Most common 2012 Hyundai Tucson problems
Share of the 255 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Hyundai Tucson complaints by model year
Best Tucson years: 2011. Years to avoid: 2025, 2016, 2017, 2022, 2023. Compare all years →
2012 Hyundai Tucson recalls (3)
Service brakes, hydraulic › Antilock/traction control/electronic limited slip › Control unit/module
Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS fuse, free of charge.
Engine and engine cooling › Engine
Hyundai Motor America (Hyundai) is recalling certain 2011-2013 Tucson vehicles. The engine oil pan may leak and, if not addressed, the loss of oil may result in engine damage.
Remedy: Hyundai has notified owners, and dealers will inspect for an oil pan leak, replacing it if necessary, and install an updated oil pressure switch, free of charge. The recall began August 19, 2019.
Air bags
Hyundai Motor Company (Hyundai) is recalling certain model year 2011-2014 Hyundai Tucson vehicles manufactured January 3, 2011, through December 23, 2013. In the affected vehicles, the air bag assembly installed in the steering wheel may come loose from its mounting.
Remedy: Hyundai will notify owners, and dealers will inspect and tighten the bolts that secure the driver's air bag assembly, free of charge. The recall began on May 9, 2014.
NHTSA defect investigations
Federal safety investigators have looked into 3 possible defects involving the 2012 Hyundai Tucson:
Engine Fires
On March 29, 2019, the Office of Defects Investigation (ODI) opened two Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) to broadly investigate incidents of non-crash fires (regardless of origin or operational status of the vehicle) on various model year Hyundai and Kia vehicles.
Loss of Motive Power
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021.
Hyundai and Kia ABS Module Fires
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando.
What 2012 Hyundai Tucson owners say
Engine & cooling all 168 →
The contact owns a 2012 Hyundai Tucson. The contact stated while driving 75 mph, the contact heard a clicking sound coming from the engine compartment. The contact stated moments later, a loud explosion came from the rear of the vehicle. The contact saw smoke coming from the rear of the vehicle. The vehicle stalled while driving to the side of the roadway. The vehicle was towed to a local dealer where it was diagnosed with the engine needing to be replaced. The vehicle was not repaired. The contact stated that the vehicle was serviced two years prior under NHTSA campaign number: 19V063000 (Engine and engine cooling) which the contact related to the failure. The manufacturer was not informed of the failure. The failure mileage was 150,000.
I was driving down the interstate, going approximately 70mph, and my 2012 Hyundai Tucson started having difficulty maintaining speed. The engine started revving up while the car was still slowing down. Suddenly, I felt a knock and smoke started bellowing out of the engine bay. I pulled over immediately, opened the hood to inspect, and was almost burnt by the flames. There was a fire near the back of the engine block which I was able to put out with some water. I had my vehicle towed to the Hyundai of West Allis in Wisconsin. The dealership and a corporate Hyundai inspector determined that the cause of the fire was a thrown engine rod. There were no signs of issues or engine lights prior to this event. My Tucson has been at the dealership for nearly two months. …
Brakes all 35 →
The contact owns a 2012 Hyundai Tucson. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the brake pedal was inoperable. The contact depressed the brake pedal to the floorboard and the vehicle failed to stop. The contact continually depressed the brake pedal and the vehicle eventually stopped. The contact checked the brake fluid reservoir and noticed that the brake reservoir was empty. The contact refilled the brake fluid reservoir. The contact drove the vehicle to the residence. …
The contact owns a 2012 Hyundai Tucson. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed, and the contact heard an abnormal squeaking sound. The vehicle was taken to an independent mechanic, but the failure could not be duplicated. The dealer was made aware of the failure but confirmed that parts were not yet available 48,000. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 48,000. VIN tool confirms parts not available.
Transmission & drivetrain all 26 →
I was driving down the interstate, going approximately 70mph, and my 2012 Hyundai Tucson started having difficulty maintaining speed. The engine started revving up while the car was still slowing down. Suddenly, I felt a knock and smoke started bellowing out of the engine bay. I pulled over immediately, opened the hood to inspect, and was almost burnt by the flames. There was a fire near the back of the engine block which I was able to put out with some water. I had my vehicle towed to the Hyundai of West Allis in Wisconsin. The dealership and a corporate Hyundai inspector determined that the cause of the fire was a thrown engine rod. There were no signs of issues or engine lights prior to this event. My Tucson has been at the dealership for nearly two months. …
The contact owns a 2012 Hyundai Tucson. The contact stated the all-wheel drive (AWD) warning light was illuminated. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was approximately 45,000.
2012 Hyundai Tucson engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 2.0L 4-cyl | 6-speed automatic | FWD | 22 / 29 / 25 |
| 2.4L 4-cyl | 6-speed automatic | FWD | 21 / 30 / 25 |
| 2.4L 4-cyl | 6-speed manual | FWD | 20 / 27 / 23 |
| 2.4L 4-cyl | 6-speed automatic | 4WD | 20 / 27 / 23 |
| 2.0L 4-cyl | 5-speed manual | FWD | 20 / 26 / 22 |
| 2.4L 4-cyl | 6-speed manual | 4WD | 19 / 25 / 21 |
EPA ratings. Class: SUV.
Frequently asked questions
Is the 2012 Hyundai Tucson a good car?
Based on 255 owner complaints filed with NHTSA, the 2012 Tucson rates use caution: 1.8× as many complaints as a typical year of the Tucson at the same age. It is one of the Tucson years we suggest avoiding. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2012 Hyundai Tucson?
The engine & cooling — 168 complaints, 66% of all complaints for this model year. Next are the brakes (35) and transmission & drivetrain (26).
How many recalls does the 2012 Hyundai Tucson have?
There are 3 recalls for the 2012 Hyundai Tucson, the most recent from September 22, 2023 (control unit/module). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Hyundai Tucson?
The best years by complaints, compared at the same age, are 2011. Years to avoid or approach with caution: 2025, 2016, 2017, 2022 and 2023. See the full Hyundai Tucson years comparison.
At what mileage do 2012 Hyundai Tucson problems happen?
The median mileage reported in complaints is about 83,000 miles; 21% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.