Most common 2012 Toyota Prius problems
Share of the 424 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Toyota Prius complaints by model year
Best Prius years: 2021, 2020, 2018. Years to avoid: 2011, 2010, 2007, 2006, 2008. Compare all years →
2012 Toyota Prius recalls (6)
Hybrid propulsion system
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019.
Air bags › Side/window
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016.
Seats › Front assembly › Seat heater/cooler
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010…
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016.
Electrical system › Software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge.
Equipment › Other › Labels
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011…
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed.
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and…
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013.
NHTSA defect investigations
Federal safety investigators have looked into 3 possible defects involving the 2012 Toyota Prius:
Brake Actuator Valve Wear
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights.
Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles.
Brake Actuator Valve Wear
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s).
What 2012 Toyota Prius owners say
Brakes all 200 →
I have had a 2012 Prius since 2016. The entire time I've had it, it occasionally "hydroplanes" but without any water. It happens in wet or dry (but mostly dry) conditions. Usually at slower speeds so, though it makes me very uncomfortable, it doesn't happen with any regularity. I've taken it multiple times to my mechanic who always says "Prius' just do that", which is not reassuring. I know there was a recall and I was told my car did not fall under that umbrella. On Wednesday of this week, 10/25/23, I finally had an accident because of this. The brake lockup had been happening more frequently in the past week and in this instance I saw the car in front of me suddenly slow down - I had about 2/3 of a cars distance between me and the car ahead. I hit the brakes and nothing happened. I was pushing down on them long enough to think, "Ok, this is it. …
While pulling out of a parallel parking spot going slightly uphill, I braked as I looked around the back of a double parked truck. I saw a car coming, braked hard, and suddenly my car surged forward across the street and hit a parked car. I looked down and saw that my foot was squarely on the brake pedal pressing down as hard as I could. The parked car was unoccupied, and I was uninjured. There were no warning lamps, messages, or other symptoms of the problem. I turned my car into the dealer for repairs and a fix to the sudden unexpected acceleration. They could offer no fix until a Toyota representative examined the car. On August 14, by an emailed letter, Toyota claimed it found no defects and it must be the result of driver error, specifically, my mistakenly hitting the accelerator. This is gaslighting denialism. …
Electrical system all 52 →
The engine caught fire while sitting in my garage. I had driven it for a few hours doing deliveries for a store and parked it in my garage around 2:30pm. About 1.5 hours later, my wife was coming home and opened the garage door and saw smoke above the hood of my car and then a few seconds later it burst into flames. I believe that it was smouldering for a while and the gust of wind when the big garage door opened gave it the extra push to ignite. The car was bought used and had a front end accident prior to my purchasing it so the electrical system could have melted and started the fire but the inspector that Toyota sent did not give me any copy of his report. It is a 2012 model. I bought the car in 2014, and had it for about 5 years until this happened and completed burned up the car and all the contents of my garage. …
The contact owns a 2012 Toyota Prius. The contact stated while attempting to use the horn, the horn failed to operate as needed. The contact also stated that the front passenger's air bag warning light illuminated and then turned off. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the clock spring failed and needed to be replaced. The vehicle was also taken to an independent mechanic who confirmed the cause of the failure. The vehicle was not repaired. The manufacturer informed the contact that the vehicle was not included in the manufacturer communications regarding the clock spring assembly repair. The vehicle was not repaired. The approximate failure mileage was 90,000.
Lights all 36 →
The contact owns a 2012 Toyota Prius. The contact stated that the passenger's side low-beam headlight failed to provide adequate illumination while driving. The vehicle was taken to the dealer who informed the contact that no issues were found; however, the dealer replaced the headlight bulb. The contact stated that the headlight bulb was replaced several times; however, the failure persisted. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 100,000.
On 12/25/2021, I was driving in the country side under darkness and under heavy rain and I had a hard time seeing the road. There were no road lights so I could not make out where the divider, curve of the road or side of the road was. It was quite a safety hazards because cars were coming from the front, or a few inches off the road would be dirt field. I discovered that the headlamps of my 2012 Prius are full of water bubbles and the water bubbles are blocking and distorting the headlights. I have pictures and videos of the headlights. It is six days already and the water bubbles are still there, and it is not safe to drive out to the field at night or where there is no road lights, with such minimal and distorted lights. I found on the web that a few people experienced water bubbles in their headlamps over the years, but don't know if they reported to NHTSA. …
2012 Toyota Prius engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 1.8L 4-cyl plug-in hybrid | CVT | FWD | 51 / 49 / 50 |
| 1.8L 4-cyl hybrid | CVT | FWD | 49 / 46 / 48 |
EPA ratings. Class: Midsize car.
Frequently asked questions
Is the 2012 Toyota Prius a good car?
Based on 424 owner complaints filed with NHTSA, the 2012 Prius rates average: about as many complaints as a typical year of the Prius at the same age. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2012 Toyota Prius?
The brakes — 200 complaints, 47% of all complaints for this model year, most often about antilock › abs warning light. Next are the electrical system (52) and lights (36).
How many recalls does the 2012 Toyota Prius have?
There are 6 recalls for the 2012 Toyota Prius, the most recent from October 4, 2018 (hybrid propulsion system). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Toyota Prius?
The best years by complaints, compared at the same age, are 2021, 2020 and 2018. Years to avoid or approach with caution: 2011, 2010, 2007, 2006 and 2008. See the full Toyota Prius years comparison.
At what mileage do 2012 Toyota Prius problems happen?
The median mileage reported in complaints is about 50,000 miles; 49% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.