Which parts fail
Components named in complaints (automatic and manual transmissions, CVT, axles, driveshaft, 4WD/AWD).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2015 Toyota RAV4 owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2015 Toyota Rav4. The contact stated while driving approximately 25-50 MPH, the vehicle was vibrating. There were no warning lights illuminated. The contact was able to continue to drive the vehicle. Additionally, the contact stated that the failure mainly occurred while depressing the accelerator pedal. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the torque converter needed to be replaced. The vehicle was then taken to the dealer where it was diagnosed that the torque converter needed to be replaced. The dealer informed the contact that the vehicle could not be repaired under an unknown extended warranty for the torque converter as the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure and advised as the dealer. The failure mileage was approximately 140,000.
The contact owns a 2015 Toyota Rav4. The contact stated that while driving at speeds between 20-30 MPH the vehicle had experienced a severe shutter and vibration coming from the rear end and the vehicle would not properly accelerate. The vehicle was taken to the local dealer who diagnosed that the torque converter was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure but no assistance was offered. The failure mileage was 120,000
The contact owns a 2015 Toyota Rav4. The contact stated while driving 40 MPH and attempting to accelerate, the vehicle started to hesitate. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the torque converter. The vehicle was repaired, but the dealer informed the contact that if the failure reoccurred, the transmission would need to be replaced. The manufacturer was not notified of the failure. The failure mileage was 112,000.
Our Torque convertor went in our RAV4. There is a warranty bulletin on this issue for our make/year and our vehicle fell within the years and mileage needed to be covered by this warranty but when we asked Toyota to repair it under the warranty they told us that our VIN was not on the list for free repair. We recently had our local certified mechanic replace the torque convertor out of fear if we waited for VIN to show up on list further damage would be done. We sent a certified letter to Toyota Corp along with our invoice for repair and asked if they would reconsider and cover us under warranty and the answer is no. The reason for this complaint is to document the fact that we had faulty parts and even though the vehicle met all the guidelines needed for free repair, we were still denied. The warranty bulletin is #POL17-06 this covers models 2013-2015 up to 150,000 miles. …
The battery is off . It does not work. The car does not start. It looks like the battery is not properly installed. I just left my car at the Toyota dealership in June 12 for maintenance services, for brake fluid and flush etc including the replacement of a battery mounting hardware however it does not look right. The car started to go off and today it does not start at all. Please advice Sincerely, [redacted]
While driving on the interstate the transmission stopped working. There was no indication that anything was wrong with the transmission. It was working fine and suddenly would not engage in any gear. This was a new OE transmission replaced six months ago for the same issue, with less than 9,000 miles on the new unit. I had to coast from the middle lane to the side of the interstate in heavy traffic.
Ever since I purchased it, it had a shudder between 20-50 miles. Called the dealer, they said it was normal with these cars. 6 years after and still making shudder noise just louder now and it bothers my ears. Took it in for a diagnostic at the same dealer I bought it and they said it's not a torque converter issue (a bulletin was issued), but a transmission issue and it will cost $6.100 to repair.
Toyota dealer in the area says transmission fluid does not need to be serviced unless we tow trailer and etc. Well the transmission broke down and we need to put a remanufactured one. This could be fatal incident if vehicle quits on busy highway.
The power stick shift moves to easily out of gear. It requires only a light depressing of the break to disengage it. On May 17 2019, I had been parked with the car on. I had dropped something on the floor and went to pick it up. My foot was lightly touching the break as I bent down. The break was depressed just enough to allow my shoulder or back to hit the stick shift and push it into reverse. Unbenounced to me, as I was still bending over to pick something up, the car was pushed into reverse and moved backwards into two cars behind me. This could have been a really tragic situation had someone been behind me in the parking lot. Or worse, if I had a child in the car and I had gotten out to get something from the trunk and the child jumped into the drivers seat. …
Toyota poorly designed the torque converter for this vehicle leading to future transmission failure prematurely! I have had two torque converters replaced due to them failing!!! A torque converter when it fails pushes metal shavings into the transmission leading to transmission failure most manufacturers when a converter fails they check the transmission and if there is shavings they replace it. I had my torque converter replaced under a a special program through Toyota but it only covered the torque converter and no additional parts. I had to have my axle replaced twice and my seal after torque converter replacement covered by the dealership not even Toyota warranty under the torque converter recall or special program. …
Transmission complaints in other RAV4 years
Frequently asked questions
How common are transmission problems on the 2015 Toyota RAV4?
NHTSA has 25 complaints about the transmission & drivetrain of the 2015 Toyota RAV4, 8% of the model year's 305 complaints. The component named most often is automatic transmission › torque converter (2 mentions).
Is there a recall for 2015 Toyota RAV4 transmission problems?
No. NHTSA lists no transmission & drivetrain recall for the 2015 Toyota RAV4, though it has 4 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2015 Toyota RAV4 transmission problems start?
Half of the complaints with a recorded mileage happened before about 42,000 miles, and 31% before 25,000 miles.
Is it dangerous?
Owners linked 3 crashes, 0 fires and 1 injury to transmission & drivetrain problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.