Most common 2020 GMC Sierra 2500 problems
Share of the 78 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
GMC Sierra 2500 complaints by model year
Best Sierra 2500 years: 2012, 2014, 2013. Years to avoid: 2024, 2025, 2020, 2021, 2022. Compare all years →
2020 GMC Sierra 2500 recalls (9)
Power train › Automatic transmission › Control module › Software
General Motors, LLC is recalling certain 2020 Chevrolet Silverado 2500, 3500, GMC Sierra 2500, 3500, and 2020-2022 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles that may have been repaired incorrectly under recall 24V797. The transmission control valve may fail and cause the rear wheels to lock up.
Remedy: Dealers will inspect the vehicles and update the transmission control software, free of charge. Owner notification letters were mailed March 6, 2026.
Power train › Automatic transmission › Fluid/lubricant › Valves/valve body
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels to lock-up.
Remedy: Dealers will install new transmission control module software, free of charge. GM will provide a special coverage program to cover the repair of transmissions that are identified by the remedy software as containing a…
Latches/locks/linkages › Tailgate › Latch
General Motors, LLC (GM) is recalling certain 2020-2024 Chevrolet Silverado 2500, 3500, GMC Sierra 2500 and 3500 vehicles equipped with power-unlatching tailgates. The tailgate's electronic gate-release switch may short circuit due to water intrusion, which can result in the tailgate inadvertently unlatching while the vehicle…
Remedy: Owners are advised to check that the tailgate is closed and latched before driving. Dealers will replace the exterior touchpad switch assemblies, free of charge. Owner notification letters were mailed May 17, 2024.
Tires › Temporary/emergency spare tire
General Motors, LLC. (GM) is recalling certain 2020-2021 Chevrolet Silverado 2500 and GMC Sierra 2500 vehicles equipped with a 17" spare tire (RPO ZHQ or ZXT) and either the 20" accessory road tire (RPO REM) or the 18" accessory road tire (RPO Q2V).
Remedy: Dealers will provide the appropriate spare tire and apply a new spare tire information label, free of charge. Owner notification letters were mailed on October 18, 2021.
Seat belts › Critical fasteners
General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles.
Remedy: GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began January 26, 2021.
Air bags › Side/window › Curtain › Inflator
General Motors, LLC. (GM) is recalling certain 2020 Buick Enclave, Cadillac XT5 and XT6, Chevrolet Blazer, Silverado 1500, 2500 and 3500 and Traverse and GMC Acadia and Sierra 1500, 2500 and 3500 vehicles.
Remedy: GM will notify owners, and dealers will replace the suspect RRAB modules, free of charge. The recall began September 3, 2020.
Show 3 more recalls
Latches/locks/linkages › Hood › Latch
General Motors LLC (GM) is recalling certain 2020 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles previously recalled under 20V-142. Some of the vehicles in 20V-324 were not part of Recall 20V-142 but received defect parts during another service (typically during collision repair).
Remedy: GM will notify owners, and dealers will replace the hood assembly, free of charge. For hoods sold over the counter, dealers will contact customers with instructions for hood replacement. The recall began July 7, 2020.
Latches/locks/linkages › Hood › Latch
General Motors LLC (GM) is recalling certain 2020 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The hood-latch striker wires may not have been heat-treated properly, possibly causing them to fracture.
Remedy: GM will notify owners, and dealers will replace the hood assembly, free of charge. The recall began April 13, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at…
Seat belts › Pretensioner
General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2020 Silverado 2500, Silverado 3500, Sierra 2500, and Sierra 3500 vehicles equipped with carpet floor covering.
Remedy: GM will notify owners, and dealers will close off the opening in the pretensioner bracket, free of charge. The recall began December 13, 2019.
NHTSA defect investigations
Federal safety investigators have looked into a possible defect involving the 2020 GMC Sierra 2500:
Air Bag Malfunction
On April 9, 2021, the Office of Defects Investigations (ODI) opened PE21-010 to investigate instances of air bag malfunction indicator light (MIL) illumination and potential for frontal air bag non-deployment in several vehicles manufactured by General Motors (GM).
What 2020 GMC Sierra 2500 owners say
Transmission & drivetrain all 24 →
The contact owns a 2020 GMC Sierra 2500. The contact stated while driving 63 MPH, and towing a 15,000 lb. 5th Wheel RV, the contact heard the rear wheels make an abnormal squealing or chirping sound. The contact stated that the front end of the vehicle was pulling to the right. The contact adjusted the steering wheel to the left to compensate. The contact stated that the vehicle was losing motive power. The contact stated that the drive(D) symbol was flashing on the instrument cluster. The contact depressed the accelerator pedal; however, the vehicle failed to respond as intended. The contact exited the highway and stopped the vehicle. The contact had the vehicle towed to an independent mechanic. The mechanic scanned the vehicle but did not retrieve any fault codes. …
The contact owns a 2020 GMC Sierra 2500. The contact stated that the vehicle was under NHTSA Campaign Number: 24V797000 (Power Train) and the vehicle was repaired. The contact stated that after the recall repair, the transmission started shifting hard. The vehicle was taken to the dealer, and the contact was informed that the transmission module would reprogram and adjust independently. The contact stated that a week later, while driving approximately 45 MPH, the vehicle started to run rough, and the message engine power reduced was displayed. The transmission fault, parking brake system alert, service parking brake, and the check engine warning light illuminated. The vehicle was towed to the dealer, who diagnosed the vehicle and determined that the fuel injector was open, causing high resistance in the connector for cylinder #4. …
Electrical system
The rear defroster massively overheated. It started heavily smoking and eventually exploded the rear windows. Only warning sign was the smoke which we noticed quickly because the windows were up. Had the windows been down we might not have noticed before a fire started. I'm taking it to a dealership now. This module also triggers on from a remote start. Extremely dangerous!!!
Vehicle was parked in a school parking lot. Rear Trailer Harness and modules in back short circuited causing an electrical fire that expanded to the driver's taillight rear bumper, and bed of truck.
Brakes
The contact owns a 2020 GMC Sierra 2500. The contact stated that while driving 65 MPH, the message "Check Service Brakes Now" was displayed. The vehicle was taken to an independent mechanic, where it was diagnosed with electric parking brake malfunction. The mechanic informed the contact that the electric parking brake had been engaged unintendedly, causing the rear driver's side brake calipers to seize. The vehicle was repaired; however, the failure recurred on the rear passenger's side while driving. The vehicle was taken to the dealer, where it was diagnosed with electric parking brake circuitry failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 62,000.
The main tailgate will not go down or function properly and it says online there is a national recall for this, but does not come up when I search my vehicle. When I turn on my left turn signal the brights flash for no reason and this is a known major issue with the vehicles as well. The trucks computer is telling me low on coolant even though it is not that has already been fixed through a 3rd pARTY WARRANTY Parking brake was stuck on when I bought the vehicle and had been for a long time you could tell and I had to pay over $1100 to fix it at GM. The Ford collision system does not work properly and the cameras will come on at certain times when they're not supposed to be and not come on when they are supposed to be
Frequently asked questions
Is the 2020 GMC Sierra 2500 a good car?
Based on 78 owner complaints filed with NHTSA, the 2020 Sierra 2500 rates avoid: 3.1× as many complaints as a typical year of the Sierra 2500 at the same age. It is one of the Sierra 2500 years we suggest avoiding. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2020 GMC Sierra 2500?
The transmission & drivetrain — 24 complaints, 31% of all complaints for this model year. Next are the electrical system (13) and brakes (12).
How many recalls does the 2020 GMC Sierra 2500 have?
There are 9 recalls for the 2020 GMC Sierra 2500, the most recent from February 12, 2026 (software). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the GMC Sierra 2500?
The best years by complaints, compared at the same age, are 2012, 2014 and 2013. Years to avoid or approach with caution: 2024, 2025, 2020, 2021 and 2022. See the full GMC Sierra 2500 years comparison.
At what mileage do 2020 GMC Sierra 2500 problems happen?
The median mileage reported in complaints is about 32,000 miles; 54% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.