Most common 2015 Toyota RAV4 problems
Share of the 305 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Toyota RAV4 complaints by model year
Best RAV4 years: 2014. Years to avoid: 2019, 2020, 2021, 2024, 2025. Compare all years →
2015 Toyota RAV4 recalls (4)
Electrical system › 12V/24V/48V battery
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners.
Steering › Electric power assist system
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2015 Camry, Camry Hybrid, Highlander, and Highlander Hybrid, and 2014-2015 Rav4 vehicles. A component of the electric power steering (EPS) electronic control unit (ECU) may have been damaged during the manufacturing process.
Remedy: Toyota will notify owners, and dealers will inspect the serial number of the EPS ECU or steering column assembly. If the number is within the affected range, the EPS ECU will be replaced, free of charge.
Trailer hitches
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015.
Equipment
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2014-2015 Toyota 4Runner, Tacoma, FJ Cruiser, Land Cruiser, RAV4, Scion FRS, and XB vehicles. The affected vehicles may have accessories installed by SET, such as running boards or other items, that were incorrectly installed.
Remedy: SET will notify owners, and dealers will inspect and tighten the affected bolts, free of charge. The recall began February 23, 2015. Owners may contact SET customer service at 1-866-405-4226.
NHTSA defect investigations
Federal safety investigators have looked into a possible defect involving the 2015 Toyota RAV4:
Battery Hold Down Bracket Thermal Events
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE.
What 2015 Toyota RAV4 owners say
Electrical system all 85 →
The contact owned a 2015 Toyota RAV4. The contact stated that while the vehicle was parked in his driveway, he observed black smoke emanating from the engine compartment. Shortly afterward, the vehicle became engulfed in flames originating from the engine compartment. Local emergency services arrived and were able to extinguish the flames. No warning lights were illuminated. A fire report was filed. A police report was not filed, and no injuries were reported. The vehicle remained at the contact's residence but was deemed a total loss by his insurance provider. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V734000 (Electrical System), and the VIN was included, but parts were not yet available. The manufacturer was notified of the failure but did not assist. The failure mileage was 34,000.
The contact owned a 2015 Toyota Rav4. The contact stated that after pulling into the driveway after driving for approximately 30 minutes, the contact parked and exited the vehicle. The contact stated that approximately 10 minutes later there was a loud explosion heard. The contact looked out to see the vehicle on fire. The fire department was called and extinguished the fire. The contact was unsure if a fire report was filed. The vehicle was deemed a total loss. The cause of the failure was unknown. There were no injuries sustained. Neither the dealer nor the manufacturer was made aware of the failure. The approximate failure mileage was 123,000. The VIN was not provided.
Steering all 47 →
The contact owns a 2015 Toyota Rav4. The contact stated while driving 50-55 MPH, the vehicle lost power steering functionality, and the steering wheel became difficult to turn. The power steering warning light was illuminated. The contact was able to pull to the side of the road by using physical strength to steer the vehicle. The contact stated that upon turning off and restarting the vehicle, the power steering became functional. The contact was able to continue driving. The vehicle was taken to an independent mechanic, where the failure was linked to NHTSA Campaign Number: 15V144000 (Steering); however, the vehicle was not diagnosed or repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and informed the contact that the VIN was not included in the recall. The failure mileage was approximately 118,000.
The contact owns a 2015 Toyota Rav4. The contact stated that while driving at 30 MPH, the power steering warning light appeared on the instrument panel as the power steering assist failed to operate as needed. The contact used excessive force to steer the vehicle to the side of the road. The contact called a friend for assistance but once the friend arrived, the warning light had disappeared, and the vehicle was driven back to the residence. Several days later, the same failure returned while driving at 30 MPH. The vehicle was driven to the dealer where the vehicle was diagnosed with a defective steering shaft. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 15V144000 (Steering). The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 112,000.
Engine & cooling all 37 →
The contact owned a 2015 Toyota Rav4. The contact stated that while his wife was driving and making a right turn the vehicle loss motive power and stalled without warning. The contact stated that his wife coasted to the side of the road, restarted the vehicle, and several unknown warning lights flashed on the instrument panel and then disappeared. While driving through the drive-thru at McDonalds his wife was notified by an employee of an abnormal burning odor. While pulling out of the drive-thru, the vehicle stalled. The driver restarted the vehicle and pulled into a parking space and the vehicle caught on fire underneath the hood. The contact stated that after his wife removed the child from the vehicle there were a series of explosions. The Fire Department was called out and the fire was extinguished. A fire report was filed. …
The contact owns a 2015 Toyota Rav4. The contact stated that while his daughter was driving at an undisclosed speed, the steering wheel was inoperable and all the warning lights illuminated. The steering wheel was seized and the vehicle lost motive power in the middle of the street. The contact's daughter noticed the vehicle was smoking from under the hood. The contact's daughter exited the vehicle and the vehicle caught on fire. The fire department arrived and extinguished the fire. A fire or police report was not filed. The vehicle was towed to the tow yard. The insurance company declared the vehicle a total loss. The contact was informed of NHTSA Campaign Number: 23V734000 (Electrical System), however, the contact stated he did not receive the recall notification. The manufacturer was not made aware of the failure. The failure mileage was approximately 70,000.
2015 Toyota RAV4 engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 2.5L 4-cyl | 6-speed automatic | FWD | 23 / 30 / 26 |
| 2.5L 4-cyl | 6-speed automatic | AWD | 22 / 28 / 25 |
EPA ratings. Class: Small SUV.
Frequently asked questions
Is the 2015 Toyota RAV4 a good car?
Based on 305 owner complaints filed with NHTSA, the 2015 RAV4 rates average: 1.3× as many complaints as a typical year of the RAV4 at the same age. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2015 Toyota RAV4?
The electrical system — 85 complaints, 28% of all complaints for this model year, most often about ignition. Next are the steering (47) and engine & cooling (37).
How many recalls does the 2015 Toyota RAV4 have?
There are 4 recalls for the 2015 Toyota RAV4, the most recent from November 1, 2023 (12v/24v/48v battery). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Toyota RAV4?
The best years by complaints, compared at the same age, are 2014. Years to avoid or approach with caution: 2019, 2020, 2021, 2024 and 2025. See the full Toyota RAV4 years comparison.
At what mileage do 2015 Toyota RAV4 problems happen?
The median mileage reported in complaints is about 35,000 miles; 63% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.