Which parts fail
Components named in complaints (automatic and manual transmissions, CVT, axles, driveshaft, 4WD/AWD).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2011 Ford Explorer owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2011 Ford Explorer. The contact stated that while the windshield wipers were in the on position, the wipers went off the vehicle and had to be pushed back into place. There was an unknown yellow warning light illuminated. The contact stated that while making a turn, the driver's and passenger's front wheels detached on two occasions. The vehicle was taken to an independent mechanic and the vehicle received an unstated repair. There was an abnormal sound while driving at various speeds. While shifting gear, the vehicle jumped. The vehicle was taken to the local dealer however, the result of the diagnostic test was unknown. The vehicle was repaired. The manufacturer was not contacted. The failure mileage was approximately 104,000.
The contact owns a 2011 Ford Explorer. The contact stated that on five different occasions while driving at various speeds, the power steering warning light illuminated, and the steering wheel became firm, making it difficult to steer the vehicle. The contact stated that on one occasion, the vehicle was towed to a dealer where the contact was informed that the power steering gear needed to be replaced. The vehicle was repaired; however, the failure recurred a week later. The manufacture was notified of the failure. The failure mileage was approximately 120,000.
The contact owns a 2011 Ford Explorer. The contact stated while driving approximately 30 MPH and making a left turn, the power steering and 4WD suddenly failed, causing the steering wheel to become difficult to turn in either direction. The 4WD was independently deactivated. During the failure, the message "Service Power Steering" and "Service Power Track" were displayed. The cause of the failures was not yet determined. The manufacturer and local dealer were notified of the failures, but no assistance was offered. The failure mileage was 110,000.
I had a recall on my 2011 Ford explorer for toe Links and bushings. Since ever since this has been going on I have gone through 38 tires in the rear in the past two years alone no shop will fix my car because the camber is so out of whack I have to have the whole rear suspension redone again when it should have been fixed the first time with the recall link Ford spent 5 minutes going through my car and said that my car didn't qualify for any recall because my car is a front wheel drive and not an all-wheel drive so they did not do the recall now after bringing it to another shop I have the estimate of what it would cost to fix that needs to be done it is an emergency because when I hit a pothole I go in the ditch my friend and his smashed because I can't control my car my steering freezes while driving down the highway and this all has something to do with the rear suspension five Star …
Every time we put the car in park, it would not register that it was in park and warning kept flashing that said shift to park. We had to just turn off the car most of the time and sometimes wiggling the shifter would work any time the "Not in Park" sign comes on when I know the gear is in park. I believe this can cause serious damage to property or cause death since the vehicle can roll. I believe Ford Motor Co should own up and recall all vehicles for service much for This is a known problem that has been know to happen to 2011 Edge and Explorers. The switch in the console shifter tends to fail prematurely. If the light does not light up the computer thinks the car is NOT in Park and alarms go off. THIS NEEDS TO BE FIXED BY FORD THIS IS A SAFETY ISSUE
The power steering system fault failed .Yes, the power steering system is available for inspection upon request.The failure of the power steering system put my safety and the safety of others at risk because it became extremely difficult to steer the vehicle, especially at low speeds, which could have led to a loss of control and potential accidents.Yes, the problem has been reproduced and confirmed by SUBURBAN FORD OF TROY .The vehicle has been inspected by SUBURBAN FORD OF TROY.There were no warning lamps or messages prior to the failure. The issue first appeared suddenly while driving on September 14, 2024.
The wheel locks in low speeds. It does not happen often, maybe about 3 times per year. I have brought this up to Ford dealer in Encinitas CA for several years and the problem is seldom that they did not find anything wrong with it. Recently I found the recall online and brought it to their attention. I never received the notice of recall back in 2015. They are refusing service because it has been more than 10 yrs since the recall and my vehicle is at 180,000 miles. I use the car to carpool my kids and other people's kids. Please help fix the problem.
Between 7/17/20 and 9/7/20 car stalled five times and stopped moving while in drive mode with no warning. Dealer kept car from 7/30/20 to 8/7/20, but problem was not fixed. Car returned to dealer 9/8/20 and kept by them until 9/16/20 when it was returned with problem apparently fixed. No problem since. Diagnosed Throttle Body Failure. Have verifying work order and invoice.
As I was driving, a "service Power steering" warning came on along with another warning about my power assist being lost. I have taken my car to see a mechanic a total of 4 times for this same issue and need answers or reimbursement.
Driving along and the power steering assist went out. I called dealer and they said if it was over 10 years they didnt have to repair it. According to your website, It has a 15 year window. Please advise
Transmission complaints in other Explorer years
Frequently asked questions
How common are transmission problems on the 2011 Ford Explorer?
NHTSA has 64 complaints about the transmission & drivetrain of the 2011 Ford Explorer, 5% of the model year's 1,197 complaints. The component named most often is transmission case/housing (1 mentions).
Is there a recall for 2011 Ford Explorer transmission problems?
No. NHTSA lists no transmission & drivetrain recall for the 2011 Ford Explorer, though it has 6 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2011 Ford Explorer transmission problems start?
Half of the complaints with a recorded mileage happened before about 53,000 miles, and 21% before 25,000 miles.
Is it dangerous?
Owners linked 2 crashes, 0 fires and 1 injury to transmission & drivetrain problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.