2025 Hyundai Santa Fe Hybrid Engine Problems

Mileage when the problem started

Owner reports

Selected complaints filed with NHTSA by 2025 Hyundai Santa Fe Hybrid owners, lightly cleaned up (personal details are redacted by NHTSA).

I was stopped at a red light. When the light turned green, I proceeded to apply the gas and accelerate. I quickly noticed that the vehicle began accelerating at a faster rate than I was intending. The vehicle continued to accelerate without me applying my foot to the gas pedal. Nothing would stop the continued acceleration (application of brake). I crashed into the rear of a vehicle in my lane going approximately 50-60mph (estimate). I am unsure what the issue was that resulted in this crash. In doing some internet searching, it seems it could have something to do with the transition from electric to gas when I was stopped temporarily at the intersection. It could have been a faulty sensor (throttle position) or software glitch. These components have not been inspected by the manufacturer, police, or insurance representatives. …

The contact owns a 2025 Hyundai Santa Fe. The contact stated that while driving approximately 65 MPH, the vehicle unexpectedly decelerated to 25 MPH with a "Vehicle Will Shut Down" warning message displayed. The contact stated that the engine then began to shut down, and although the accelerator pedal was depressed, the vehicle failed to accelerate and stalled. The failure occurred on multiple occasions, requiring the vehicle to be towed each time. The vehicle was towed to the dealer; the vehicle was not diagnosed or repaired and the contact was informed that the failure could not be duplicated. The manufacturer was made aware of the failure and multiple cases were opened, The failure mileage was approximately 3,300.

Description of the Problem: I own a 2025 Hyundai Santa Fe Hybrid Limited with approximately 3 months of use. While driving on highway, the vehicle suddenly stalled displaying "Hybrid System Failure-Stop by side". I had to stop on shoulder and restart, drove it couple of days and it happened again. Engine would not start, leaving the vehicle stuck in EV mode only with no ability to accelerate properly, Vehicle wouldnt go beyond 35mph. The vehicle then stalled and became unsafe to operate on a public road. After restarting, the vehicle displayed a Check Engine Light. Tookk it to the dealer and the dealer reported DTC P1122000, but did not provide clear evidence of an internal system fault. The dealer claimed the event was caused by "20% ethanol in the fuel," which is inconsistent with U.S. pump labeling laws. …

While driving on the freeway at approx 65mph, the car suddenly starting de-celerating and forced me to pull over to emergency shoulder/lane and try to determine the cause. The car is a "Hybrid" and the dashboard stated to put car in Park and Idle the Engine over 2000rpm to charge up the Battery. ( i still don't know which Battery they were speaking of...Engine Battery or Hybrid Battery) I sat there Idling the Engine for 15 minutes and slowly proceeded to get off the freeway and limped the car back to my home. I then called my selling Hyundai Dealer, as the car was still in warranty, and told them of my sudden problem and asking them what could it be??? They said they did not know until they saw the car and tested it with their computer equipment...please have it towed into their shop. So i did and 2 days later they called to say..NO Computer Codes showed any problem. …

**What component or system failed, and is it available for inspection?** The vehicle's electrical/power system failed, causing a complete loss of power while driving. This is the fourth occurrence of this failure. The vehicle is currently at the Hyundai dealership and available for inspection. **How was your safety or the safety of others put at risk?** The power failure occurred while driving on a busy road. The driver struggled to safely maneuver the vehicle (executing a U-turn) to get out of traffic and reach a safe location. The vehicle had to be towed as a result. **Has the problem been reproduced or confirmed by a dealer or independent service center?** The vehicle has been brought to the Hyundai dealership for this same issue four times. As of the most recent update, the dealership has not been able to identify the root cause or confirm a fix. …

I was on a semi residential-commercial street that turns on to a freeway entrance. I was turning right and unavoidably entered the freeway when the sudden loss of power occurred. The car slowed down to about 20 mph and pressing on the gas medal didn't yield any more power. I immediately pulled over to the emergency lane upon entering freeway to let fast moving vehicles pass me on the left side. I turned off the vehicle and turned it back on. It seemed to turn on as normal so I proceeded to drive home slowly, staying on the slow right lane of the freeway driving under the speed limit until I took my exit to get to my home. All seemed ok until I turned onto residential street near my home. Again the car slowed down suddenly to 20mph and giving it more gas did not make a difference. …

My 2025 Hyundai Santa Fe Hybrid AWD was serviced under warranty on 4/22/2026 for a driveability concern after experiencing a loss of power while driving. The service history shows part HY35326-2M500 was replaced. On or about 5/25/2026, the same issue occurred again while driving at highway speed. The vehicle suddenly lost motive power and dropped from approximately 70 mph to approximately 30 to 40 mph, creating a serious safety risk because the vehicle could not maintain speed with surrounding highway traffic. No warning lamps, dashboard messages, or diagnostic codes appeared during the failure. The vehicle is currently at a Hyundai dealership for inspection and repair for the repeat issue and should be available for inspection upon request. …

When traveling home from work 8/27/26, my cruise control shut off and my car immediately went into "limp" mode. This almost caused me to get into an accident with a tractor trailer, in which, I may not have survived. Immediately pulled over and tried to find out what had caused this and how to get it fixed. Nothing worked to get it out of "limp" mode. There were no warning lights or messages, except LV3. Which was a completely different issue. This issue I was able to correct. Tried fixing the "limp" mode issue by doing as told by Google AI, turn car off, lock door with key fob, waiting 10-15 minutes for computer to reset. NOTHING. Also tried checking to see if there was a battery dump, in which this case would have been the fuel system not communicating with the hybrid battery system, NOTHING. I do have an appt with the dealership on 9/2/26 to have this looked at and inspected. …

Vehicle experienced a loss of acceleration while driving. When pressing the accelerator, engine RPM increased significantly but the vehicle did not increase speed. The vehicle felt as though it was stuck in one gear and would not upshift or downshift. The issue was most noticeable while driving uphill, where the vehicle was unable to maintain speed despite full throttle input. This created a safety concern as the vehicle could not accelerate normally in traffic conditions. The problem has been progressively worsening over time. Initially there were mild symptoms, but it has become more severe and frequent, culminating in a near-complete inability to accelerate under load. No warning lights or messages were observed prior to or during the failure (if that's true-adjust if needed). Vehicle has approximately 28,000 miles. …

Driving home from church this morning, the vehicle experiences a sudden loss of power and the car went into "limp mode". Even the pedal floored and the engine rpms high, the car would barely go about 25 or 30 mph. A message from the dash board told me to pull over and leave the engine running to charge the EV batteries. The batteries would charge enough for what I thought would get me home but quickly drained leaving repeat the action until I could limp the six miles home with flashers on and cars passing me to get around. No warning lights and no indication there was a problem until it happened leaving me baffled and frustrated. I was just thankful that I wasn't going faster when it happened. If I had been going faster when this happened, it could have created a major accident. Dangerous! Since this happened on Sunday, the dealer wasn't open. …

Engine complaints in other Santa Fe Hybrid years