Which parts fail
Components named in complaints (fuel pump, injectors, fuel tank, hybrid and EV propulsion).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2022 Hyundai Tucson owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact's wife owns a 2022 Hyundai Tucson. The contact stated that his wife reported that the vehicle shuddered significantly and failed to exceed 30 MPH while driving. The check engine warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed that the fuel injectors were leaking, and the dealer determined that the fuel injectors needed to be replaced. The dealer informed the contact that the manufacturer had redesigned the fuel injectors due to the known failure. The dealer informed the contact that the repair could not be covered under the extended warranty because the vehicle had exceeded the required mileage. The contact was informed that parts needed to be ordered to repair the vehicle. The vehicle had not yet been repaired. The contact related the failure to TSB Number: 22-FL-002H. …
The contact owns a 2022 Hyundai Tucson. The contact stated while driving at various speeds, the vehicle lost motive power. The check engine, emissions, and other unknown warning lights were illuminated. The contact coasted to the side of the road and had the vehicle towed to the dealer. The contact stated that the failure had occurred 3 times within 10 months. The dealer diagnosed the vehicle with fuel injection system failure. The dealer replaced the fuel injector for the first time. The contact stated that after the second failure, the vehicle was taken to the dealer to be diagnosed. The contact stated that another fuel injector was replaced. The contact stated that the vehicle was diagnosed again after the third time and the contact was informed that the fuel injectors needed to be replaced; however, the were not yet repaired. …
This 2022 Hyundai Tucson stalled in the middle of a busy highway with my wife in the vehicle. The car suddenyly stalled while going 75mph and she was almost killed and got rear ended. Later we were informed by the dealership that there is a inherent issue with the fuel injection system on these vehicles and the fuel injector has gone bad. These people only replaced the faulty injector. Two months back another injector went bad and then i researched and found this is a bad engineering issue. Now Hyundai is trying to hide behind the veil of Texas Leamon law and is not taking any responsibility or buying back the vehicle. Hyundai forums are full of this problem and many people avoided near death experience because of the stall. I can provide reditt and hyundai forum urls for reference if required.
The contact owns a 2022 Hyundai Tucson. The contact stated while the vehicle was stationary, the contact attempted to open the tank door and pressed the button; however, the tank door failed to open to refuel the vehicle. There were no warning lights illuminated. The vehicle was taken to a dealer and the contact was able to open the fuel tank. The vehicle was not diagnosed by the dealer because of the diagnostic fee. The vehicle was not repaired. The contact had experienced the failure intermittently for over five months. The manufacturer was not made aware of the failure. The failure mileage was approximately 19,000.
The contact owns a 2022 Hyundai Tucson. The contact stated that while his daughter was driving approximately 65 MPH, the check engine warning light illuminated and the vehicle began to vibrate, lose motive power, and then stalled. The vehicle was towed to the local dealer who diagnosed that cylinder #4 fuel injector had failed. The fuel injector was replaced; however, the same failure occurred with fuel injector #3. The vehicle was not yet repaired. The manufacturer was not yet contacted. The failure mileage was 34,219.
On 3 occasions over my 18-month ownership of this certified pre-owned Hyundai 2022 Tucson, the vehicle surged suddenly forward WITH BRAKE APPLIED at creeping (parking) speeds of 3-4 mph. No warning lamps were observed. On the most recent (3rd) occasion, a crash over a sidewalk and into a storefront caused $10,000 damage. No pedestrians were harmed, no airbags deployed and neither passenger was harmed. The service department is "unable to duplicate" the surging behavior and declares the car mechanically "safe to drive."
The contact owns a 2022 Hyundai Tucson. The contact stated that the fuel door had failed to open intermittently. The contact stated that the failure had progressively worsened, causing the contact to seek assistance to open the fuel door. The vehicle was taken to the dealer where it was being repaired. The manufacturer was not contacted. The failure mileage was approximately 50,000.
I have a 2022 Hyundai Tucson with about 15k miles on it. I have had it serviced twice for oil changes and the recommended manufacture recommended maintenance. However, I have noticed a SIGNIFICANT loss in power upon acceleration with this vehicle. My new car drives very rough and this is a safety issue due to the fact when entering the interstate, the car will not increase speed as requested putting myself and others on the road in danger. Additionally, simple maneuvers like turning into cross traffic are of concern because the vehicle doesn't respond to acceleration when accelerating from 0mph as well as in stop and go traffic. There are no engine lights or codes that I can visibly notice but even in sport mode the acceleration of the vehicle is not responsive. …
On 5/27/24, my check engine light came on and the vehicle stayed to shimmy and shake each time I would press on the gas. Had the vehicle towed to the dealer for the #4 fuel injector assembly to be replaced. The same thing happened on 7/16/24 while traveling out of state. I was traveling on a highway and had to keep my emergency flashers on as I tried to coax the car to the next exit. Couldn't go above 25-30 mph. Had vehicle towed to a dealer for the #2 fuel injector assembly to be replaced. Now I am again without a vehicle because on 7/26/24, the same thing happened and I was told it is the #1 fuel injector. I was told by 2 different dealers that this is a known Hyundai Tucson issue but they are only allowed to replace what is coming up with an error code. …
At 37,430 mileage while driving on the interstate our vehicle check engine light came on, shortly after, our vehicle began to shake, and would stall if our RPM fell below 2000, placing us at a serious safety risk of breaking down and causing an accident on the interstate driving 80 mph. We were 290 miles from the nearest Hyundai service department, and managed to make it without breaking down. After inspecting our vehicle, the service department reported that our fuel injector for cylinder two needed replacing, but that it would take 3 business days to order the part, leaving us stranded 1600 miles from home for 6 days in total. On our way back home, at around 38,800 mileage, our check engine light came back on and are car began to shake and stall if our RPM fell below 2000 (same as before) while driving on the interstate. …
Fuel System complaints in other Tucson years
Frequently asked questions
How common are fuel system problems on the 2022 Hyundai Tucson?
NHTSA has 137 complaints about the fuel & propulsion system of the 2022 Hyundai Tucson, 35% of the model year's 386 complaints. The component named most often is fuel injection system › injectors (2 mentions).
Is there a recall for 2022 Hyundai Tucson fuel system problems?
No. NHTSA lists no fuel & propulsion system recall for the 2022 Hyundai Tucson, though it has 3 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2022 Hyundai Tucson fuel system problems start?
Half of the complaints with a recorded mileage happened before about 34,000 miles, and 20% before 25,000 miles.
Is it dangerous?
Owners linked 2 crashes, 0 fires and 0 injuries to fuel & propulsion system problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.