0P101 ) brakes in the intake resulting in wrong air reading and forcing vehicle into limp mode causing the vehicle to rapidly decrease speed, and creating a potential accident with other vehicles and semi's. this will continue to happen but this will give a person a false sense of security since error codes will reset once vehicle is turned off and on, a reassurance to a person that the issue has resolved itself since this will only happen at high speeds. the part is designed for fuel efficiency, as the flap opens and closes air is controlled properly for emission, but once broken will throw error codes, and force vehicle into limp mode this part is not be repairable, the part needs to be changed completely. this would happen to me while accelerating on highways, up mountain passes and pushing vehicle over 4000 rpm.
Electrical system all 37 →
The contact owns a 2016 Toyota Tacoma. The contact stated while driving at 60 MPH, the contact noticed their front driver seat warmer stop operating and started smelling an electrical burning. The contact continued to drive to their residence where at that time the contact inspected the vehicle and noticed the seat heater amp connection wiring was burned out. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 63,404.
Driver's side front seat not delivering heat despite switch lamp indicating it's on and working. Further exploration reveals passenger side seat heater working as it should. I checked wiring harness and connections under driver's seat only to discover plastic connector entering amplifier scorched and melted with two of four pins destroyed (Red and Green wires). I believe the wire gauge sized for this system is improper and therefore represents a fire hazard. About the time the seat heater failed, I smelled a burning odor inside the car for a short time but didn't associate the two events until later. The vehicle has 135,998 miles on it and therefore out of warranty. I spoke to the dealer who explained he's had similar issues from other customers and added there is no recalls at this time.
2016 Toyota Tacoma engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 2.7L 4-cyl | 6-speed automatic | RWD | 19 / 23 / 21 |
| 3.5L 6-cyl | 6-speed automatic | RWD | 19 / 24 / 21 |
| 2.7L 4-cyl | 6-speed automatic | 4WD | 19 / 22 / 20 |
| 2.7L 4-cyl | 5-speed manual | 4WD | 19 / 21 / 20 |
| 3.5L 6-cyl | 6-speed automatic | 4WD | 18 / 23 / 20 |
| 3.5L 6-cyl | 6-speed manual | 4WD | 17 / 21 / 19 |
EPA ratings. Class: Small pickup.
Frequently asked questions
Is the 2016 Toyota Tacoma a good car?
Based on 324 owner complaints filed with NHTSA, the 2016 Tacoma rates avoid: 2.1× as many complaints as a typical year of the Tacoma at the same age. It is one of the Tacoma years we suggest avoiding. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2016 Toyota Tacoma?
The transmission & drivetrain — 136 complaints, 42% of all complaints for this model year, most often about driveline › differential unit. Next are the engine & cooling (47) and electrical system (37).
How many recalls does the 2016 Toyota Tacoma have?
There are 4 recalls for the 2016 Toyota Tacoma, the most recent from July 3, 2017 (equipment). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Toyota Tacoma?
The best years by complaints, compared at the same age, are 2014, 2015 and 2020. Years to avoid or approach with caution: 2024, 2016, 2025, 2012 and 2017. See the full Toyota Tacoma years comparison.
At what mileage do 2016 Toyota Tacoma problems happen?
The median mileage reported in complaints is about 15,000 miles; 81% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.