Which parts fail
Components named in complaints (service brakes, ABS, rotors and pads, parking brake).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2012 Toyota Prius owners, lightly cleaned up (personal details are redacted by NHTSA).
I have had a 2012 Prius since 2016. The entire time I've had it, it occasionally "hydroplanes" but without any water. It happens in wet or dry (but mostly dry) conditions. Usually at slower speeds so, though it makes me very uncomfortable, it doesn't happen with any regularity. I've taken it multiple times to my mechanic who always says "Prius' just do that", which is not reassuring. I know there was a recall and I was told my car did not fall under that umbrella. On Wednesday of this week, 10/25/23, I finally had an accident because of this. The brake lockup had been happening more frequently in the past week and in this instance I saw the car in front of me suddenly slow down - I had about 2/3 of a cars distance between me and the car ahead. I hit the brakes and nothing happened. I was pushing down on them long enough to think, "Ok, this is it. …
While pulling out of a parallel parking spot going slightly uphill, I braked as I looked around the back of a double parked truck. I saw a car coming, braked hard, and suddenly my car surged forward across the street and hit a parked car. I looked down and saw that my foot was squarely on the brake pedal pressing down as hard as I could. The parked car was unoccupied, and I was uninjured. There were no warning lamps, messages, or other symptoms of the problem. I turned my car into the dealer for repairs and a fix to the sudden unexpected acceleration. They could offer no fix until a Toyota representative examined the car. On August 14, by an emailed letter, Toyota claimed it found no defects and it must be the result of driver error, specifically, my mistakenly hitting the accelerator. This is gaslighting denialism. …
The contact owns a 2012 Toyota Prius. The contact stated while driving 50 MPH and depressing the brake pedal, the vehicle failed to respond. The vehicle responded after depressing the brake pedal several times, and came into a complete stop. The ABS and anti-skid warning light were illuminated, and the message "Brake" was displayed. The vehicle was taken to an unknown location, where it was diagnosed that the rear passenger brake sensor needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken to an independent mechanic, where it was diagnosed that the pump actuator needed to be replaced. The vehicle was not repaired. The mechanic referred the contact to the manufacturer. There was no further information provided. …
The contact owns a 2012 Toyota Prius. The contact stated that while driving at 30 MPH, the ABS, traction control, and several other unknown warning lights illuminated on the instrument panel as the brake pedal became spongy. The contact initially drove the vehicle to an independent mechanic who informed her of a service bulletin related to the failure; he then instructed her to take the vehicle to the dealer. The vehicle was taken to the dealer and the contact was informed that the vehicle could not be covered under a warranty related to the failure. The manufacturer was also notified of the failure and confirmed that her vehicle was no longer covered under warranty; a case was filed with the manufacturer. The contact agreed to have the vehicle repaired by the dealer and the vehicle remained in their possession. The vehicle had yet to be repaired. …
The contact owns a 2012 Toyota Prius. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle did not stop as intended. In addition, several unknown warning lights were illuminated. The contact used the parking brake to stop the vehicle. The vehicle was towed to the dealer where it was diagnosed with a failed brake master cylinder, accumulator, and brake booster. The contact was informed that the brake master cylinder, accumulator, and brake booster needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and a case was filed. The contact was informed of an unknown recall for the failure; however, the contact was informed that the recall had expired. The failure mileage was approximately 136,000.
The contact's mother owns a 2012 Toyota Prius. The contact stated while driving at various speeds and depressing the brake pedal, the brakes made an abnormal sound. There were no warning lights illuminated. Additionally, the contact stated while the vehicle was parked, the ABS, the brakes, the electronic parking brake, and traction control system warning lights were illuminated. The vehicle was taken to the dealer, where it was diagnosed that the brake booster assembly, the brake booster pump, and the brake master cylinder needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that they could not assist as an unknown Customer Satisfaction Program had expired. The failure mileage was approximately 125,000.
The contact owns a 2012 Toyota Prius. The contact stated while driving 30 MPH, the ABS and traction control warning lights illuminated. The contact stated that while attempting to depress the brake pedal, the vehicle hesitated while responding. The contact stated that there was a buzzing sound coming from accumulator pump. The dealer was contacted. The contact stated that the failure had occurred on several occasions. The vehicle was taken to Nico's Auto Repair where it was diagnosed and determined that the brake booster and accumulator assembly needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The approximate failure mileage was 140,000.
The contact owns a 2012 Toyota Prius. The contact stated that while driving at an undisclosed speed, the brake warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the brake master cylinder and brake booster needed to be replaced; however, the dealer informed the contact that the repair was not covered under warranty. The vehicle was not repaired. The contact stated that the failure recurred while driving and the vehicle hesitated while the brake pedal was depressed. The contact slammed on the brake pedal and the vehicle came to a complete stop. The vehicle was towed to the residence. The manufacturer was not made aware of the failure. The failure mileage was 185,519.
The contact owns a 2012 Toyota Prius. The contact stated while driving at an undisclosed speed, several unknown warning lights illuminated, with an abnormal sound coming from the vehicle. The vehicle was taken to the dealer where it was diagnosed with brake booster failure. The contact was informed that the brake booster pump needed to be replaced. The vehicle was not repaired. The contact stated that the failure was a known failure with the vehicle. The manufacturer was made aware of the failure. The contact was informed that an undisclosed Extended Warranty Program had expired. In addition, the contact was informed that the repair was not covered. The failure mileage was approximately 175,000.
The contact owns a 2012 Toyota Prius. The contact stated that while driving approximately 50 MPH, the ABS, brakes, and traction control warning lights illuminated. The brakes became inoperable, but the driver was able to regain control of the vehicle and pulled over. The vehicle was taken to the local dealer where it was diagnosed there was a hydro pump motor fault and hydro motor pump relay fault with codes C1252 and C1253 and the hydro boost brake pump kit and brake assembly needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and referred him to the NHTSA hotline. The approximate failure mileage was 97,000.
NHTSA investigations
Brake Actuator Valve Wear
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights.
Brake Actuator Valve Wear
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s).
Brake complaints in other Prius years
Frequently asked questions
How common are brake problems on the 2012 Toyota Prius?
NHTSA has 200 complaints about the brakes of the 2012 Toyota Prius, 47% of the model year's 424 complaints. The component named most often is antilock › abs warning light (3 mentions).
Is there a recall for 2012 Toyota Prius brake problems?
No. NHTSA lists no brakes recall for the 2012 Toyota Prius, though it has 6 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2012 Toyota Prius brake problems start?
Half of the complaints with a recorded mileage happened before about 96,000 miles, and 23% before 25,000 miles.
Is it dangerous?
Owners linked 15 crashes, 0 fires and 7 injuries to brakes problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.