2023 Hyundai Santa Fe Hybrid Engine Problems

Which parts fail

• Cooling system › Radiator assembly
  1

Components named in complaints (engine, cooling system, oil leaks, timing chain, exhaust).

Mileage when the problem started

Owner reports

Selected complaints filed with NHTSA by 2023 Hyundai Santa Fe Hybrid owners, lightly cleaned up (personal details are redacted by NHTSA).

The contact owns a 2023 Hyundai Santa Fe. The contact stated while driving at approximately 30-35 MPH, the vehicle lost motive power. The contact restarted the vehicle and the vehicle worked as designed for several miles before the failure recurred. The contact stated that several unknown warning lights were illuminated. The vehicle was towed to the local dealer, where it was diagnosed and determined that the failure was due to the accelerator switch. The vehicle was repaired, but the failure recurred. The contact stated while driving 10 MPH in the driveway, the vehicle lost motive power. The manufacturer was not contacted. The failure mileage was approximately 6,800.

The issue I'm about to describe has occurred multiple times during the seven (7) months I've owned the vehicle - including again today. In all cases, I was attempting gradual acceleration to merge onto a highway or high-traffic street (e.g., when exiting a mall parking lot onto a busy city street). When I press the accelerator nothing happens - NO power whatsoever for at least two seconds! And on three of these occasions, I was almost broadsided by oncoming high-speed traffic! I've reported this issue to my dealership (both sales and service) and their response was that this is a known problem with the Hyundai hybrid models BUT that there is NO fix available nor, to the best of their knowledge, is there one in the process of being developed! …

On 8/14/23/ I got the first oil change for my new car at the dealer. On 8/15/23 as I cruised at 65mph on a crowded Detroit expressway, I pushed further on the accelerator to get away from an aggressive driver on my tail. Nothing happened; The car engine shut down. No warning, no lights, no beeping, no alarm, no dash screen message. Dead engine in the middle lane with cars all around. After i miraculously made it to the shoulder of the freeway, The engine light and oil light came on. Not before, only after the car died. The dipstick indicated The car was out of oil. Unbeknownst to me the parts used to change the oil the previous day were defective. The oil had leaked out over the course of the day and over night. (I later discovered my driveway full of oil). THE PROBLEM, additional to the defective parts is the fact that I HAD NO WARNING THAT THE ENGINE SHUT DOWN WAS IMMINENT. …

I purchased a 2023 Hyundai Santa Fe Hybrid in November of 2023. Within a couple of months of purchase I had 2 incidents where without warning the car lost power and made a noise sounding like some sort of fan. One of the incidents was on [redacted] in Massachusetts, the heavy traffic cleared, I was in the fast lane, and the car would barely move. It was a safety issue as there was no place to go on the left side of the highway and traffic to my right had already picked up speed. After a minute or so the power again became available. This has happened to me several times but Hyundai has told me there is NO RECORD of this happening with my car model. On occasion I have my grandkids in the car and I am very concerned that Hyundai will not acknowledge this problem. By the way, it happened again this morning as I was pulling away from a Starbucks drive-up window. …

Occurred on [redacted] while travelling in the middle lane of a 3-lane highway just west of Raleigh, NC and heading west. The Emergency Brake Light came on, the car stopped suddenly and my head shook from side to side. This could have been a major accident if the traffic wasn't light. I do not tailgate and there were at least 6-8 car lengths between me and the car in front. No cars on either side. There was no beeping warning from the vehicle about being too close to other vehicles before the car stopped. I pressed on the gas pedal and the car moved forward. The weather was about 50-60 degrees, dry road and sunny. Next Step: Called Hyundai Customer Care on [redacted] and was advised to bring the vehicle in for inspection and correction. Took the car into the Hyundai Autonation dealership in Buford, GA, where the vehicle was purchased. They found nothing wrong. …

This is related to Complaint Number 11526621 filed June 13, '23. Today I experienced the same issue described in my previous complaint but under different circumstances. I was at an intersection of two 2-lane highways, one going east-west and the other going north-south, and was facing oncoming traffic as I waited for a gap in the oncoming traffic that would allow me to make the left turn. Once a gap appeared (perhaps 4 or 5 car lengths long), I pressed the accelerator to turn left but there was zero propulsion for about 2 seconds. I was simply stalled in the path of the oncoming traffic. At the end of the 2 second delay, as the vehicle transitioned from EV (electric) to internal combustion (gasoline) mode of propulsion, my vehicle GRADUALLY accelerated just enough to allow me to complete the turn; however, I came very close to being broadsided by the oncoming traffic. …

One two separate occasions while driving the car has lost the ability to accelerate. There is no acceleration power even when completely flooring the gas pedal. The dash displays a red circle warming that states "Check Hybrid system. Stop Safely". I have had to coast to the side of the road and then the car shuts off. It has taken several minutes before it can start again, and then displays a warning "Park with engine On to charge battery" before being able to shift the car into drive. I immediately took the vehicle to the dealership at which I had purchased the car. They have run a diagnostic on it and did not find any error codes stored in the computer. I picked up the vehicle from them and immediately upon pulling out of their lot it happened again. …

On December 11 and 12, 2022, my 2023 Hyundai Santa Fe Limited Hybrid failed to accelerate in traffic. In both cases I was attempting gradual acceleration to change lanes, or merge onto an another high traffic street and when I pressed the accelerator nothing happened. On second occasion I could not get any power for several seconds. In both cases I activated hazard signals to avoid a collision by vehicles rapidly approaching me from behind in a 50 Mph speed zone. The vehicle has 900 miles on it and I took delivery November 14,2022. I see where this has occurred to other Santa Fr Hybrids, yet when I called the dealer they seemed unaware of any problems.I am scheduled for a long driving trip to Michigan in a week. 567 miles and I am very concerned about driving on the Turnpikes with this problem. I am going to Pohanka Hyundai of Fredericksburg VA tomorrow.

On highway, emergency braking enacted. I pulled to side the of the road to turn engine off and restart car. When I did, I could not put the car in gear. I have had other similar incidents happen with this vehicle. After about an hour of waiting for roadside assistance and having NYS troopers come help, the car dash lit up and I was then able to put car in Drive. When I talked to dealership and said that I got a diagnostic message on my screen to have transmission component checked TODAY ('today' was in all CAPS on the screen), they said they could not get me in. Then when I said, "I'm supposed to just drive around hoping my car doesn't break down again?" She said, "I'll cross my fingers for you." Are you kidding me!? My safety is at risk is this what a major dealership's answer is to the car's issue?

Car has a SEVERE Life threatening Hesitation, sometimes as much as almost 2 seconds delay from when you fully step on the accelerator to when it slowly starts to go. No warning lights or bells whatsoever. Regardless of driving mode it dose it. Seems to be especially pronounced when at a dead stop in sport mode. Problem seems to have gotten progressively worse the more we have driven it. The Dealership is denying that there's any problem or issue & didn't want to make an appointment to look at it & keeps trying to tell me this is normal. Car is unsafe to drive like this & has nearly gotten me & my family killed on numerous occasions. I have driven other hybrids by other manufacturers & none have had this issue.

Engine complaints in other Santa Fe Hybrid years