Which parts fail
Components named in complaints (wheels, lug nuts, original-equipment tires, TPMS).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2014 Ford Explorer owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2014 Ford Explorer. The contact stated while driving 60 MPH, the vehicle lost motive power with the TPMS warning light illuminated. Additionally, the vehicle was leaking coolant. The vehicle was taken to an independent mechanic who diagnosed that the water pump needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 150,000.
At one point the Explorer was always causing a rear wheel area to squeal really loud while driving. That finally got remedied but after 3 years of taking the vehicle in to 2 different shops. While yhe vehicle was still under warranty I was told there was nothing wrong and they can't reproduce the squeal. Once the warranty expired they said it was due to a seized brake which I ended up paying for the replacement even though they said this was a known issue on the Explorers. Another issue with the 2014 Explorer is water leaking into the rear compartments and the spare tire area in the vehicle. From online sear he's, this is also a known issue with no recalls. More recently, I was trying to get all four of my tires changed, but was told by the tire shop that they can't change my tires due to swollen lug nuts,this is a known issue on Ford's and I have to take it to a mechanic. …
My Ford Explorer had a rear suspension toe link Recall, and in December I took my vehicle to the Ford dealership to get it fixed. At that time, they did a full vehicle inspection, fixed the part, and told me everything looked great. Shortly after the service, we had a snow storm, and my SUV would fishtail in Icy/snowy conditions. Every time it'd snow, it made me so scared to drive, because I'd essentially not have control over my vehicle. The issue wasn't present when the roads were clear. Within the two months since that service, my back tires have gone completely bald, down to the wires. I recently got in a car accident because my car wouldn't complete a turn and ended up t-boning a Tundra on a residential street. Luckily I was going slow so the damage to the other vehicle was minimal, and no obvious injuries have resulted from the accident. …
Steering fault warning message came up service now and stability control lights engaged both on and off, I lost control of my steering and it completely tightened up as I was driving. I was driving 60 miles per hour when this happened. Depending on the severity of the failure, I was completely at risk with colliding with anything on the road. I brought it straight to the dealership where it has been sitting for a week since they are not able to drive it into the garage because the steering is locked up and the wheel will not move even though it will start and engage in drive. They need to actually tow it into the garage to complete diagnostics, I expect from other reports this is an expensive fix, but the risk to my life and others on the road is worth reporting. Ford needs to include this steering fault on the 2014 explorers in a recall. …
Hi my name is [redacted] and Im an owner of a 2014 Ford Explorer sport my vehicle is at the service department for almost 2 months already before i took the vehicle into the dealership to get fix i was going to have a car crash thanks to the front tires of the car. Both front tires locked and the car slide really bad that day the steering wheel went loose and i wasnt able to control the vehicle. I took it to the service department at a ford dealership where I was told that the ABS was falling the computer module was not working and the traction control has an issue too
The wheels corrode around edges & Bead mounting area due to improper procedures done during manufacturing. The factory only put clear protection on the outside (visible portion) of the wheel. Thus the elements enter under the clear coating from the un-protected portion of the wheel. As this corrosion expands, it causes the Bead of the tire to leak. The leaking gets more rapid in a short time and causes poor handling & can cause a loss of control. The Ford Customer Forum has Hundreds, if not Thousands of Customer Complaints. The problem is that Ford will not stand behind their product and doesn't care about the Safety Danger to their Customers.
My 2014 Explorer has developed corrosion on all 4 aluminum wheels causing air loss along the tire bead while driving. Underinflated tires generate heat, tire distortion and catastrophic failure. I had one wheel "repaired" at Tom's Ford in February 2023 at a cost of 187.95. Please see attached and note Ford themselves refer to the rim as rusted. Aluminum wheels should not rust nor corrode. It is my position Ford used dissimilar metals for coating the wheels to enhance appearance and in the process has created a dangerous situation of leaking tires.
My vehicle has been experiencing the "death wobble". I've done research online and I've seen other people complain about the issue as well as videos. Whenever I drive my vehicle, I hear noises coming from the front end such as scraping and my steering wheel wobbles and it's excessive while on the freeway. I've gotten the wheel bearings replaced, tires rotated, replaced front passenger tire, breaks and rotors replaced. My axel and car were lifted in the air with no damages.
My steering is making a scretching noise when I try to turn it either way. With it being hard to turn I'm afraid for my safety with driving it and I dont have another vehicle to drive. Yes, I have a quote from a repair shop that my steering rack is going out I didn't notice a warning light as of yet.- this happened about a week ago I have found several complaints about the 2014 Ford Explorer Steering issues so I feel for safety purposes that this should have a recall.
Vehicle has code C0063-64ABS. Also has a problem with the restraint control module and ABS module causing the front tires to lock and make the car slide. I was about to get into a car crash on Oct 24,2024 because the cars front tires locked and just slide from one side to other the steering wheel went loose and I wasn't able to control the car I took it to ford dealership where they told me that it has the code that appears at the beginning of this message
Wheel & Tire complaints in other Explorer years
Frequently asked questions
How common are wheel & tire problems on the 2014 Ford Explorer?
NHTSA has 30 complaints about the wheels & tires of the 2014 Ford Explorer, 2% of the model year's 1,682 complaints. The component named most often is hubcap/cover (1 mentions).
Is there a recall for 2014 Ford Explorer wheel & tire problems?
No. NHTSA lists no wheels & tires recall for the 2014 Ford Explorer, though it has 6 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2014 Ford Explorer wheel & tire problems start?
Half of the complaints with a recorded mileage happened before about 72,000 miles, and 13% before 25,000 miles.
Is it dangerous?
Owners linked 2 crashes, 0 fires and 1 injury to wheels & tires problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.