Which parts fail
Components named in complaints (wheels, lug nuts, original-equipment tires, TPMS).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2017 Ford Explorer owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2017 Ford Explorer. The contact stated that the A-pillar trim on the driver's and passenger's side of the windshield was loose at the top. Additionally, the contact stated that the TPMS warning light was illuminated. The contact received notification of NHTSA Campaign Number 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was 125,000. VIN tool confirms parts not available.
The contact owns a 2017 Ford Explorer. The contact stated that while the vehicle was parked, the contact attempted to change the tires on the vehicle and was unable to remove the lug nuts. The contact stated that the lug nuts on all four wheels were swollen. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 176,825.
On 5/21/2021 a Police Officer for the Iowa Tribe Police Department located in Perkins, Oklahoma was responding to a call and had just been canceled when the driver-side rear tire tread separated from the tire and it blew out. The officer's safety was at risk had she not been canceled and slowed down some or this could've resulted in a rollover or some other traffic collision possibly injuring or killing the officer or other individuals on the roadway. Direct Discount Tire in Stillwater Oklahoma is unaware of any recalls with this tire and have offered to help replace the tire. The tire hasn't been inspected by the manufacturer as I am unaware who manufactured this tire. Upon researching Nokian tire through the internet I discovered that Nokian Tires have had issues in the past for tread separation. The earliest I could fine may have been around 2016. …
Rear toe joint arm used to replace recalled rear toe joint arm is causing the tires in the back to tilt leaving vehicle at risk of roll over accident from tire, axel, or suspention failure. The suv becomes increasingly unstable and difficult to control. The mechanic said it was a miracle that my suv had not flipped. When I took this issue to the dealership, the service manager was aware of the issue and had a "high percentage" of cars that had the recall service done returning with the same problem. Despite this information being passed on to ford by its dealership service departments, Ford is continuing to place drivers at risk by using the toe joint arm that is too small. Pictures: rear vs front tires purchased same time, allign.before new toe joint placed with report, then after, recall work done and , allign report, toe joint arms used for recall. …
While driving on the freeway, I heard a clunking noise from the rear of my vehicle and immediately started to fishtail violently back and forth across all 3 lanes of the highway narrowly avoiding crashing into other cars on the highway while avoiding spinning or flipping the vehicle. I was able to gain control of the vehicle while it whipsawed back and forth with all four tires screeching and smoking slowing down to navigate to the shoulder out of harms way. It was one of if not the most frightening experiences I ever had as a motor vehicle operator. On inspection, I observed the rear left wheel was loosely connected to the drive train and severly out of alignment by ~30% which was what caused the vehicle to begin to fishtail and whipsaw so violently at freeway speed which at the time of mechanical failure was approximately 70 miles per hour. …
I bought the SUV Used in January/2023 from a Ford dealer. It had brand new tires on it. 6 months later and the outer tread of the tires are bald, that's when I realized the toe angle was pointed in. I went to Discount Tire to get new tires and an alignment. They put new tires on and then they told me they couldn't do the alignment on my truck because it has a recalled part on the rear suspension. The toe angle rods are not adjustable. He showed me what they are supposed to look like on his computer for him to do the alignment. He then proceeded to tell me how dangerous it was because if the rod cracks, my wheel will fall off. I called ford, but they are claiming there is no recall for that part, but that can't be true.
Hankook Ventus S1 Noble 2 P255R20 A/S BSW Tires 23,041 miles 2017 Ford Explorer Sport. These are the tires that came on the vehicle, there is only 23,041 miles on the vehicle and the tires are prematurely wearing on the outerside of all 4 tires. Chunks of the tire is pealing off. Hazardous to drive. The vehicle is not out of line, tires are rotated on schedule, and tire pressure maintained. Looks like defective tires, need to be investigated as safety recall. Ford Motor Company is aware of the problem and stated that we need they have a problem with those tires pealing and wearing out, most people have to replace around 20,000 to 30,000 miles. VERY DANGEROUS! I have safety inspections that shows tire are perfect.
When I had to drive with 1 inch of snow on the road it felt like my rear end was going to come out of my car. My rear end was all over the place and has been getting worse when driving in snow and rain. This is putting my children life at risk especially since there's a recall on my vehicle and there's still no parts to fix it. I want a rental car until someone gets this issues fixed! Someone is seriously going to be injured or this problem and the recall that can't be fixed. I'm scared for my safety to even drive it in the snow or rain but I have to work. This is a huge issue and I'm not sure why this is still an ongoing issue
Thr manufacturer did not put rear tire links on my vehicle. I purchased brand new tires 3 months ago and my two rear tires are already showing sings of wear and tear. I went to a mechanic to see if I could get a full alignment on my vehicle. When they started on thr alignment, they informed me that they could not proceed because the vehicle was missing the manufacturer rear toe links. If I decided to let them order rear toe links and do the alignment, it would cost me almost $600. This is completely unacceptable for ford to drop the ball again and we the consumer are stuck paying for something that they should.
Tow links from my vehicle is going bad. Vehicle fish tails a little on the highway when traveling on uneven surface. Knuckles have been replaced and Link-Stabilizer on both side by my mechanic. Ford STATED they replaced in May 2022 (never did) I had the original parts that came with vehicle. Ford refuses to reimburse. I'm concern now that the tow links are going bad and vehicle will soon be unsafe to drive.
Wheel & Tire complaints in other Explorer years
Frequently asked questions
How common are wheel & tire problems on the 2017 Ford Explorer?
NHTSA has 76 complaints about the wheels & tires of the 2017 Ford Explorer, 4% of the model year's 1,703 complaints. The component named most often is tread/belt (5 mentions).
Is there a recall for 2017 Ford Explorer wheel & tire problems?
No. NHTSA lists no wheels & tires recall for the 2017 Ford Explorer, though it has 13 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2017 Ford Explorer wheel & tire problems start?
Half of the complaints with a recorded mileage happened before about 20,000 miles, and 75% before 25,000 miles.
Is it dangerous?
Owners linked 1 crash, 0 fires and 0 injuries to wheels & tires problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.