Which parts fail
Components named in complaints (struts, shocks, control arms, ball joints, springs).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2007 Toyota Tacoma owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2007 Toyota Tacoma. The contact received notification of NHTSA Campaign Number: 14V604000 (SUSPENSION); and the vehicle was taken to a local dealer for the recall repair; however, the dealer declined to service the vehicle because of the excessive rust on the subframe of the vehicle. The contact was informed that the subframe needed to be replaced before the recall repair could be performed. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 198,000.
The contact owns a 2007 Toyota Tacoma. The contact stated while inspecting the vehicle, he noticed that the rear suspension subframe was corroded and had fractured. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 140,000.
Over the years, Toyota has had to issue numerous recalls for their Toyota Tacomas and frame replacements/maintenance required by Toyota due to rust and corrosion. However, Toyota chose not to replace all frames, instead decided to "treat" the issue with underspray. My Toyota, like many others, has received the recalled Toyota undercoat spray to prevent rust and corrosion on a frame with known issues (once in 2015, another in 2019). I have just received a phonecall from my mechanic that my frame is now unsafe to drive and needs to be fixed or replaced. However, Toyota has claimed they have no guarantee on the vehicle and it isn't there problem because it is outside of the timeframe. However...this car DID participate in their recall 2x. …
Purchased my 2 tacoma in 11/24 second party learned of leaf spring tested and failed sent me home in rent a car demanding it back 2 min upon my arrival home due to the frame was damaged. Said they put it up on lift but didn't it was too dangerous. Had to he my vehicle out of their shop Saturday morning without the fix. Driving it off the lot from toyota Pittsfield Massachusetts. Called another toyota she sees in 16 it was inspected with recall but never fixed. I know if a pervious owner was aware who wouldn't get a fix for free? It came from an auction, a.dealership according to history. With no reports of it ever being fixed. I believe from much research this is the second recall for leaf springs. It was never explained to be except via text that it was terrible w insulation shoved in parts. Who had done it I'm not sure. CT. …
I was totally aware of the recall for these year models of Tacoma and I brought the truck in several times to have the frame inspected and asked for it to be replaced. The folks at Dorschel Automotive group turned me away saying it did not meet the "rust perforation standard." Lo and behold, when Dorschel was bought by Bob Johnson Auto Group, the first time I took it in they recognized that the frame was entirely rotted and would not pass inspection. At this point, I called Toyota Customer Service and they said they would not honor the recall as it is outside the window of time. Yet this is not a matter of me not taking proper action. I did. I did my due diligence and I am being harmed by the negligence of the service managers at Dorschel. I made Toyota aware that the frame inspection was not done properly. I could see visible rust and I made mention of that. …
Yesterday, 7/27/2022, I had my 2007 Toyota Tacoma Access Cab at my mechanic's shop for a minor issue. While on the lift he noticed significant rust on the frame rails. He brought me over and showed me extensive areas where the metal was completely rusted through. I have never seen anything like this on even the oldest of vehicles. Subsequently I did a search online and found that this was a known issue for many years of Tacoma truck frames, but I was never notified by Toyota or anyone including the local Toyota dealer where I have had services done. I cannot believe a company as well established as Toyota would allow such a potentially serious problem to go unaddressed. Toyota should be held responsible for selling defective and dangerous vehicles and be required to effect repairs as soon as possible completely at their cost. …
Frame is completely rusted. the rear gas tank strap where it attaches to the frame corroded through and the strap dropped and was dragging on the ground. the gas tank also dropped and made it difficult to remove the gas cap. upon further inspection the frame is completely rusted through in spots. in 2014 a rust protective coating was applied by a dealer. it did nothing to stop the rust it just covered it. the steel is delaminating underneath the coating. It was just a band-aid to get them out of warranty period. these frames should have been a full recall. the strap could of easily hit the ground and bounced up and punctured a brake line or the gas tank. with it sparking on the ground a fire could of happened. The tacoma is in immaculate condition except for the frame. this is my 4th toyota and the only one that has had a problem.
It was determined by the Toyota dealer where this vehicle was purchased that there are rust holes in the frame. This vehicle's mileage is less than 100,000 miles. I understand there was a recall at one time however the Toyota dealership advised that this truck was not one of the vehicles in the recall at that time. This truck has always been garaged, has low miles and well maintained. You would think it would be able to be driven another 150k miles. This is a safety issue and I don't feel I should be penalized for taking good care of this vehicle. It is a known fact within the industry that Toyota used bad steel for their frames during this year if manufacture. Please advise what you can do to remedy this situation. Thank you
I purchased NEW a Toyota 2007 Tacoma, After year of ownership I found heavy surface rust around the chassis and hardware components. I went to dealership and they stated that it was surface rust and were not able to rustproof . After 10 years I was assigned to SMA in FT Bliss TX were I was for 12 months on Active duty orders . Once I return and picked up truck from storage I found chassis completely rusted with several areas that were in critical need of repair. I contacted Toyota and was informed I missed the cut off date for recall repair . I will be repairing on my own but its a injustice that there is a such monetary preference than safety of the consumer who purchase vehicle out right for the reliability .
I tried to take my 2007 Toyota Tacoma for a recall about the leaf springs to Modern Toyota in Winston-Salem, NC. Modern Toyota took my truck for inspection, but upon return, informed me the would not replace the component nor were the obligated to do so.
Related recalls
Suspension › Rear › Springs › Leaf spring assembly › Leaf
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion.
Remedy: Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
Suspension complaints in other Tacoma years
Frequently asked questions
How common are suspension problems on the 2007 Toyota Tacoma?
NHTSA has 118 complaints about the suspension of the 2007 Toyota Tacoma, 22% of the model year's 541 complaints. The component named most often is rear (6 mentions).
Is there a recall for 2007 Toyota Tacoma suspension problems?
Yes — NHTSA recall 14V-604 (leaf, Sep 29, 2014). Recall repairs are free at authorized dealers.
At what mileage do 2007 Toyota Tacoma suspension problems start?
Half of the complaints with a recorded mileage happened before about 97,000 miles, and 13% before 25,000 miles.
Is it dangerous?
Owners linked 1 crash, 0 fires and 0 injuries to suspension problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.