Most common 1995 Chevrolet Astro problems
Share of the 446 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Chevrolet Astro complaints by model year
Best Astro years: 2005, 2004, 2003. Years to avoid: 1995, 1997, 1996, 1998, 2000. Compare all years →
1995 Chevrolet Astro recalls (3)
Visibility › Windshield wiper/washer
On certain minivans, pickup trucks, and sport utility vehicles with certain model-engine combinations, the windshield wiper motor May fail due to cracked solder joints on the controller circuit board. The windshield wipers could work intermittently or not at all.
Remedy: Dealers will replace the wiper motor circuit board and cover. Owner notification began on June 19, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free…
Suspension › Front › Control arm › Lower arm
These vehicles were assembled with the left-hand lower control arm-to-frame rear nut not tightened to the specified torque.
Remedy: Dealers will tighten the left-hand lower control arm-to- frame rear nut to the proper torque specification.
Fuel system, gasoline › Storage › Tank assembly › Mounting
The fuel lines attached to the fuel tank were not properly tightened.
Remedy: Dealers will lower the fuel tank and tighten the fuel tank lines to the proper torque value.
NHTSA defect investigations
Federal safety investigators have looked into 3 possible defects involving the 1995 Chevrolet Astro:
Windshield wiper
Windshield wiper failure
As a result of this, and the precedinginvestigation, rq99-003, GM has expanded the population of safety recall 98v-150 (replacement of the windshield wiper control module) to include an additional 1.77 million vehicles.included are various 1994-1997 my m/l vans, s/t trucks and suvs, & c/k trucks and suvs.see attached technical report for details.
Loss of power assist
There is no summary currently available
What 1995 Chevrolet Astro owners say
Brakes all 109 →
Dt*: the contact stated, intermittently, while the road conditions were wet and snowy the brakes did not operate correctly. There was no pressure in the brake pedal and the vehicle would not stop, resulting in an accident. The contact's vehicle rear ended a truck. A police report was taken. There were multiple repairs made to the vehicle at the dealership, but the problem persisted. Updated 06/07/2006.
I have had problems with my 1995 Astro van 4.03l from the day I bought it hard starting asb locking up dealer replaced EGR value twice took back with same problem 3 months later was told nothing wrong computer digital check said so now I have gotten 2 mechanics to look at it and said the EGR valve fuel lind stays open pouring out gas they want to charge my 600.00 to clean out the sluge this problem has been going on for 3 years my van now has 82000 miles and it sounds and smells like a mac truck I also has to replace to wiper motor about 2 years ago and I paid for it I just a notice to replace it it no charge I cant find the orginal receipt so I'm out another120.00 for that repair along with the 65.00 so a local mechanic. …
Windows, wipers & sunroof all 101 →
I have had problems with my 1995 Astro van 4.03l from the day I bought it hard starting asb locking up dealer replaced EGR value twice took back with same problem 3 months later was told nothing wrong computer digital check said so now I have gotten 2 mechanics to look at it and said the EGR valve fuel lind stays open pouring out gas they want to charge my 600.00 to clean out the sluge this problem has been going on for 3 years my van now has 82000 miles and it sounds and smells like a mac truck I also has to replace to wiper motor about 2 years ago and I paid for it I just a notice to replace it it no charge I cant find the orginal receipt so I'm out another120.00 for that repair along with the 65.00 so a local mechanic. …
Windshiel wipers intermittently quit working, just like my 1996 blazer and 1997 k3500. This is a serious problem involving what appears to be all of GM's vehicles where the wipers quit working at critical times or May not begin working when needed. Please help consumers today.
Suspension all 75 →
Takata recall upon leaving my condominium parking lot, there is a slight curb you must drive over before exiting. The left lower control arm came loose while making a right turn onto a local city street. Resulting in the vehical to collapse on the drivers side of the car. The frame is rested on the front left tire, also damaging the drivers side door as a result. Considering the facts, the car was then completely immobile. I had to call a tow costing $100 in order to move it about 150 ft. Back to my designated parking space. Recall # 95V175000. This happened on 07/05/2017.
Consumer has experienced several problems with vehicle, right rear blinker and parking brake bulb failed. Back hatch would not open, door was locked and would not open, dealer found latch rod retainers worn out. Alternator failed. Serpentine belt failed. Air conditioner quit blowing. Rear end was roaring, dealer replaced rear differential. Oil pressure would go to zero, dealer replaced indicator. Vehicle experienced missing, dealer replaced spark plub and distributor cap, when the engine cover was removed, dealer found the plug wires shorting to the cylinder head, dealer replaced all plug wires. Vehicle would turn, but would not start, dealer found fuel pump shorted out, dealer replaced fuel pump system. Oil leaking at pinion area, dealer replaced front differential and pinion seal. Rear axle was replaced due to rear axle seal leaking. …
1995 Chevrolet Astro engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 4.3L 6-cyl | 4-speed automatic | RWD | 15 / 20 / 17 |
| 4.3L 6-cyl | 4-speed automatic | 4WD/AWD | 15 / 20 / 16 |
EPA ratings. Class: Van.
Frequently asked questions
Is the 1995 Chevrolet Astro a good car?
Based on 446 owner complaints filed with NHTSA, the 1995 Astro rates avoid: 4.0× as many complaints as a typical year of the Astro at the same age. It is one of the Astro years we suggest avoiding. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 1995 Chevrolet Astro?
The brakes — 109 complaints, 24% of all complaints for this model year, most often about antilock/traction control/electronic limited slip. Next are the windows, wipers & sunroof (101) and suspension (75).
How many recalls does the 1995 Chevrolet Astro have?
There are 3 recalls for the 1995 Chevrolet Astro, the most recent from April 28, 2003 (windshield wiper/washer). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Chevrolet Astro?
The best years by complaints, compared at the same age, are 2005, 2004 and 2003. Years to avoid or approach with caution: 1995, 1997, 1996, 1998 and 2000. See the full Chevrolet Astro years comparison.
At what mileage do 1995 Chevrolet Astro problems happen?
The median mileage reported in complaints is about 114,000 miles; 0% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.