Which parts fail
Components named in complaints (wheels, lug nuts, original-equipment tires, TPMS).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2020 Ford Escape owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2020 Ford Escape. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while attempting to start the vehicle, the vehicle hesitated to start. The TPMS warning light was illuminated. The local dealer was contacted, and the contact was advised that the recall remedy was available for vehicles experiencing a recall-related failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 82,000.
The contact owns a 2020 Ford Escape. The contact stated while driving at approximately 40 MPH, the message "Low Tire Pressure Fault" was displayed. The vehicle was taken to a local dealer, where it was diagnosed that the TPMS sensor needed to be replaced. The contact related the failure to NHTSA Campaign Number: 20V635000(Electrical System, Tires); however, the dealer informed the contact that the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was notified of the failure and provided the same information. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 41,000.
The contact owns a 2020 Ford Escape. The contact stated that the vehicle was taken to the local dealer for an unstated recall repair. Upon retrieval of the vehicle, the pre-collision, driver assist, and cross traffic systems were inoperable. The vehicle was taken back to the local dealer, where the modules were updated, but the failure persisted. The tire pressure fault message was displayed, and the rear bumper sensors were inside the vehicle. The manufacturer was contacted and informed the contact about diagnostic testing, but no assistance was provided. The failure mileage was approximately 65,188.
The contact owns a 2020 Ford Escape. The contact stated that the message "Tire Pressure Sensor Fault" was displayed for the rear passenger's side tire; however, the tire air pressure appeared to be normal upon inspection. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, but no assistance was provided. The contact was informed that the VIN was not included in NHTSA Campaign Number: 20V635000 (Electrical System, Tires). The failure mileage was 78,000.
The contact owns a 2020 Ford Escape. The contact received notification of NHTSA Campaign Number: 25V467000(Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the message "Tire Pressure Monitor Fault," was displayed. The dealer was not contacted. No further information was available. The manufacturer was not made aware of the issue. The failure mileage was 61,067.
Subject: Safety Complaint - TPMS & Trunk System Failure on 2020 Ford Escape Hybrid I'm reporting two ongoing issues with my 2020 Ford Escape Hybrid that I believe are connected to a recall I've seen issued for other vehicles of the same make and model year. 1. Tire Pressure Monitoring System (TPMS): My dashboard only displays pressure readings for two of the four tires. The other two do not register at all, which makes it difficult to monitor tire safety. 2. Trunk Release Button Failure: The button to electronically open my trunk no longer works. I have to manually open the liftgate each time, which is not how the vehicle was designed to function. The last time I took my vehicle in for a recall-related service, I was told I would need to return to complete additional recall work. …
I purchased four brand new tires Douglas touring AS 102 H all season tires on September 12, 2024 with my mileage at 48,906 miles. On July 14th 2026 I went to Portsmouth Ford used car for a recall the inspected my tires and said I had 7/32 of tread life left. Today on September 17, 2026 I was told by Walmart in Portsmouth New Hampshire I had hardly any tread left on all four tires and they needed to be replaced. The tires I had bought from Walmart on September 12, 2024 it cost me $501 for Ford tires with a 50,000 mile warranty or five years Natalia brand is Douglas touring AS102H all season tire number is 1M62YPH13324 . The mileage on my car today is 79,768 miles so if you do the calculations 79,768-48,906 when I bought the tires you're looking at roughly the tires only got 30,000 miles out of those tires. . …
I brought my vehicle into its manufacturer service center after noticing several issues. The vehicle was not maneuvering as smoothly as it used to and when it hit bumps I would feel a slight loss of control. This is extremely dangerous, especially in the coming winter months where it snows heavily where I live in the midwest. I also hear like a cracking sound underneath the vehicle. I saw several service light illuminate to include: AWD Fault Service Required, Hill Start Not Available, and Pre Collision Assist Not Available. I brought in my vehicle into the Ford Service Center and they advised me that I needed to replace the AWD module and that this has been a common trend among the Ford Escape vehicles. I conducted research online and observed that several people have also had complaints about the same if not similar issues with the same year, make, and model of my vehicle. …
Lugnuts are swollen and a flat had occurred and I couldn't remove the wheel was almost hit by on coming traffic finally gave up replenished air into tire and drove Home . Took car into Ford dealership they said all of the Lugnuts swell on newer models not just mine I asked for a replacement quote it's 300 for new Lugnuts and then labor too and hopefully they won't break a wheel removing them I said if I agreed would they replace them with the same defective Lugnuts that swell and his answer was yes .Please do something about thease dangerous swelling Lugnuts before someone's life is taken. …
ALL WHEEL DRIVE STOPPED FUNCTIONING IN ICY/SNOWY CONDITION. CAUSING UNSAFE DRIVING CONDITIONS. WARNING MESSAGE: Driver display indicates, "ALL wheel drive module faulty, driver assist not available. Service required!" and an orange wrench displayed >>There is already a bulletin on this issue for 2020 Ford Escapes CSB21B19, April 2021, however our VIN was not included in bulletin. >> We took the car back to the dealership for repairs and they said they are having MANY Escapes coming in with this issue whose VINs are also not included in the original bulletin >> No pre warning. The first time we saw the warning the AWD failed on snowy road. >>We contacted FORD customer service and got the run around. FORD NEEDS TO INCREASE THE LIST OF VINS INCLUDED IN THE BULLETIN SO PEOPLE CAN GET THE MODULE REPLACED TO PREVENT THE LOSS OF AWD IN SNOWY/ICY CONDITIONS.
Wheel & Tire complaints in other Escape years
Frequently asked questions
How common are wheel & tire problems on the 2020 Ford Escape?
NHTSA has 27 complaints about the wheels & tires of the 2020 Ford Escape, 2% of the model year's 1,612 complaints. The component named most often is pressure monitoring and regulating systems (4 mentions).
Is there a recall for 2020 Ford Escape wheel & tire problems?
No. NHTSA lists no wheels & tires recall for the 2020 Ford Escape, though it has 23 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2020 Ford Escape wheel & tire problems start?
Half of the complaints with a recorded mileage happened before about 41,000 miles, and 44% before 25,000 miles.
Is it dangerous?
Owners linked 1 crash, 0 fires and 4 injuries to wheels & tires problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.