Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2025 Chevrolet Traverse owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2025 Chevrolet Traverse. The contact stated that while driving at approximately 45 MPH through a green light, another vehicle failed to yield at 50 MPH for a red light due to being impaired, causing a collision in which the contact's vehicle was T-boned. No warning lights were illuminated before the crash. The front and side curtain air bags failed to deploy. The contact reported that no injuries were immediately sustained, and no medical attention was provided at the scene. However, the contact was later transported to a local emergency facility and diagnosed with a back injury. A police report was filed.. The vehicle was towed to an independent mechanic, where it was diagnosed that the air bags, service brakes, and battery of the vehicle had failed and needed to be replaced. The vehicle was not repaired. The dealer was not contacted. …
The contact owns a 2025 Chevrolet Traverse. The contact stated that while her husband was driving at 30 MPH on an expressway, occupied with his wife in the vehicle, seated on the front passenger side, attempting to depress the brake pedal, the vehicle failed to respond as intended, causing the front end of the vehicle to crash with the rear end of the vehicle in front. The contact mentioned that the brake pedal felt abnormally hard and excessive force was applied; however failed to bring the vehicle to a stop, causing the crash. The air bags did deploy. The vehicle was towed to a tow yard, the vehicle was then towed to the insurance company. The contact stated she and her husband did not sustain any injuries. No medical attention was required. A police report was filed. The manufacturer was not notified of the failure. The approximate failure mileage was 2,000.
The contact owns a 2025 Chevrolet Traverse. The contact stated that while driving, approaching a traffic light, the Electronic Stability Control (ESC), rear collision warning, service assist, front collision warning, check engine light, and multiple brake warning lights illuminated. The emergency brake failed to function. The vehicle was towed to a local dealer, where the master cylinder failure was diagnosed, and the part was replaced. However, while driving after the repair, a complete brake failure occurred alongside the same warning lights. The contact lost control of the vehicle and traversed two intersections. The contact attempted multiple times to stop the vehicle, and the contact's daughter exited the moving vehicle before the contact stopped the engine by depressing the ignition button. The police were contacted, and a CAD report was generated. …
The contact owns a 2025 Chevrolet Traverse. The contact stated that while driving 70 MPH during a road trip, the ABS warning light illuminated upon depressing the brake pedal. The contact stated that the messages "Control Module Performance Warning" and "Forward Collision Alert System" were displayed. The contact continued driving, and the brake pedal and steering wheel became stiff. The vehicle was pulled over to the side of the road and restarted. The message "Do Not Drive the Vehicle over 62 MPH" was displayed. The vehicle was taken to a dealer, where it was partially diagnosed that the brake plunger motor temperature was too high, and there was a braking performance failure. The dealer reset unknown sensors, and the contact and his family drove to the destination. …
The contact owns a 2025 Chevrolet Traverse. While the contact's wife was driving approximately 5 MPH, the brakes independently activated while the accelerator pedal was depressed. The ABS, traction control, check engine, collision avoidance, and other unknown warning lights illuminated. An audible alert chimed erroneously without a pedestrian nearby. Due to the failure, the contact's chest struck the steering wheel. A passenger seated in the front passenger's side seat experienced mental distress. The vehicle was taken to a local dealer, where it was diagnosed, and DTC: P053D, C055F, P25A2, and 25NA240 were retrieved. The vehicle was repaired under warranty; however, the failure persisted. The vehicle was taken back to the same local dealer and scanned with an OBD2 scanner, and the failures were confirmed. The manufacturer was made aware of the failure. …
The contact owns a 2025 Chevrolet Traverse. The contact stated that while driving at slow speeds, the red "Service Brake Assist Warning" light and ESC (Electronic Stability Control) message were displayed. Additionally, the yellow ABS, Cruise Control, and Traction Control warning lights were illuminated. Due to the failure, the contact returned to the residence and parked the vehicle. The dealer was contacted and agreed to have the vehicle towed from the residence to the dealer. The dealer performed a diagnostic and retrieved DTC: C055F, for the brake master cylinder failure. The dealer informed the contact of Technical Service Bulletin: 25-NA-240; and the failure was associated with the failure. The manufacturer was notified of the failure but offered no assistance. The vehicle was not repaired and remained with the dealer. The failure mileage was approximately 11,000.
The contact owns a 2025 Chevrolet Traverse. The contact stated that while driving 40 MPH, the semi-truck in front of the vehicle started slowing down and the contact depressed the brake pedal and the brakes failed. When the brake pedal was first depressed the brake pedal was extremely firm. While forcefully depressing the brake pedal the brake pedal went to the floorboard and the braking distance became extended. The Brake Assist Failure, Warning Brake, Park, ABS, Starter Control, Crash, and ESC warning lights were illuminated. Additionally, the parking brake was inoperable, and the vehicle was coasted to a stop. The contact became aware that there was fluid leaking underneath the vehicle. A Police report was filed. The vehicle was towed to the dealer. The manufacturer was contacted by phone and made aware of the failure. The failure mileage was approximately 21,589.
The contact owns a 2025 Chevrolet Traverse. The contact stated while driving approximately 70 MPH, the vehicle shifted into LIMP Mode, causing the vehicle to decelerate unintendedly. During the failure the headlights and the interior lights flashed and flickered, and the ABS, traction control, and several unknown messages were displayed. While depressing the brake pedal, the brake pedal extended to the floor and the vehicle failed to immediately stop. The vehicle was later towed to the local dealer who recharged the battery and performed a software update to the Crucial Control Module. The contact stated that three weeks later the same failure had reoccurred. The local dealer and manufacturer were notified of the failure. The failure mileage was 9,995.
The contact owns a 2025 Chevrolet Traverse. The contact stated that while driving at an undisclosed speed, the messages "ESC", "ABS", "Brakes", "Emergency Brakes", "Forward Collision", "Emergency Parking Brake", and "Speed Limited" displayed. The contact depressed the brake pedal and it went to the floorboard. The vehicle failed to stop immediately. The contact activated the hazard lights, and the vehicle coasted to the shoulder. The vehicle was turned off and restarted. The vehicle was able to drive to the destination, but the failure recurred two days later. The vehicle was towed to the dealer but was not yet diagnosed or repaired. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 17,000.
The contact owns a 2025 Chevrolet Traverse. The contact stated that while driving at an undisclosed speed, there was an abnormal metal-on-metal sound coming from the front brakes. No warning light was illuminated. The vehicle was taken to the dealer; however, no cause for the failure was found. The dealer lubed the brakes; however, the failure persisted, and the abnormal grinding sound had worsened. The vehicle was taken back to the dealer. However, no cause for the failure was found. The dealer lubed the brakes and informed the contact that the failure was common with the vehicle. The contact stated that the sound worsened. The manufacturer was made aware of the failure. The failure mileage was approximately 7,000.
NHTSA investigations
Electronic Brake Module Component Failure
On April 11, 2024, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE24011 after receiving complaints concerning a loss of brake assist in 2023 MY Cadillac Lyriq vehicles. These complaints allege a hard brake pedal, followed by a "Brake System Failure" message at start up or while driving.
Brake complaints in other Traverse years
Frequently asked questions
How common are brake problems on the 2025 Chevrolet Traverse?
NHTSA has 118 complaints about the brakes of the 2025 Chevrolet Traverse, 64% of the model year's 185 complaints.
Is there a recall for 2025 Chevrolet Traverse brake problems?
No. NHTSA lists no brakes recall for the 2025 Chevrolet Traverse. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2025 Chevrolet Traverse brake problems start?
Half of the complaints with a recorded mileage happened before about 13,000 miles, and 91% before 25,000 miles.
Is it dangerous?
Owners linked 3 crashes, 0 fires and 5 injuries to brakes problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.