Which parts fail
Components named in complaints (automatic and manual transmissions, CVT, axles, driveshaft, 4WD/AWD).
Owner reports
Selected complaints filed with NHTSA by 1995 Chevrolet Astro owners, lightly cleaned up (personal details are redacted by NHTSA).
Consumer has experienced several problems with vehicle, right rear blinker and parking brake bulb failed. Back hatch would not open, door was locked and would not open, dealer found latch rod retainers worn out. Alternator failed. Serpentine belt failed. Air conditioner quit blowing. Rear end was roaring, dealer replaced rear differential. Oil pressure would go to zero, dealer replaced indicator. Vehicle experienced missing, dealer replaced spark plub and distributor cap, when the engine cover was removed, dealer found the plug wires shorting to the cylinder head, dealer replaced all plug wires. Vehicle would turn, but would not start, dealer found fuel pump shorted out, dealer replaced fuel pump system. Oil leaking at pinion area, dealer replaced front differential and pinion seal. Rear axle was replaced due to rear axle seal leaking. …
The park pawl did not engage which caused the vehicle to roll down hill with 2 children in the car. Then crashed into trees, no injuries involved. Dealer said inter- lock safety system malfunctioned.
I have heard in the past that Chevrolet has had troubles with the transmisions in the Chevrolet astros. I own a Chevrolet Astro and have experienced the trans. Slipping I am looking for information in regaurds to any factory recalls or hidden warenties from the manufacture
Engine stalls out for no reason/ABS brakes do not stop vehicle when brakes applied/transmission fails to shift into reverse and instrument panellights stay on during the day. Vehicle still running after ignition is turned off. Taking to dealer again.
Key was in ignition but the engine was not activated. Child moved automatic transmission lever without holding down the brakes, which resulted in vehicle rolling away. Please provide further information.
The truck was in park and the truck slips out of gear then rolled down the hill hit a tree and airbag didn't deploy,the sliding door feel off while getting out.
Loud clunking/banking noise between 2nd and 3rd gears; also, from park to drive/drive to park; has not caused any problems at this time. Tt
Clunk when putting vehicle in gear, and the vehicle does not hold in park and reverse gears due to possible transmission failure. Yh
Rear wheel bearings experienced excessive wear. In addition, replaced idler arm/ring and pinion gear/front brake pads/rotors.
Transmission complaints in other Astro years
Frequently asked questions
How common are transmission problems on the 1995 Chevrolet Astro?
NHTSA has 21 complaints about the transmission & drivetrain of the 1995 Chevrolet Astro, 5% of the model year's 446 complaints. The component named most often is automatic transmission (14 mentions).
Is there a recall for 1995 Chevrolet Astro transmission problems?
No. NHTSA lists no transmission & drivetrain recall for the 1995 Chevrolet Astro, though it has 3 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
Is it dangerous?
Owners linked 2 crashes, 1 fire and 1 injury to transmission & drivetrain problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.