Which parts fail
Components named in complaints (battery, alternator, wiring, ignition, instrument cluster, infotainment).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2017 Ford Explorer owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V347000 (Structure). While driving approximately 60 MPH, the driver's side B-pillar trim detached and flew off the vehicle. The vehicle was taken to the residence, inspected, and confirmed that the driver's side B-pillar trim was missing. The contact stated that the electrical system on the tailgate had stopped working as intended. The vehicle was taken to an independent mechanic; however, the cause of the failure could not be determined. The vehicle was taken to a dealer, where it was determined that the tailgate would not open because the electrical system was disconnected, and the trim had fallen off. The contact stated that on several occasions while driving at various speeds, the dome light remained illuminated and turned off approximately 4-5 seconds later. …
The contact owns a 2017 Ford Explorer. The contact stated that while driving 65 MPH, the vehicle made an abnormal beeping sound, the cabin lights illuminated unintendedly, and the message "Tailgate Ajar" was displayed. The contact decelerated and pulled over to the side of the road. The contact resumed driving; however, the failure persisted. The contact then became aware that the front driver's side door exterior keypad trim had detached and had fractured into two pieces, causing damage to the keypad wiring system. The vehicle was taken to the dealer, where it was determined that the keypad needed to be replaced. The contact purchased the part from the manufacturer's website, and the vehicle was taken to the dealer, where the part was installed; however, the failure recurred while driving. The dealer was contacted and provided an estimate for the repair. The vehicle was not repaired. …
The contact owns a 2017 Ford Explorer. The contact stated that he attempted to start the vehicle however, the engine failed to turn over. No warning lights were illuminated. The contact stated that the vehicle was towed to and independent mechanic where the vehicle was diagnosed that the relay and fuses failed and needed to be replaced. The vehicle was not repaired. The contact then stated that the independent mechanic test drove the vehicle and the vehicle stalled. The contact was then informed by the dealer that the vehicle was included in Customer Satisfaction Program: 21N01 (Cooling Fan Motor Relay). The vehicle was towed to the dealer where it was diagnosed; however, the contact was unsure of the diagnostic results. The contact was informed that the VIN was not included in a recall. The vehicle was not repaired. …
The contact owns a 2017 Ford Explorer. The contact stated while driving approximately 10 MPH and making a right turn, the steering wheel did not return to center. The contact stated that the steering wheel failed to respond normally while turning the steering wheel to center. Additionally, the contact stated that the instrument cluster went black, and the vehicle stalled. The contact pulled over safely and restarted the vehicle. The contact stated that the "System Communication Error" message was displayed on the infotainment screen after the restart. The contact later had the vehicle towed to a local dealer, where it was diagnosed and determined that the wiring harness and the GWM harness needed to be replaced. The vehicle had been repaired. The contact stated that after the repair, the battery had started to drain very quickly. …
The contact owns a 2017 Ford Explorer. The contact stated that while driving at 80 MPH, the contact heard a loud bang, and the "Door Ajar" message was displayed. The contact pulled over and noticed that the front driver's side keyless entry keypad had detached, exposing the wires from the door. The contact drove to her destination, but the rear liftgate failed to open as needed and the interior lights failed to turn off. The contact purchased and replaced the 10-amp fuse under the steering wheel, which resolved the failure with the rear liftgate and the interior lights; however, the front driver's side keyless entry keypad was not repaired. The dealer was made aware of the failure; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. …
The contact owns a 2017 Ford Explorer. The contact stated that the vehicle was running rough and was shuddering while starting and driving. The check engine warning light was illuminated. The contact stated that the failure had been recurring. The vehicle was taken to an independent mechanic twice. The mechanic determined that rodents had damaged the wiring underneath the hood. The vehicle was repaired; however, the failure recurred. The vehicle was taken to the dealer several times, and the same assessment was made. The vehicle was repaired; however, the failure persisted. The dealer determined that the wiring underneath the hood and the wiring in the rear of the vehicle needed to be replaced due to rodent damage. The vehicle was being repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 52,877.
We had an issue with Fuse 34, it popped and sent warning lights to the dash regarding safety systems and sensors, as well as the cameras in front and back stopped working. We replaced the fuse and it held for a while, but then popped again. I noticed a lamp flickering one day on the front of the vehicle, and upon further inspection saw that the front camera and wiring harness had started on fire. The wiring harness is fully melted and there are signs of smoke and fire damage on the front of the car. I took the vehicle to a Ford dealer who confirmed their wiring harness had failed, but will not take responsibility for the issue. The care only has about 45k miles on it. I called to their corporate office who also rejected any liability. Obviously this is more than just the money for repairs, but a safety hazard that they will not respond to.
We notice we were getting a warning about our battery about a year ago, so we took it to Ford and they said they couldn't find any issues. We found a mechanic in town who looked at it with a volt meter an instantly noticed that the red power cable coming from the battery had burst through the casing that once held it. Now we have an exposed power cable that could potentially catch on fire if fluids from the engine were exposed to it. We first knew something was wrong when the doors would not unlock properly. And while driving we would get a battery warning. Ford told us during our warranty period that they didn't find anything wrong when this should have been noticed instantly. This is a serious fire hazard. The vehicle was inspected by the manufacturer but a lack of knowledge by their mechanics has led to us filling this report.
The contact owns a 2017 Ford Explorer. The contact stated that the speedometer and RPM gauges were sticking. There was an abnormal ticking sound detected. While in gear, the speedometer and RPM were flashing on and off. The driver was unable to determine the speed of the vehicle while driving. The contact stated that several unknown warning lights were flashing on and off. The contact disconnected the battery. The contact cleaned the cables and terminals and replaced the battery. The vehicle started working as designed, but the failure recurred. The contact called the local dealer, who scheduled an appointment. The vehicle was not yet diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 119,000.
The contact owns a 2017 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure). However, the parts to do the recall repairs were not yet available. The contact stated that while driving at 80 MPH, the driver's side A-pillar trim detached from the vehicle. The local dealer was contacted. The vehicle was not repaired. Most recently, the keyless entry failed to function as intended. The local dealer was not contacted. The vehicle was not repaired after the most recent failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 85,000.
Electrical complaints in other Explorer years
Frequently asked questions
How common are electrical problems on the 2017 Ford Explorer?
NHTSA has 94 complaints about the electrical system of the 2017 Ford Explorer, 6% of the model year's 1,703 complaints. The component named most often is instrument panel › speedometer/odometer (4 mentions).
Is there a recall for 2017 Ford Explorer electrical problems?
No. NHTSA lists no electrical system recall for the 2017 Ford Explorer, though it has 13 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2017 Ford Explorer electrical problems start?
Half of the complaints with a recorded mileage happened before about 47,000 miles, and 23% before 25,000 miles.
Is it dangerous?
Owners linked 3 crashes, 6 fires and 0 injuries to electrical system problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.