What gets recalled
2027 Volvo VNL recalls (7)
Service brakes, electric › Software/programming
Volvo Trucks North America (Volvo Trucks) is recalling certain 2025-2027 VNL (4) and 2026-2027 VNR (4) vehicles equipped with a tanker application package. Inaccurate axle load calculations may cause reduced braking performance while transporting smoothbore tanker trailers.
Remedy: Dealers will install new software to disable the dynamic trailer braking calculations, free of charge. Owner notification letters are expected to be mailed November 27, 2026.
Exterior lighting
Volvo Trucks North America (Volvo Trucks) is recalling certain 2026-2027 VNL (4) and VNR (4) vehicles. The center roof marker lights may fail to illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Remedy: Dealers will replace the center roof marker light, free of charge. Interim letters notifying owners of the safety risk were mailed September 22, 2026. Additional letters will be sent once the final remedy is available.
Steering › Linkages › Knuckle › Spindle › Arm
Volvo Trucks North America (Volvo Trucks) is recalling certain 2026 VOLVO VAH, VN, VHD, 2026-2027 VNL (4) and VNR (4) vehicles. The steering knuckles may have been manufactured with insufficiently tightened steering arms.
Remedy: Dealers will inspect and tighten the fasteners between the steering arm and steering knuckle, as necessary, free of charge. Owner notification letters were mailed July 27, 2026.
Wheels › Lugs/nuts/bolts/studs
Volvo Trucks North America (Volvo Trucks) is recalling certain 2026 VAH, 2026-2027 VN, VHD, VNL (4), and 2027 VNR (4) vehicles. The wheel lug nuts may loosen and allow the wheel to detach.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Dealers will inspect the wheel and hub mating surfaces, remove any masking material, and replace any worn components if necessary, free…
Show 3 more recalls
Service brakes, air › Antilock › Control unit/module
Volvo Trucks North America (Volvo Trucks) is recalling certain 2026-2027 VNR (4) and 2025-2027 VNL (4) vehicles. The rear brake modulators may have unprotected electrical connectors that can short circuit and lead to a loss of the anti-lock brake system (ABS) and electronic stability control (ESC).
Remedy: Dealers will inspect the rear brake modulator electrical connectors, install a protective cover, and replace the rear brake modulators, as necessary, free of charge. Owner notification letters were mailed June 8, 2026.
Exterior lighting › Turn signal
Volvo Trucks North America (Volvo Trucks) is recalling certain 2025-2027 VNL (4) and 2026-2027 VNR (4) vehicles. The vehicle turn signals may not function properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated…
Remedy: Dealers will update the turn signal indicator software, free of charge. Owner notification letters were mailed May 7, 2026. Owners may contact Volvo Trucks' customer service at 800-528-6586.
Parking brake
Volvo Trucks North America (Volvo Trucks) is recalling certain 2024-2027 VNL (4) vehicles that do not include auxiliary parking brakes. If the vehicle is in weight bias mode there may not be enough weight on the parking brake axle, which could result in inadequate parking brake force.
Remedy: Dealers will replace the brake chambers, free of charge. Owner letters were mailed May 29, 2026. Owners may contact Volvo Trucks' customer service at 800-528-6586. Volvo Trucks' number for this recall is RVXX2601.
2026 Volvo VNL recalls (17)
Structure
Volvo Trucks North America (Volvo Trucks) is recalling certain 2025-2026 VNL (4) vehicles. The truck cabs may have loose or missing structural bolts.
Remedy: Dealers will inspect for missing structural bolts and install and/or tighten the bolts, as necessary, free of charge. Owner notification letters are expected to be mailed December 14, 2026.
Service brakes, electric › Software/programming
Volvo Trucks North America (Volvo Trucks) is recalling certain 2025-2027 VNL (4) and 2026-2027 VNR (4) vehicles equipped with a tanker application package. Inaccurate axle load calculations may cause reduced braking performance while transporting smoothbore tanker trailers.
Remedy: Dealers will install new software to disable the dynamic trailer braking calculations, free of charge. Owner notification letters are expected to be mailed November 27, 2026.
Exterior lighting
Volvo Trucks North America (Volvo Trucks) is recalling certain 2026-2027 VNL (4) and VNR (4) vehicles. The center roof marker lights may fail to illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Remedy: Dealers will replace the center roof marker light, free of charge. Interim letters notifying owners of the safety risk were mailed September 22, 2026. Additional letters will be sent once the final remedy is available.
Steering › Linkages › Knuckle › Spindle › Arm
Volvo Trucks North America (Volvo Trucks) is recalling certain 2026 VOLVO VAH, VN, VHD, 2026-2027 VNL (4) and VNR (4) vehicles. The steering knuckles may have been manufactured with insufficiently tightened steering arms.
Remedy: Dealers will inspect and tighten the fasteners between the steering arm and steering knuckle, as necessary, free of charge. Owner notification letters were mailed July 27, 2026.
Show 13 more recalls
Wheels › Lugs/nuts/bolts/studs
Volvo Trucks North America (Volvo Trucks) is recalling certain 2026 VAH, 2026-2027 VN, VHD, VNL (4), and 2027 VNR (4) vehicles. The wheel lug nuts may loosen and allow the wheel to detach.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Dealers will inspect the wheel and hub mating surfaces, remove any masking material, and replace any worn components if necessary, free…
Service brakes, air › Antilock › Control unit/module
Volvo Trucks North America (Volvo Trucks) is recalling certain 2026-2027 VNR (4) and 2025-2027 VNL (4) vehicles. The rear brake modulators may have unprotected electrical connectors that can short circuit and lead to a loss of the anti-lock brake system (ABS) and electronic stability control (ESC).
Remedy: Dealers will inspect the rear brake modulator electrical connectors, install a protective cover, and replace the rear brake modulators, as necessary, free of charge. Owner notification letters were mailed June 8, 2026.
Exterior lighting › Turn signal
Volvo Trucks North America (Volvo Trucks) is recalling certain 2025-2027 VNL (4) and 2026-2027 VNR (4) vehicles. The vehicle turn signals may not function properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated…
Remedy: Dealers will update the turn signal indicator software, free of charge. Owner notification letters were mailed May 7, 2026. Owners may contact Volvo Trucks' customer service at 800-528-6586.
Electrical system › Instrument cluster/panel
Volvo Trucks North America (Volvo Trucks) is recalling certain 2025-2026 VNL (4) vehicles. The instrument panel may fail while driving. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Controls and Displays."
Remedy: Dealers will replace the instrument panel clusters, free of charge. Owner notification letters were mailed May 8, 2026. Owners may contact Volvo Trucks' customer service at 800-528-6586.
Service brakes, air › Supply › Hoses, lines/piping, and fittings
Volvo Trucks North America (Volvo Trucks) is recalling certain 2025-2026 VNL (4) vehicles. The service brake may take longer than expected to release. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 121, "Air Brake Systems."
Remedy: Dealers will install an additional brake valve and fittings to the service brake pneumatic plumbing, free of charge. Owner letters were mailed July 29, 2026.Owners may contact Volvo Trucks' customer service at…
Parking brake
Volvo Trucks North America (Volvo Trucks) is recalling certain 2024-2027 VNL (4) vehicles that do not include auxiliary parking brakes. If the vehicle is in weight bias mode there may not be enough weight on the parking brake axle, which could result in inadequate parking brake force.
Remedy: Dealers will replace the brake chambers, free of charge. Owner letters were mailed May 29, 2026. Owners may contact Volvo Trucks' customer service at 800-528-6586. Volvo Trucks' number for this recall is RVXX2601.
Exterior lighting › Lighting control module › Software
Volvo Trucks North America (Volvo Trucks) is recalling certain 2026 VNR (4) and 2024-2026 VNL (4) vehicles. The automatic high beams (AHB) may not switch to low beam headlights as intended.
Remedy: As an interim action, Volvo Trucks will update the vehicle software through an over-the-air (OTA) update to disable the AHB feature, free of charge. Owner letters were mailed June 1, 2026.
Equipment › Mechanical
Volvo Trucks North America (Volvo Trucks) is recalling certain 2024-2026 VNL (4) vehicles. The load lock clamps, located on the back of the cab, may loosen and cause the load lock bars to become unsecured.
Remedy: Dealers will replace the load lock clamps, free of charge. Owner notification letters were mailed December 18, 2025. Owners may contact Volvo Trucks' customer service at 800-528-6586.
Exterior lighting
Volvo Trucks North America (Volvo Trucks) is recalling certain 2026 New VN trucks. The roof center marker lights may fail to illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Remedy: Dealers will replace the center roof marker light, free of charge. Owner letters were mailed January 19, 2026. Owners may contact Volvo Trucks' customer service at 800-528-6586.
Exterior lighting › Lighting control module
Volvo Trucks North America (Volvo Trucks) is recalling certain 2025-2026 New VN trucks. When towing a trailer, the trailer lights may fail to illuminate due to an improperly manufactured body control module.
Remedy: Dealers will replace the trailer body input/output module, free of charge. Owner letters were mailed November 19, 2025. Owners may contact Volvo Trucks' customer service at 800-528-6586.
Latches/locks/linkages › Doors › Latch
Volvo Trucks North America (Volvo Trucks) is recalling certain 2026 New VN trucks. The door latch cable on the interior door handle may be incorrectly installed, preventing the door from opening.
Remedy: Dealers will replace the door latch cable and pivot clip, free of charge. Owner notification letters were mailed November 11, 2025. Owners may contact Volvo Trucks' customer service at 800-528-6586.
Steering
Volvo Trucks North America (Volvo Trucks) is recalling certain 2025-2026 Volvo New VN trucks. The dynamic steering and oversteer guidance feature may malfunction and cause a loss of steering control.
Remedy: The oversteer guidance feature will be disabled through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed August 22, 2025.
Interior lighting
Volvo Trucks North America (Volvo Trucks) is recalling certain 2023-2026 New VN trucks. The hazard switch back lighting may become inoperative. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Controls and Displays."
Remedy: Dealers will update the vehicle master control unit (VMCU) software, free of charge. Owner notification letters were mailed April 25, 2025. Owners may contact Volvo Trucks' customer service at 800-528-6586.
2025 Volvo VNL recalls (16)
Structure
Volvo Trucks North America (Volvo Trucks) is recalling certain 2025-2026 VNL (4) vehicles. The truck cabs may have loose or missing structural bolts.
Remedy: Dealers will inspect for missing structural bolts and install and/or tighten the bolts, as necessary, free of charge. Owner notification letters are expected to be mailed December 14, 2026.
Service brakes, electric › Software/programming
Volvo Trucks North America (Volvo Trucks) is recalling certain 2025-2027 VNL (4) and 2026-2027 VNR (4) vehicles equipped with a tanker application package. Inaccurate axle load calculations may cause reduced braking performance while transporting smoothbore tanker trailers.
Remedy: Dealers will install new software to disable the dynamic trailer braking calculations, free of charge. Owner notification letters are expected to be mailed November 27, 2026.
Service brakes, air › Antilock › Control unit/module
Volvo Trucks North America (Volvo Trucks) is recalling certain 2026-2027 VNR (4) and 2025-2027 VNL (4) vehicles. The rear brake modulators may have unprotected electrical connectors that can short circuit and lead to a loss of the anti-lock brake system (ABS) and electronic stability control (ESC).
Remedy: Dealers will inspect the rear brake modulator electrical connectors, install a protective cover, and replace the rear brake modulators, as necessary, free of charge. Owner notification letters were mailed June 8, 2026.
Exterior lighting › Turn signal
Volvo Trucks North America (Volvo Trucks) is recalling certain 2025-2027 VNL (4) and 2026-2027 VNR (4) vehicles. The vehicle turn signals may not function properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated…
Remedy: Dealers will update the turn signal indicator software, free of charge. Owner notification letters were mailed May 7, 2026. Owners may contact Volvo Trucks' customer service at 800-528-6586.
Show 12 more recalls
Electrical system › Instrument cluster/panel
Volvo Trucks North America (Volvo Trucks) is recalling certain 2025-2026 VNL (4) vehicles. The instrument panel may fail while driving. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Controls and Displays."
Remedy: Dealers will replace the instrument panel clusters, free of charge. Owner notification letters were mailed May 8, 2026. Owners may contact Volvo Trucks' customer service at 800-528-6586.
Service brakes, air › Supply › Hoses, lines/piping, and fittings
Volvo Trucks North America (Volvo Trucks) is recalling certain 2025-2026 VNL (4) vehicles. The service brake may take longer than expected to release. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 121, "Air Brake Systems."
Remedy: Dealers will install an additional brake valve and fittings to the service brake pneumatic plumbing, free of charge. Owner letters were mailed July 29, 2026.Owners may contact Volvo Trucks' customer service at…
Parking brake
Volvo Trucks North America (Volvo Trucks) is recalling certain 2024-2027 VNL (4) vehicles that do not include auxiliary parking brakes. If the vehicle is in weight bias mode there may not be enough weight on the parking brake axle, which could result in inadequate parking brake force.
Remedy: Dealers will replace the brake chambers, free of charge. Owner letters were mailed May 29, 2026. Owners may contact Volvo Trucks' customer service at 800-528-6586. Volvo Trucks' number for this recall is RVXX2601.
Exterior lighting › Lighting control module › Software
Volvo Trucks North America (Volvo Trucks) is recalling certain 2026 VNR (4) and 2024-2026 VNL (4) vehicles. The automatic high beams (AHB) may not switch to low beam headlights as intended.
Remedy: As an interim action, Volvo Trucks will update the vehicle software through an over-the-air (OTA) update to disable the AHB feature, free of charge. Owner letters were mailed June 1, 2026.
Equipment › Mechanical
Volvo Trucks North America (Volvo Trucks) is recalling certain 2024-2026 VNL (4) vehicles. The load lock clamps, located on the back of the cab, may loosen and cause the load lock bars to become unsecured.
Remedy: Dealers will replace the load lock clamps, free of charge. Owner notification letters were mailed December 18, 2025. Owners may contact Volvo Trucks' customer service at 800-528-6586.
Exterior lighting › Lighting control module
Volvo Trucks North America (Volvo Trucks) is recalling certain 2025-2026 New VN trucks. When towing a trailer, the trailer lights may fail to illuminate due to an improperly manufactured body control module.
Remedy: Dealers will replace the trailer body input/output module, free of charge. Owner letters were mailed November 19, 2025. Owners may contact Volvo Trucks' customer service at 800-528-6586.
Steering
Volvo Trucks North America (Volvo Trucks) is recalling certain 2025-2026 Volvo New VN trucks. The dynamic steering and oversteer guidance feature may malfunction and cause a loss of steering control.
Remedy: The oversteer guidance feature will be disabled through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed August 22, 2025.
Engine and engine cooling › Engine › Diesel
Volvo Trucks North America (Volvo Trucks) is recalling certain 2022-2025 Volvo VN and 2025 New VN trucks. The idler gear bracket fasteners may have been improperly tightened, allowing the idler gear to detach from the engine.
Remedy: Dealers will inspect and replace the turbo compound units as necessary, free of charge. Owner notification letters were mailed April 28, 2025. Owners may contact Volvo Trucks' customer service at 1-800-528-6586.
Interior lighting
Volvo Trucks North America (Volvo Trucks) is recalling certain 2023-2026 New VN trucks. The hazard switch back lighting may become inoperative. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Controls and Displays."
Remedy: Dealers will update the vehicle master control unit (VMCU) software, free of charge. Owner notification letters were mailed April 25, 2025. Owners may contact Volvo Trucks' customer service at 800-528-6586.
Service brakes, air › Controls › Proportioning relay valve
Volvo Trucks North America (Volvo Trucks) is recalling certain 2023-2025 New VN trucks. The brakes may take longer than expected to activate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems."
Remedy: Dealers will install a new pneumatic circuit, free of charge. Owner notification letters were mailed March 11, 2025. Owners may contact Volvo Trucks' customer service at 800-528-6586.
Electrical system › Software
Volvo Trucks North America (Volvo Trucks) is recalling one 2025 New VN truck. A software error in the instrument cluster may cause the anti-lock brake system (ABS) warning light not to illuminate. As such, this vehicle fails to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air Brake Systems."
Remedy: A dealer will reprogram the software, free of charge. Owners may contact Volvo Customer Service at 1-800-528-6586. Volvo's number for this recall is RVXX2410.
Steering › Gear box › Shaft sector
Volvo Trucks North America (Volvo Trucks) is recalling certain 2024-2025 VNL and VNR vehicles. The steering gear sector shaft may have been improperly heat-treated, which can cause the gear teeth to crack or fracture.
Remedy: Dealers will inspect the serial numbers, and replace the steering gears, as necessary, free of charge. Owner notification letters were mailed March 5, 2024.
2024 Volvo VNL recalls (12)
Parking brake
Volvo Trucks North America (Volvo Trucks) is recalling certain 2024-2027 VNL (4) vehicles that do not include auxiliary parking brakes. If the vehicle is in weight bias mode there may not be enough weight on the parking brake axle, which could result in inadequate parking brake force.
Remedy: Dealers will replace the brake chambers, free of charge. Owner letters were mailed May 29, 2026. Owners may contact Volvo Trucks' customer service at 800-528-6586. Volvo Trucks' number for this recall is RVXX2601.
Exterior lighting › Lighting control module › Software
Volvo Trucks North America (Volvo Trucks) is recalling certain 2026 VNR (4) and 2024-2026 VNL (4) vehicles. The automatic high beams (AHB) may not switch to low beam headlights as intended.
Remedy: As an interim action, Volvo Trucks will update the vehicle software through an over-the-air (OTA) update to disable the AHB feature, free of charge. Owner letters were mailed June 1, 2026.
Equipment › Mechanical
Volvo Trucks North America (Volvo Trucks) is recalling certain 2024-2026 VNL (4) vehicles. The load lock clamps, located on the back of the cab, may loosen and cause the load lock bars to become unsecured.
Remedy: Dealers will replace the load lock clamps, free of charge. Owner notification letters were mailed December 18, 2025. Owners may contact Volvo Trucks' customer service at 800-528-6586.
Interior lighting
Volvo Trucks North America (Volvo Trucks) is recalling certain 2023-2026 New VN trucks. The hazard switch back lighting may become inoperative. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Controls and Displays."
Remedy: Dealers will update the vehicle master control unit (VMCU) software, free of charge. Owner notification letters were mailed April 25, 2025. Owners may contact Volvo Trucks' customer service at 800-528-6586.
Show 8 more recalls
Service brakes, air › Controls › Proportioning relay valve
Volvo Trucks North America (Volvo Trucks) is recalling certain 2023-2025 New VN trucks. The brakes may take longer than expected to activate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems."
Remedy: Dealers will install a new pneumatic circuit, free of charge. Owner notification letters were mailed March 11, 2025. Owners may contact Volvo Trucks' customer service at 800-528-6586.
Steering › Gear box › Shaft sector
Volvo Trucks North America (Volvo Trucks) is recalling certain 2024-2025 VNL and VNR vehicles. The steering gear sector shaft may have been improperly heat-treated, which can cause the gear teeth to crack or fracture.
Remedy: Dealers will inspect the serial numbers, and replace the steering gears, as necessary, free of charge. Owner notification letters were mailed March 5, 2024.
Steering › Linkages › Knuckle › Spindle › Arm
Volvo Trucks North America (Volvo Trucks) is recalling one 2024 VNL truck. The bearing journals may not be fully seated in the steering knuckle assembly, preventing the proper installation of the wheel end hub assembly.
Remedy: Hendrickson will inspect and replace the steering knuckle assembly as necessary, free of charge. The owner notification letter was mailed February 2, 2024.
Electronic stability control (ESC)
Volvo Trucks North America (Volvo Trucks) is recalling certain 2024 Volvo VNL and VNR trucks. A software programming error may cause the electronic stability control (ESC) to be inoperative.
Remedy: Dealers will reprogram the control unit software, free of charge. Owner notification letters are expected to be mailed December 3, 2023. Owners may contact Volvo Trucks' customer service at 1-800-528-6586.
Steering
Volvo Trucks North America (Volvo Trucks) is recalling certain 2024 VNL, VHD, and VNR trucks. The fastener that connects two steering components, the pitman arm and draglink, may be loose, which can cause the connection to fail and result in a loss of steering control.
Remedy: Dealers will inspect and tighten the castle nuts and install new cotter pins, free of charge. Owner notification letters are expected to be mailed December 4, 2023.
Visibility › Windshield wiper/washer › Motor
Volvo Trucks North America (Volvo Trucks) is recalling certain 2022-2024 VNR, VNL, VHD, and VAH trucks. The windshield wiper motor gears may wear prematurely, causing the motor to fail.
Remedy: Dealers will replace the windshield wiper motor assembly, free of charge. Owner notification letters were mailed November 1, 2023. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
Electrical system › Wiring
Volvo Trucks North America (Volvo Truck) is recalling certain 2022-2024 VNL and VHD vehicles equipped with RollTek driver seats. A missing circuit will prevent the side air bag from deploying during a crash.
Remedy: Dealers will connect a jumper harness between the seat and main cab harness, free of charge. Owner notification letters are expected to be mailed August 4, 2023.
Wheels › Hubcap/cover
Volvo Trucks North America (Volvo Trucks) is recalling certain 2024 VNR, VNL, and VHD vehicles. The hub covers do not properly fit on the hub and can detach from the vehicle.
Remedy: Dealers will remove the hub covers, free of charge. Owner notification letters were mailed March 31, 2023. Owners may contact Volvo Trucks' customer service at 1-800-528-6586.
2023 Volvo VNL recalls (5)
Interior lighting
Volvo Trucks North America (Volvo Trucks) is recalling certain 2023-2026 New VN trucks. The hazard switch back lighting may become inoperative. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Controls and Displays."
Remedy: Dealers will update the vehicle master control unit (VMCU) software, free of charge. Owner notification letters were mailed April 25, 2025. Owners may contact Volvo Trucks' customer service at 800-528-6586.
Service brakes, air › Controls › Proportioning relay valve
Volvo Trucks North America (Volvo Trucks) is recalling certain 2023-2025 New VN trucks. The brakes may take longer than expected to activate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems."
Remedy: Dealers will install a new pneumatic circuit, free of charge. Owner notification letters were mailed March 11, 2025. Owners may contact Volvo Trucks' customer service at 800-528-6586.
Visibility › Windshield wiper/washer › Motor
Volvo Trucks North America (Volvo Trucks) is recalling certain 2022-2024 VNR, VNL, VHD, and VAH trucks. The windshield wiper motor gears may wear prematurely, causing the motor to fail.
Remedy: Dealers will replace the windshield wiper motor assembly, free of charge. Owner notification letters were mailed November 1, 2023. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
Electrical system › Wiring
Volvo Trucks North America (Volvo Truck) is recalling certain 2022-2024 VNL and VHD vehicles equipped with RollTek driver seats. A missing circuit will prevent the side air bag from deploying during a crash.
Remedy: Dealers will connect a jumper harness between the seat and main cab harness, free of charge. Owner notification letters are expected to be mailed August 4, 2023.
Show 1 more recall
Service brakes, air › Critical fasteners
Volvo Trucks North America (Volvo Trucks) is recalling certain 2022-2023 VNL vehicles. The air tank bracket fasteners were excessively tightened and may have broken.
Remedy: Dealers will replace the fasteners, free of charge. Owner notification letters were mailed December 16, 2022. Owners may contact Volvo Trucks' customer service at 1-800-528-6586.
2022 Volvo VNL recalls (7)
Visibility › Windshield wiper/washer › Motor
Volvo Trucks North America (Volvo Trucks) is recalling certain 2022-2024 VNR, VNL, VHD, and VAH trucks. The windshield wiper motor gears may wear prematurely, causing the motor to fail.
Remedy: Dealers will replace the windshield wiper motor assembly, free of charge. Owner notification letters were mailed November 1, 2023. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
Electrical system › Wiring
Volvo Trucks North America (Volvo Truck) is recalling certain 2022-2024 VNL and VHD vehicles equipped with RollTek driver seats. A missing circuit will prevent the side air bag from deploying during a crash.
Remedy: Dealers will connect a jumper harness between the seat and main cab harness, free of charge. Owner notification letters are expected to be mailed August 4, 2023.
Service brakes, air › Critical fasteners
Volvo Trucks North America (Volvo Trucks) is recalling certain 2022-2023 VNL vehicles. The air tank bracket fasteners were excessively tightened and may have broken.
Remedy: Dealers will replace the fasteners, free of charge. Owner notification letters were mailed December 16, 2022. Owners may contact Volvo Trucks' customer service at 1-800-528-6586.
Power train › Automatic transmission
Volvo Trucks North America (Volvo Trucks) is recalling certain 2022 VNL vehicles. The electronic control unit software may allow the transmission to shift into neutral unexpectedly.
Remedy: Dealers will reprogram the electronic control module, free of charge. Owner notification letters were mailed on November 01, 2021. Owners may contact Volvo Trucks' customer service at 1-800-528-6586.
Show 3 more recalls
Wheels › Hub
Volvo Trucks North America (Volvo Trucks) is recalling certain 2021-2022 VAH, VDH, VNL, AND VNR vehicles. The hubcap compression spring can cause the hubcap to separate.
Remedy: Dealers will remove the hubcap, free of charge. Owner notification letters were mailed on July 12, 2021. Owners may contact Volvo Trucks customer service at 1-800-528-6586. Mack's number for this recall is RVXX 2102.
Wheels › Rim
Volvo Trucks North America (Volvo Trucks) is recalling certain 2022 VNL vehicles equipped with Alcoa Mirror Polish Wheels, part number ULT 391, and wheel size 22.5 x 8.25. Under certain circumstances, these wheels may not be able to support the load, which can cause the wheels to bend or break while in use.
Remedy: The affected vehicles have been contained by the manufacturer, and therefore no owners will be notified. Dealers will replace the wheels, free of charge. The recall began January 29, 2021.
Engine
Volvo Trucks North America (Volvo Trucks) is recalling certain 2022 VNL vehicles equipped with Cummins X15 diesel engines. The capscrews that attach the flywheel to the crankshaft may have been improperly torqued, allowing the flywheel to detach.
Remedy: The affected vehicles are still within the manufacturer's control. The Volvo Trucks manufacturing facility will properly torque the capscrews and inspect for possible damage and, if necessary, repair any damage found,…
2021 Volvo VNL recalls (7)
Steering › Hydraulic power assist › Pump
Volvo Trucks North America (Volvo Trucks) is recalling certain 2021 VNL vehicles. A machining defect may cause pressure to build in the power steering pump, breaking the shaft seal and resulting in a loss of power steering assist.
Remedy: Dealers will replace the power steering pumps, free of charge. Owner notification letters were mailed on December 10, 2021. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
Wheels › Hub
Volvo Trucks North America (Volvo Trucks) is recalling certain 2021-2022 VAH, VDH, VNL, AND VNR vehicles. The hubcap compression spring can cause the hubcap to separate.
Remedy: Dealers will remove the hubcap, free of charge. Owner notification letters were mailed on July 12, 2021. Owners may contact Volvo Trucks customer service at 1-800-528-6586. Mack's number for this recall is RVXX 2102.
Service brakes, hydraulic › Critical fasteners
Volvo Trucks North America (Volvo Trucks) is recalling 2021 VNL, VNR, VAH, and VHD vehicles. The collets (internal jaws) for the brass fitting inserts used in the pneumatic pass-through plate may have been damaged during leak testing.
Remedy: Volvo Trucks will notify owners, and dealers will inspect the air brake line for proper engagement of the fitting in the pass-through plate, free of charge. The recall is expected to begin January 31, 2021.
Service brakes, air
Volvo Trucks North America (Volvo Trucks) is recalling certain 2020-2021 VAH, VHD, VNL and VNR vehicles. The die cast pedal plate may break at one of its attachment points, possibly resulting in the brake pedal dislodging.
Remedy: Volvo Trucks will notify owners, and dealers will inspect and replace the pedal plates if required, free of charge. The recall began October 7, 2020. Owners may contact Volvo Trucks customer service at 1-800-458-1552.
Show 3 more recalls
Steering
Volvo Trucks North America (Volvo Trucks) is recalling certain 2021 VNL, VHD, and VNR vehicles. The king pin nut may not have been installed or properly tightened during axle assembly.
Remedy: Volvo Trucks will notify owners, and dealers will inspect the vehicle to make sure that the king pin nut is installed and that it properly tightened, free of charge. The recall began September 28, 2020.
Equipment › Other › Labels
Volvo Trucks North America (Volvo) is recalling certain 2018-2021 VNL and VNR buses. The Gross Axle Weight Rating (GAWR) for the rear drive axles stated on the Federal Certification Label exceeds the rating of the wheel hubs. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Remedy: Volvo will notify owners and send corrected replacement labels, free of charge. The recall began August 18, 2020. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX2002.
Steering
Volvo Trucks North America (Volvo Trucks) is recalling certain 2020-2021 VNL and VNR trucks. The steering gear fasteners may have not been properly tightened.
Remedy: Volvo Trucks will notify owners, and dealers will tighten the steering gear fasteners to specification, free of charge. The recall began May 20, 2020. Owners may contact Volvo Trucks customer service at 800-528-6586.
2020 Volvo VNL recalls (9)
Steering
Volvo Trucks North America (Volvo Trucks) is recalling one 2020 VNL truck. The steering gear assembly may have been assembled incorrectly with fewer recirculating balls than are required, which may result in a loss of steering control.
Remedy: A dealer will inspect and replace the defective gears as necessary, free of charge. An owner notification letter was mailed February 7, 2024. The owner may contact Volvo Trucks customer service at 1-800-528-6586.
Structure › Body
Volvo Trucks North America (Volvo Trucks) is recalling certain 2020 VNL vehicles. The window hinge and mounting hardware are insufficient to hold the window in place if the truck is driven with the sleeper bunk windows open.
Remedy: Volvo Trucks has notified owners, and dealers will replace the window hinge, free of charge. The recall began October 29, 2020. Owners may contact Volvo Trucks customer service at 1-800-458-1552.
Service brakes, air
Volvo Trucks North America (Volvo Trucks) is recalling certain 2020-2021 VAH, VHD, VNL and VNR vehicles. The die cast pedal plate may break at one of its attachment points, possibly resulting in the brake pedal dislodging.
Remedy: Volvo Trucks will notify owners, and dealers will inspect and replace the pedal plates if required, free of charge. The recall began October 7, 2020. Owners may contact Volvo Trucks customer service at 1-800-458-1552.
Equipment › Other › Labels
Volvo Trucks North America (Volvo) is recalling certain 2018-2021 VNL and VNR buses. The Gross Axle Weight Rating (GAWR) for the rear drive axles stated on the Federal Certification Label exceeds the rating of the wheel hubs. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Remedy: Volvo will notify owners and send corrected replacement labels, free of charge. The recall began August 18, 2020. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX2002.
Show 5 more recalls
Steering
Volvo Trucks North America (Volvo Trucks) is recalling certain 2020-2021 VNL and VNR trucks. The steering gear fasteners may have not been properly tightened.
Remedy: Volvo Trucks will notify owners, and dealers will tighten the steering gear fasteners to specification, free of charge. The recall began May 20, 2020. Owners may contact Volvo Trucks customer service at 800-528-6586.
Steering
Volvo Trucks North America (Volvo Trucks) is recalling certain 2020 VNL and VNR vehicles equipped with HD94 Sheppard gear variants. The steering gear mounting fasteners may be insufficiently tightened, allowing the steering gear to loosen.
Remedy: Volvo Trucks will notify owners, and dealers will inspect and re-torque the steering gear to a higher value. Additionally, the steering gear will be replaced, as necessary, free of charge.
Power train › Automatic transmission
Volvo Trucks North America (Volvo Trucks) is recalling certain 2019-2020 VAH, VHD, VNL, and VNR vehicles. The t-bolt clasps on the transmission auxiliary air tank straps may have been over-tightened, resulting in potential deformation to the strap where the t-bolt is anchored.
Remedy: Volvo Trucks will notify owners, and dealers will inspect and replace the air tank strap, if necessary, free of charge. The recall began August 7, 2019.
Electrical system › Wiring › Fuses and circuit breakers
Volvo Trucks North America (Volvo Trucks) is recalling certain 2018-2020 VAH, VHD, VNL, and VNR vehicles. The fuse in the transmission circuit may blow, preventing the transmission from shifting.
Remedy: Volvo Trucks will notify owners, and dealers will inspect and replace the fuse, if necessary, free of charge. The recall began August 7, 2019. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
Structure › Body
Volvo Trucks North America (Volvo Trucks) is recalling certain 2018-2020 VNL and VNX vehicles configured as 740 and 760 sleeper models. The sleeper bunk window may detach and fall from the vehicle.
Remedy: Volvo Trucks has notified owners, and dealers will replace the window hinge, free of charge. Owners were notified of the recall on April 8, 2019 and will be sent a second notice when the remedy parts are available.
2019 Volvo VNL recalls (8)
Equipment › Other › Labels
Volvo Trucks North America (Volvo) is recalling certain 2018-2021 VNL and VNR buses. The Gross Axle Weight Rating (GAWR) for the rear drive axles stated on the Federal Certification Label exceeds the rating of the wheel hubs. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Remedy: Volvo will notify owners and send corrected replacement labels, free of charge. The recall began August 18, 2020. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX2002.
Power train › Automatic transmission
Volvo Trucks North America (Volvo Trucks) is recalling certain 2019-2020 VAH, VHD, VNL, and VNR vehicles. The t-bolt clasps on the transmission auxiliary air tank straps may have been over-tightened, resulting in potential deformation to the strap where the t-bolt is anchored.
Remedy: Volvo Trucks will notify owners, and dealers will inspect and replace the air tank strap, if necessary, free of charge. The recall began August 7, 2019.
Electrical system › Wiring › Fuses and circuit breakers
Volvo Trucks North America (Volvo Trucks) is recalling certain 2018-2020 VAH, VHD, VNL, and VNR vehicles. The fuse in the transmission circuit may blow, preventing the transmission from shifting.
Remedy: Volvo Trucks will notify owners, and dealers will inspect and replace the fuse, if necessary, free of charge. The recall began August 7, 2019. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
Structure › Body
Volvo Trucks North America (Volvo Trucks) is recalling certain 2018-2020 VNL and VNX vehicles configured as 740 and 760 sleeper models. The sleeper bunk window may detach and fall from the vehicle.
Remedy: Volvo Trucks has notified owners, and dealers will replace the window hinge, free of charge. Owners were notified of the recall on April 8, 2019 and will be sent a second notice when the remedy parts are available.
Show 4 more recalls
Power train › Clutch assembly
Volvo Trucks North America (Volvo) is recalling certain 2018-2019 Volvo VNL vehicles equipped with an automated manual transmission. An internal component in the clutch assembly may fail, possibly resulting in unintended vehicle movement.
Remedy: Volvo has notified owners and dealers will update the Transmission Control Module software, free of charge. The recall began February 1, 2019. Owners can contact Volvo customer service at 1-800-528-6586.
Tires
Volvo Trucks North America (Volvo) is recalling certain 2019 Volvo VNL and VHD trucks, equipped with Bridgestone M854 tires with date codes 2418-2518, Bridgestone M860A tires with date code 2518, and Bridgestone M864 tires with date codes 2318-2418, all of size 425/65R22.5.
Remedy: Volvo will notify owners, instructing them to take their vehicles to Bridgestone Tire or Volvo Truck service centers for inspection and replacement, as necessary, free of charge. The recall began December 19, 2018.
Engine and engine cooling › Engine › Diesel
Volvo Trucks North America (Volvo) is recalling certain 2016-2019 Volvo VNL trucks equipped with Cummins ISX15 diesel engines. In certain driving conditions, such as on a long down-hill grade, the fuel line may burst if the fuel pump cooling circuit screen becomes restricted.
Remedy: Cummins will notify owners, and dealers will replace the single screen filter banjo bolt will be replaced with a dual screen filter banjo bolt, free of charge. The recall began November 21, 2018.
Trailer hitches › Fifth wheel assembly
Volvo Trucks North America (Volvo) is recalling certain 2019 Volvo VNL and VNR trucks equipped with Jost fifth wheel couplings. The fifth wheel may have an outboard slider bracket that is too narrow, possibly allowing the trailer to separate from the tractor.
Remedy: Volvo will notify owners, and dealers will inspect the fifth wheel slider bracket, replacing it as necessary, free of charge. The recall began September 25, 2018.
2018 Volvo VNL recalls (5)
Equipment › Other › Labels
Volvo Trucks North America (Volvo) is recalling certain 2018-2021 VNL and VNR buses. The Gross Axle Weight Rating (GAWR) for the rear drive axles stated on the Federal Certification Label exceeds the rating of the wheel hubs. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Remedy: Volvo will notify owners and send corrected replacement labels, free of charge. The recall began August 18, 2020. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX2002.
Electrical system › Wiring › Fuses and circuit breakers
Volvo Trucks North America (Volvo Trucks) is recalling certain 2018-2020 VAH, VHD, VNL, and VNR vehicles. The fuse in the transmission circuit may blow, preventing the transmission from shifting.
Remedy: Volvo Trucks will notify owners, and dealers will inspect and replace the fuse, if necessary, free of charge. The recall began August 7, 2019. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
Structure › Body
Volvo Trucks North America (Volvo Trucks) is recalling certain 2018-2020 VNL and VNX vehicles configured as 740 and 760 sleeper models. The sleeper bunk window may detach and fall from the vehicle.
Remedy: Volvo Trucks has notified owners, and dealers will replace the window hinge, free of charge. Owners were notified of the recall on April 8, 2019 and will be sent a second notice when the remedy parts are available.
Power train › Clutch assembly
Volvo Trucks North America (Volvo) is recalling certain 2018-2019 Volvo VNL vehicles equipped with an automated manual transmission. An internal component in the clutch assembly may fail, possibly resulting in unintended vehicle movement.
Remedy: Volvo has notified owners and dealers will update the Transmission Control Module software, free of charge. The recall began February 1, 2019. Owners can contact Volvo customer service at 1-800-528-6586.
Show 1 more recall
Engine and engine cooling › Engine › Diesel
Volvo Trucks North America (Volvo) is recalling certain 2016-2019 Volvo VNL trucks equipped with Cummins ISX15 diesel engines. In certain driving conditions, such as on a long down-hill grade, the fuel line may burst if the fuel pump cooling circuit screen becomes restricted.
Remedy: Cummins will notify owners, and dealers will replace the single screen filter banjo bolt will be replaced with a dual screen filter banjo bolt, free of charge. The recall began November 21, 2018.
2017 Volvo VNL recalls (5)
Engine and engine cooling › Engine › Diesel
Volvo Trucks North America (Volvo) is recalling certain 2016-2019 Volvo VNL trucks equipped with Cummins ISX15 diesel engines. In certain driving conditions, such as on a long down-hill grade, the fuel line may burst if the fuel pump cooling circuit screen becomes restricted.
Remedy: Cummins will notify owners, and dealers will replace the single screen filter banjo bolt will be replaced with a dual screen filter banjo bolt, free of charge. The recall began November 21, 2018.
Suspension › Front › Hub
Volvo Trucks North America (Volvo) is recalling certain 2017 Volvo VHD, VNL, and VNM trucks manufactured February 19, 2016, to June 21, 2016. The affected vehicles were built with front wheel hubs that cannot support the gross axle weight rating of the front axle.
Remedy: Volvo will notify owners, and dealers will replace the hub assemblies, free of charge. The recall began on February 16, 2017. Owners may contact Volvo customer service at 1-800-528-6586.
Service brakes, air
Volvo Trucks North America (Volvo) is recalling certain model year 2013-2017 VNL and VNM trucks and certain model year 2017 VNX trucks. In the affected vehicles, incorrect software for controlling the electronic air dryer may result in oil and water contaminating the brake system.
Remedy: Volvo will notify owners, and dealers will reprogram the vehicle control module and replace the air dryer filter, free of charge. The recall began on February 16, 2017.
Engine and engine cooling › Engine › Diesel
Volvo Trucks North America (Trucks) is recalling certain model year 2017 VNL trucks manufactured March 15, 2016, to April 20, 2016, equipped with a Cummins ISX12 or ISX15 engine using certain engine control modules (ECM).
Remedy: Cummins will notify owners, and Cummins dealers will replace the existing ECM with a new ECM, free of charge. The recall began on July 11, 2016.
Show 1 more recall
Steering
Volvo Trucks North America (Volvo) is recalling certain model year 2016-2017 VNL, VNX, and VNM trucks manufactured from May 11, 2015, through April 18, 2016. The trucks may have been manufactured without a roll pin on the steering shafts.
Remedy: Volvo is strongly recommending that the affected vehicles not be driven until the interim remedy is applied. An interim notice was sent to Volvo owners on March 16, 2016, and an interim repair is available now.
2016 Volvo VNL recalls (6)
Engine and engine cooling › Engine › Diesel
Volvo Trucks North America (Volvo) is recalling certain 2016-2019 Volvo VNL trucks equipped with Cummins ISX15 diesel engines. In certain driving conditions, such as on a long down-hill grade, the fuel line may burst if the fuel pump cooling circuit screen becomes restricted.
Remedy: Cummins will notify owners, and dealers will replace the single screen filter banjo bolt will be replaced with a dual screen filter banjo bolt, free of charge. The recall began November 21, 2018.
Steering › Linkages › Tie rod assembly
Volvo Trucks North America (Volvo) is recalling certain 2016 Volvo VNL and VNM trucks equipped with certain Dana Spicer D-Series and E-Series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.
Remedy: Volvo will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary.
Service brakes, air
Volvo Trucks North America (Volvo) is recalling certain model year 2013-2017 VNL and VNM trucks and certain model year 2017 VNX trucks. In the affected vehicles, incorrect software for controlling the electronic air dryer may result in oil and water contaminating the brake system.
Remedy: Volvo will notify owners, and dealers will reprogram the vehicle control module and replace the air dryer filter, free of charge. The recall began on February 16, 2017.
Suspension › Front › Control arm › Lower ball joint
Volvo Trucks North America (Volvo) is recalling certain model year 2009-2010 VT trucks manufactured from April 9, 2008, through September 24, 2009, and certain 2016 model VNL and VNM trucks manufactured from January 2, 2015, through to November 6, 2015.
Remedy: Volvo will notify owners, and dealers will replace the drag links, free of charge. The recall began on April 21, 2016. Owners may contact Volvo customer service at 1-800-528-6586.
Show 2 more recalls
Steering
Volvo Trucks North America (Volvo) is recalling certain model year 2016-2017 VNL, VNX, and VNM trucks manufactured from May 11, 2015, through April 18, 2016. The trucks may have been manufactured without a roll pin on the steering shafts.
Remedy: Volvo is strongly recommending that the affected vehicles not be driven until the interim remedy is applied. An interim notice was sent to Volvo owners on March 16, 2016, and an interim repair is available now.
Parking brake › Driveline › Hydraulic › Actuator
Volvo Trucks North America (Volvo) is recalling certain model year 2015 and 2016 VNX and VNL trucks manufactured from May 20, 2014, through March 6, 2015, equipped with certain Haldex Life Seal Type 30/30 Long Stroke Air Brake Actuators manufactured January 9, 2014, to October 28, 2014.
Remedy: Volvo will notify owners, and dealers will inspect the brake actuator and replace, as necessary, free of charge. The recall began March 20, 2015. Owners may contact Volvo customer service at 1-800-528-6586.
2015 Volvo VNL recalls (9)
Suspension › Front
Volvo Trucks North America (Volvo Trucks) is recalling certain 2015 VNL vehicles equipped with Meritor FF967 Non-Drive Front Steer axles. The axles missed the heat treating operation during manufacturing, reducing their strength and possibly causing the axle beams to fracture.
Remedy: Volvo Trucks will notify the affected vehicle owners, and dealers will inspect and replace the axles as necessary, free of charge. The recall began September 27, 2019.
Service brakes, air
Volvo Trucks North America (Volvo) is recalling certain model year 2013-2017 VNL and VNM trucks and certain model year 2017 VNX trucks. In the affected vehicles, incorrect software for controlling the electronic air dryer may result in oil and water contaminating the brake system.
Remedy: Volvo will notify owners, and dealers will reprogram the vehicle control module and replace the air dryer filter, free of charge. The recall began on February 16, 2017.
Service brakes
Volvo Trucks North America (Volvo) is recalling certain model year 2012-2015 VNL and VNM trucks manufactured May 31, 2011, to December 1, 2014. In the affected trucks, the trailer hand brake handle may not to return to the off position due to being restricted by the cut out in the trim panel.
Remedy: Volvo will notify owners, and dealers will inspect the trim panel slot and make it longer, as necessary, free of charge. The recall began on October 19, 2015. Owners may contact Volvo customer service at 1-800-258-6586.
Parking brake › Driveline › Hydraulic › Actuator
Volvo Trucks North America (Volvo) is recalling certain model year 2015 and 2016 VNX and VNL trucks manufactured from May 20, 2014, through March 6, 2015, equipped with certain Haldex Life Seal Type 30/30 Long Stroke Air Brake Actuators manufactured January 9, 2014, to October 28, 2014.
Remedy: Volvo will notify owners, and dealers will inspect the brake actuator and replace, as necessary, free of charge. The recall began March 20, 2015. Owners may contact Volvo customer service at 1-800-528-6586.
Show 5 more recalls
Power train › Automatic transmission
Volvo Trucks North America (Volvo) is recalling certain model year 2012, 2014-2015 VHD, 2012-2015 VNL, and 2014-2015 VNM trucks manufactured June 16, 2011, to August 18, 2014, and equipped with the Eco-Roll option. The affected trucks may fail to re-engage the vehicle drivetrain after using the Eco-Roll feature.
Remedy: Volvo has notified owners, and dealers will update the Eco-Roll software, free of charge. The recall began on December 10, 2014. Owners may contact Volvo customer service at 1-800-528-6586.
Electrical system › Software
Volvo Trucks North America (Volvo) is recalling certain model year 2015 VNL and VNX trucks manufactured January 7, 2014, to June 5, 2014, and equipped with a D16 engine. Due to the engine control unit having an incorrect parameter setting in the software, the engine may stall.
Remedy: Volvo will notify owners, and dealers will update the engine control unit software, free of charge. The recall began in October 2014. Owners may contact Volvo customer service at 1-800-528-6586.
Service brakes, air › Disc › Caliper
Volvo Trucks North America (Volvo) is recalling certain model year 2014-2015 VAH, VNL, and VNM trucks manufactured March 4, 2013, to April 28, 2014. Due to the bolts holding the disc brake caliper to the backing plate not being tightened to the specified torque, the disc brake caliper may detach from the backing plate.
Remedy: Volvo will notify owners, and dealers will inspect and tighten the bolts to specification, as necessary, free of charge. The recall began October 10, 2014. Owners may contact Volvo customer service at 1-800-528-6586.
Forward collision avoidance › Adaptive cruise control
Volvo Trucks of North America (Volvo) is recalling certain model year 2011-2015 VNL and 2014-2015 VNM trucks manufactured November 17, 2010, through February 5, 2014, and equipped with enhanced cruise control and without side fairings.
Remedy: Volvo will notify owners, and dealers will update the control unit software, free of charge. The recall began on August 12, 2014. Owners may contact Volvo customer service at 1-800-528-6586.
Engine and engine cooling › Engine
Volvo Trucks North America (Volvo) is recalling certain model year 2013-2015 VNL trucks, and 2013-2014 VNM trucks equipped with certain Cummins Westport Model ISL G and ISX12 G engines.
Remedy: Cummins Inc. and Cummins Wesport Inc. will notify owners, and authorized Cummins service facilities will upload a new ECM calibration, free of charge. The recall began on April 12, 2014.
2014 Volvo VNL recalls (12)
Service brakes, air
Volvo Trucks North America (Volvo) is recalling certain model year 2013-2017 VNL and VNM trucks and certain model year 2017 VNX trucks. In the affected vehicles, incorrect software for controlling the electronic air dryer may result in oil and water contaminating the brake system.
Remedy: Volvo will notify owners, and dealers will reprogram the vehicle control module and replace the air dryer filter, free of charge. The recall began on February 16, 2017.
Electrical system
Volvo Trucks North America (Volvo) is recalling certain model year 2012-2014 Volvo VNL trucks manufactured December 1, 2011, to September 1, 2013, equipped with certain Electric Auxiliary Power Units (APU), part number BA600, manufactured by Idle Free Systems (IFS).
Remedy: Volvo will notify owners and IFS dealers will inspect the APU for damage and, where needed, install a welded gusset upgrade kit to strengthen the APU C-channels. All units will receive stronger clamping brackets.
Service brakes
Volvo Trucks North America (Volvo) is recalling certain model year 2012-2015 VNL and VNM trucks manufactured May 31, 2011, to December 1, 2014. In the affected trucks, the trailer hand brake handle may not to return to the off position due to being restricted by the cut out in the trim panel.
Remedy: Volvo will notify owners, and dealers will inspect the trim panel slot and make it longer, as necessary, free of charge. The recall began on October 19, 2015. Owners may contact Volvo customer service at 1-800-258-6586.
Power train › Automatic transmission
Volvo Trucks North America (Volvo) is recalling certain model year 2012, 2014-2015 VHD, 2012-2015 VNL, and 2014-2015 VNM trucks manufactured June 16, 2011, to August 18, 2014, and equipped with the Eco-Roll option. The affected trucks may fail to re-engage the vehicle drivetrain after using the Eco-Roll feature.
Remedy: Volvo has notified owners, and dealers will update the Eco-Roll software, free of charge. The recall began on December 10, 2014. Owners may contact Volvo customer service at 1-800-528-6586.
Show 8 more recalls
Tires
Volvo Trucks North America (Volvo) is recalling certain model year 2011-2014 VAH and VNL trucks manufactured May 12, 2010, to October 31, 2014. The affected vehicles may experience premature tire failure during certain operating conditions such as high speeds, heavy load, and high road temperature.
Remedy: Volvo will notify owners, and dealers will replace the tires and set the road speed limiter, free of charge. The recall began on January 16, 2015. Owners may contact Volvo customer service at 1-800-528-6586.
Service brakes, air › Disc › Caliper
Volvo Trucks North America (Volvo) is recalling certain model year 2014-2015 VAH, VNL, and VNM trucks manufactured March 4, 2013, to April 28, 2014. Due to the bolts holding the disc brake caliper to the backing plate not being tightened to the specified torque, the disc brake caliper may detach from the backing plate.
Remedy: Volvo will notify owners, and dealers will inspect and tighten the bolts to specification, as necessary, free of charge. The recall began October 10, 2014. Owners may contact Volvo customer service at 1-800-528-6586.
Forward collision avoidance › Adaptive cruise control
Volvo Trucks of North America (Volvo) is recalling certain model year 2011-2015 VNL and 2014-2015 VNM trucks manufactured November 17, 2010, through February 5, 2014, and equipped with enhanced cruise control and without side fairings.
Remedy: Volvo will notify owners, and dealers will update the control unit software, free of charge. The recall began on August 12, 2014. Owners may contact Volvo customer service at 1-800-528-6586.
Engine and engine cooling › Engine
Volvo Trucks North America (Volvo) is recalling certain model year 2013-2015 VNL trucks, and 2013-2014 VNM trucks equipped with certain Cummins Westport Model ISL G and ISX12 G engines.
Remedy: Cummins Inc. and Cummins Wesport Inc. will notify owners, and authorized Cummins service facilities will upload a new ECM calibration, free of charge. The recall began on April 12, 2014.
Seat belts
Volvo Trucks North America (Volvo) is recalling certain model year 2014 VAH, VHD, VNL, and VNM trucks manufactured August 12, 2013, through November 14, 2013; and equipped with IMMI-brand L9 seat belt buckles.
Remedy: Volvo will notify owners, and dealers will inspect and replace the seat belt buckle, as necessary, free of charge. The recall began on January 27, 2014. Owners may contact Volvo at 1-336-393-2000.
Power train › Driveline › Driveshaft
Volvo Trucks North America is recalling certain model year 2013-2014 VNL vehicles manufactured April 2, 2012, through May 3, 2013; and equipped with a Meritor RPL-20 driveline transmission. The driveshaft is too weak for this application and may fail.
Remedy: Volvo will notify owners, and dealers will replace the driveshaft, free of charge. The recall began on October 9, 2013. Owners may contact Volvo at 1-336-393-2000. Volvo's recall number is RVXX1305.
Power train › Clutch assembly
Volvo Trucks North America (Volvo) is recalling certain model year 2007-2014 VAH, VHD, VNL, VNM, and VT models. The affected vehicles were built without a redundant clutch disengagement switch.
Remedy: Volvo Trucks will notify owners and dealers will inspect and repair the vehicles if necessary. The recall began on August 26, 2013. Volvo's recall number is RVXX1303. Owners may contact Volvo at 1-336-393-2000.
Electrical system › 12V/24V/48V battery › Cables
Volvo is recalling certain model year 2012-2014 VHD, VNL, and VNM trucks, manufactured from April 18, 2011, through March 14, 2013, and equipped with a horizontally mounted remote battery disconnect switch. The remote battery disconnect switch was manufactured with incorrect hardware allowing the cables to loosen.
Remedy: Volvo will send owners an interim letter and dealers will replace and relocate the remote battery disconnect switch. The recall began on May 7, 2013.
2013 Volvo VNL recalls (14)
Service brakes, air
Volvo Trucks North America (Volvo) is recalling certain model year 2013-2017 VNL and VNM trucks and certain model year 2017 VNX trucks. In the affected vehicles, incorrect software for controlling the electronic air dryer may result in oil and water contaminating the brake system.
Remedy: Volvo will notify owners, and dealers will reprogram the vehicle control module and replace the air dryer filter, free of charge. The recall began on February 16, 2017.
Suspension › Front
Volvo Trucks North America, (Volvo) is recalling certain model year 2013 VNM and VNL trucks manufactured April 16, 2012, to May 4, 2012. These vehicles are equipped with certain Meritor FF967 non-drive front steer axles that may have been incorrectly heat treated.
Remedy: Volvo will notify owners, and dealers will inspect the axles for specific heat code serial numbers. The affected axles will be replaced, free of charge. The recall began on August 1, 2016.
Trailer hitches › Fifth wheel assembly
Volvo Trucks North America (Volvo) is recalling certain model year 2011-2013 VNL and VNM trucks manufactured June 21, 2010, to December 14, 2012. The affected trucks are equipped with Fontaine Ultra LT Fifth Wheel connectors, which, due to cumulative damage to the fifth wheel and its locking mechanism, have a locking mechanism…
Remedy: Volvo will notify owners, and Fontaine dealers will replace the fifth wheel with an Ultra NT model fifth wheel, free of charge. The recall began on November 23, 2015.
Electrical system
Volvo Trucks North America (Volvo) is recalling certain model year 2012-2014 Volvo VNL trucks manufactured December 1, 2011, to September 1, 2013, equipped with certain Electric Auxiliary Power Units (APU), part number BA600, manufactured by Idle Free Systems (IFS).
Remedy: Volvo will notify owners and IFS dealers will inspect the APU for damage and, where needed, install a welded gusset upgrade kit to strengthen the APU C-channels. All units will receive stronger clamping brackets.
Show 10 more recalls
Service brakes
Volvo Trucks North America (Volvo) is recalling certain model year 2012-2015 VNL and VNM trucks manufactured May 31, 2011, to December 1, 2014. In the affected trucks, the trailer hand brake handle may not to return to the off position due to being restricted by the cut out in the trim panel.
Remedy: Volvo will notify owners, and dealers will inspect the trim panel slot and make it longer, as necessary, free of charge. The recall began on October 19, 2015. Owners may contact Volvo customer service at 1-800-258-6586.
Power train › Automatic transmission
Volvo Trucks North America (Volvo) is recalling certain model year 2012, 2014-2015 VHD, 2012-2015 VNL, and 2014-2015 VNM trucks manufactured June 16, 2011, to August 18, 2014, and equipped with the Eco-Roll option. The affected trucks may fail to re-engage the vehicle drivetrain after using the Eco-Roll feature.
Remedy: Volvo has notified owners, and dealers will update the Eco-Roll software, free of charge. The recall began on December 10, 2014. Owners may contact Volvo customer service at 1-800-528-6586.
Tires
Volvo Trucks North America (Volvo) is recalling certain model year 2011-2014 VAH and VNL trucks manufactured May 12, 2010, to October 31, 2014. The affected vehicles may experience premature tire failure during certain operating conditions such as high speeds, heavy load, and high road temperature.
Remedy: Volvo will notify owners, and dealers will replace the tires and set the road speed limiter, free of charge. The recall began on January 16, 2015. Owners may contact Volvo customer service at 1-800-528-6586.
Forward collision avoidance › Adaptive cruise control
Volvo Trucks of North America (Volvo) is recalling certain model year 2011-2015 VNL and 2014-2015 VNM trucks manufactured November 17, 2010, through February 5, 2014, and equipped with enhanced cruise control and without side fairings.
Remedy: Volvo will notify owners, and dealers will update the control unit software, free of charge. The recall began on August 12, 2014. Owners may contact Volvo customer service at 1-800-528-6586.
Engine and engine cooling › Engine
Volvo Trucks North America (Volvo) is recalling certain model year 2013-2015 VNL trucks, and 2013-2014 VNM trucks equipped with certain Cummins Westport Model ISL G and ISX12 G engines.
Remedy: Cummins Inc. and Cummins Wesport Inc. will notify owners, and authorized Cummins service facilities will upload a new ECM calibration, free of charge. The recall began on April 12, 2014.
Power train › Driveline › Driveshaft
Volvo Trucks North America is recalling certain model year 2013-2014 VNL vehicles manufactured April 2, 2012, through May 3, 2013; and equipped with a Meritor RPL-20 driveline transmission. The driveshaft is too weak for this application and may fail.
Remedy: Volvo will notify owners, and dealers will replace the driveshaft, free of charge. The recall began on October 9, 2013. Owners may contact Volvo at 1-336-393-2000. Volvo's recall number is RVXX1305.
Power train › Clutch assembly
Volvo Trucks North America (Volvo) is recalling certain model year 2007-2014 VAH, VHD, VNL, VNM, and VT models. The affected vehicles were built without a redundant clutch disengagement switch.
Remedy: Volvo Trucks will notify owners and dealers will inspect and repair the vehicles if necessary. The recall began on August 26, 2013. Volvo's recall number is RVXX1303. Owners may contact Volvo at 1-336-393-2000.
Parking brake › Conventional › Air
Volvo Trucks North America (Volvo) is recalling certain model year 2011-2013 VHD and VNL vehicles manufactured December 13, 2010, through July 17, 2012. These vehicles are equipped with an MGM Type 24 J-series piston parking brake chamber.
Remedy: Volvo will notify owners and the brake chambers will be replaced as needed, free of charge. The safety recall is expected to begin on, or before, June 17, 2013. Owners may contact Volvo at 1-336-393-2000.
Electrical system › 12V/24V/48V battery › Cables
Volvo is recalling certain model year 2012-2014 VHD, VNL, and VNM trucks, manufactured from April 18, 2011, through March 14, 2013, and equipped with a horizontally mounted remote battery disconnect switch. The remote battery disconnect switch was manufactured with incorrect hardware allowing the cables to loosen.
Remedy: Volvo will send owners an interim letter and dealers will replace and relocate the remote battery disconnect switch. The recall began on May 7, 2013.
Service brakes, air › Supply › Check valve
Volvo is recalling certain model year 2011-2012 vhd and model year 2011-2013 vnl and vnm vehicles, manufactured from December 2, 2010, through January 18, 2012, and equipped with bendix atr-6 traction relay valves. In extremely cold conditions, these bendix relay valves May potentially develop internal leakage.
Remedy: Volvo will notify owners, and provide a temporary repair until bendix develops a permanent remedy. A permanent remedy has been developed and notification to owners began on April 27, 2012.
2012 Volvo VNL recalls (14)
Trailer hitches › Fifth wheel assembly
Volvo Trucks North America (Volvo) is recalling certain model year 2011-2013 VNL and VNM trucks manufactured June 21, 2010, to December 14, 2012. The affected trucks are equipped with Fontaine Ultra LT Fifth Wheel connectors, which, due to cumulative damage to the fifth wheel and its locking mechanism, have a locking mechanism…
Remedy: Volvo will notify owners, and Fontaine dealers will replace the fifth wheel with an Ultra NT model fifth wheel, free of charge. The recall began on November 23, 2015.
Electrical system
Volvo Trucks North America (Volvo) is recalling certain model year 2012-2014 Volvo VNL trucks manufactured December 1, 2011, to September 1, 2013, equipped with certain Electric Auxiliary Power Units (APU), part number BA600, manufactured by Idle Free Systems (IFS).
Remedy: Volvo will notify owners and IFS dealers will inspect the APU for damage and, where needed, install a welded gusset upgrade kit to strengthen the APU C-channels. All units will receive stronger clamping brackets.
Service brakes
Volvo Trucks North America (Volvo) is recalling certain model year 2012-2015 VNL and VNM trucks manufactured May 31, 2011, to December 1, 2014. In the affected trucks, the trailer hand brake handle may not to return to the off position due to being restricted by the cut out in the trim panel.
Remedy: Volvo will notify owners, and dealers will inspect the trim panel slot and make it longer, as necessary, free of charge. The recall began on October 19, 2015. Owners may contact Volvo customer service at 1-800-258-6586.
Power train › Automatic transmission
Volvo Trucks North America (Volvo) is recalling certain model year 2012, 2014-2015 VHD, 2012-2015 VNL, and 2014-2015 VNM trucks manufactured June 16, 2011, to August 18, 2014, and equipped with the Eco-Roll option. The affected trucks may fail to re-engage the vehicle drivetrain after using the Eco-Roll feature.
Remedy: Volvo has notified owners, and dealers will update the Eco-Roll software, free of charge. The recall began on December 10, 2014. Owners may contact Volvo customer service at 1-800-528-6586.
Show 10 more recalls
Tires
Volvo Trucks North America (Volvo) is recalling certain model year 2011-2014 VAH and VNL trucks manufactured May 12, 2010, to October 31, 2014. The affected vehicles may experience premature tire failure during certain operating conditions such as high speeds, heavy load, and high road temperature.
Remedy: Volvo will notify owners, and dealers will replace the tires and set the road speed limiter, free of charge. The recall began on January 16, 2015. Owners may contact Volvo customer service at 1-800-528-6586.
Forward collision avoidance › Adaptive cruise control
Volvo Trucks of North America (Volvo) is recalling certain model year 2011-2015 VNL and 2014-2015 VNM trucks manufactured November 17, 2010, through February 5, 2014, and equipped with enhanced cruise control and without side fairings.
Remedy: Volvo will notify owners, and dealers will update the control unit software, free of charge. The recall began on August 12, 2014. Owners may contact Volvo customer service at 1-800-528-6586.
Visibility/wiper
Volvo Trucks North America (Volvo) is recalling certain model year 2011-2012 VAH, VHD, VNL, and VNM trucks manufactured February 1, 2010, through September 30, 2010 and June 1, 2011, through November 30, 2011. The windshield wiper motor may fail.
Remedy: Volvo will notify owners and dealers will replace the windshield wiper motor, free of charge. The recallbegan on December 6, 2013. Owners may contact Volvo at 1-336-393-2000. Volvo's recall number is RVXX1304.
Power train › Clutch assembly
Volvo Trucks North America (Volvo) is recalling certain model year 2007-2014 VAH, VHD, VNL, VNM, and VT models. The affected vehicles were built without a redundant clutch disengagement switch.
Remedy: Volvo Trucks will notify owners and dealers will inspect and repair the vehicles if necessary. The recall began on August 26, 2013. Volvo's recall number is RVXX1303. Owners may contact Volvo at 1-336-393-2000.
Parking brake › Conventional › Air
Volvo Trucks North America (Volvo) is recalling certain model year 2011-2013 VHD and VNL vehicles manufactured December 13, 2010, through July 17, 2012. These vehicles are equipped with an MGM Type 24 J-series piston parking brake chamber.
Remedy: Volvo will notify owners and the brake chambers will be replaced as needed, free of charge. The safety recall is expected to begin on, or before, June 17, 2013. Owners may contact Volvo at 1-336-393-2000.
Electrical system › 12V/24V/48V battery › Cables
Volvo is recalling certain model year 2012-2014 VHD, VNL, and VNM trucks, manufactured from April 18, 2011, through March 14, 2013, and equipped with a horizontally mounted remote battery disconnect switch. The remote battery disconnect switch was manufactured with incorrect hardware allowing the cables to loosen.
Remedy: Volvo will send owners an interim letter and dealers will replace and relocate the remote battery disconnect switch. The recall began on May 7, 2013.
Service brakes, air › Supply › Check valve
Volvo is recalling certain model year 2011-2012 vhd and model year 2011-2013 vnl and vnm vehicles, manufactured from December 2, 2010, through January 18, 2012, and equipped with bendix atr-6 traction relay valves. In extremely cold conditions, these bendix relay valves May potentially develop internal leakage.
Remedy: Volvo will notify owners, and provide a temporary repair until bendix develops a permanent remedy. A permanent remedy has been developed and notification to owners began on April 27, 2012.
Trailer hitches › Fifth wheel assembly
Volvo trucks is recalling certain model year 2011-2012 vnl and vnm trucks manufactured from May 1, 2010, through January 31, 2011. During the coupling process, it is possible for the driver to partially close the fifth wheel lock and if solely relying on a tug test (pull test), the driver May think that the fifth wheel lock is…
Remedy: Dealers will notify owners, and dealers will replace the lock bar free of charge. The safety recall began on December 7, 2011. Owners May contact Volvo trucks at 1-800-528-6586.
Power train › Driveline
Volvo trucks is recalling certain model year 2012 vhd, vnl, and vnm trucks equipped with a meritor driveline. The tubing used to assemble the drivelines has a nonconforming seam weld with insufficient bonding of the material.
Remedy: Dealers will replace the drivelines free of charge. The safety recall began on July 25, 2011. Owners May contact Volvo trucks at 1-800-528-6586.
Service brakes, air › Slack adjusters
Volvo trucks is recalling certain model year 2011-2012 vhd, vnl, and model year 2012 vnm trucks manufactured from October 15, 2010, through January 31, 2011, and equipped with gunite automatic slack adjusters.
Remedy: Volvo trucks will notify owners and dealers will replace the subject slack adjusters free of charge. The safety recall is expected to begin on or about August 12, 2011. Owners May contact Volvo trucks at 1-800-528-6586.
2011 Volvo VNL recalls (12)
Trailer hitches › Fifth wheel assembly
Volvo Trucks North America (Volvo) is recalling certain model year 2011-2013 VNL and VNM trucks manufactured June 21, 2010, to December 14, 2012. The affected trucks are equipped with Fontaine Ultra LT Fifth Wheel connectors, which, due to cumulative damage to the fifth wheel and its locking mechanism, have a locking mechanism…
Remedy: Volvo will notify owners, and Fontaine dealers will replace the fifth wheel with an Ultra NT model fifth wheel, free of charge. The recall began on November 23, 2015.
Tires
Volvo Trucks North America (Volvo) is recalling certain model year 2011-2014 VAH and VNL trucks manufactured May 12, 2010, to October 31, 2014. The affected vehicles may experience premature tire failure during certain operating conditions such as high speeds, heavy load, and high road temperature.
Remedy: Volvo will notify owners, and dealers will replace the tires and set the road speed limiter, free of charge. The recall began on January 16, 2015. Owners may contact Volvo customer service at 1-800-528-6586.
Forward collision avoidance › Adaptive cruise control
Volvo Trucks of North America (Volvo) is recalling certain model year 2011-2015 VNL and 2014-2015 VNM trucks manufactured November 17, 2010, through February 5, 2014, and equipped with enhanced cruise control and without side fairings.
Remedy: Volvo will notify owners, and dealers will update the control unit software, free of charge. The recall began on August 12, 2014. Owners may contact Volvo customer service at 1-800-528-6586.
Visibility/wiper
Volvo Trucks North America (Volvo) is recalling certain model year 2011-2012 VAH, VHD, VNL, and VNM trucks manufactured February 1, 2010, through September 30, 2010 and June 1, 2011, through November 30, 2011. The windshield wiper motor may fail.
Remedy: Volvo will notify owners and dealers will replace the windshield wiper motor, free of charge. The recallbegan on December 6, 2013. Owners may contact Volvo at 1-336-393-2000. Volvo's recall number is RVXX1304.
Show 8 more recalls
Power train › Clutch assembly
Volvo Trucks North America (Volvo) is recalling certain model year 2007-2014 VAH, VHD, VNL, VNM, and VT models. The affected vehicles were built without a redundant clutch disengagement switch.
Remedy: Volvo Trucks will notify owners and dealers will inspect and repair the vehicles if necessary. The recall began on August 26, 2013. Volvo's recall number is RVXX1303. Owners may contact Volvo at 1-336-393-2000.
Parking brake › Conventional › Air
Volvo Trucks North America (Volvo) is recalling certain model year 2011-2013 VHD and VNL vehicles manufactured December 13, 2010, through July 17, 2012. These vehicles are equipped with an MGM Type 24 J-series piston parking brake chamber.
Remedy: Volvo will notify owners and the brake chambers will be replaced as needed, free of charge. The safety recall is expected to begin on, or before, June 17, 2013. Owners may contact Volvo at 1-336-393-2000.
Service brakes, air › Supply › Check valve
Volvo is recalling certain model year 2011-2012 vhd and model year 2011-2013 vnl and vnm vehicles, manufactured from December 2, 2010, through January 18, 2012, and equipped with bendix atr-6 traction relay valves. In extremely cold conditions, these bendix relay valves May potentially develop internal leakage.
Remedy: Volvo will notify owners, and provide a temporary repair until bendix develops a permanent remedy. A permanent remedy has been developed and notification to owners began on April 27, 2012.
Trailer hitches › Fifth wheel assembly
Volvo trucks is recalling certain model year 2011-2012 vnl and vnm trucks manufactured from May 1, 2010, through January 31, 2011. During the coupling process, it is possible for the driver to partially close the fifth wheel lock and if solely relying on a tug test (pull test), the driver May think that the fifth wheel lock is…
Remedy: Dealers will notify owners, and dealers will replace the lock bar free of charge. The safety recall began on December 7, 2011. Owners May contact Volvo trucks at 1-800-528-6586.
Service brakes, air › Slack adjusters
Volvo trucks is recalling certain model year 2011-2012 vhd, vnl, and model year 2012 vnm trucks manufactured from October 15, 2010, through January 31, 2011, and equipped with gunite automatic slack adjusters.
Remedy: Volvo trucks will notify owners and dealers will replace the subject slack adjusters free of charge. The safety recall is expected to begin on or about August 12, 2011. Owners May contact Volvo trucks at 1-800-528-6586.
Electrical system › 12V/24V/48V battery
Volvo trucks is recalling certain model year 2011 vnl trucks manufactured from March 23, 2010, through December 22, 2010. There is a potential for the vehicle to start without warning because of an unintended path to ground that exists.
Remedy: Dealers will replace a wiring harness free of charge. The safety recall began on April 13, 2011. Owners May contact Volvo trucks at 1-800-528-6586.
Equipment › Other › Labels
Volvo is recalling certain model year 2008-2011 vhd, vnl, vnm, as well as 2008-2010 vt vehicles for failing to comply with the requirements of part 567, "certification." the tire description May be incorrect on the vehicle's certification label.
Remedy: Dealers will inspect and replace the labels free of charge. The safety recall began on February 25, 2011. Owners May contact Volvo at 1-800-458-1552.
Visibility › Power window devices and controls
Volvo trucks is recalling certain model year 2010-2011 vnl trucks. The adhesive used in the upper window in the bunk area to secure the glass May debond.
Remedy: Dealers will inspect and replace the window as required free of charge. The safety recall began on June 4, 2010. Owners May contact Volvo trucks at 1-800-528-6586.
2010 Volvo VNL recalls (4)
Power train › Clutch assembly
Volvo Trucks North America (Volvo) is recalling certain model year 2007-2014 VAH, VHD, VNL, VNM, and VT models. The affected vehicles were built without a redundant clutch disengagement switch.
Remedy: Volvo Trucks will notify owners and dealers will inspect and repair the vehicles if necessary. The recall began on August 26, 2013. Volvo's recall number is RVXX1303. Owners may contact Volvo at 1-336-393-2000.
Equipment › Other › Labels
Volvo is recalling certain model year 2008-2011 vhd, vnl, vnm, as well as 2008-2010 vt vehicles for failing to comply with the requirements of part 567, "certification." the tire description May be incorrect on the vehicle's certification label.
Remedy: Dealers will inspect and replace the labels free of charge. The safety recall began on February 25, 2011. Owners May contact Volvo at 1-800-458-1552.
Visibility › Glass, side/rear
Volvo trucks is recalling certain model year 2009-2010 vnl, vt, and 780 trucks manufactured from March 1, 2008 through February 6, 2009. The bottom track that attaches to the arms used to open and close the window May de-bond, which results in the glass coming loose at the bottom.
Remedy: Dealers will inspect and repair as required free of charge. The safety recall began on December 1, 2010. Owners May contact Volvo trucks at 1-800-528-6586.
Visibility › Power window devices and controls
Volvo trucks is recalling certain model year 2010-2011 vnl trucks. The adhesive used in the upper window in the bunk area to secure the glass May debond.
Remedy: Dealers will inspect and replace the window as required free of charge. The safety recall began on June 4, 2010. Owners May contact Volvo trucks at 1-800-528-6586.
2009 Volvo VNL recalls (4)
Power train › Clutch assembly
Volvo Trucks North America (Volvo) is recalling certain model year 2007-2014 VAH, VHD, VNL, VNM, and VT models. The affected vehicles were built without a redundant clutch disengagement switch.
Remedy: Volvo Trucks will notify owners and dealers will inspect and repair the vehicles if necessary. The recall began on August 26, 2013. Volvo's recall number is RVXX1303. Owners may contact Volvo at 1-336-393-2000.
Equipment › Other › Labels
Volvo is recalling certain model year 2008-2011 vhd, vnl, vnm, as well as 2008-2010 vt vehicles for failing to comply with the requirements of part 567, "certification." the tire description May be incorrect on the vehicle's certification label.
Remedy: Dealers will inspect and replace the labels free of charge. The safety recall began on February 25, 2011. Owners May contact Volvo at 1-800-458-1552.
Visibility › Glass, side/rear
Volvo trucks is recalling certain model year 2009-2010 vnl, vt, and 780 trucks manufactured from March 1, 2008 through February 6, 2009. The bottom track that attaches to the arms used to open and close the window May de-bond, which results in the glass coming loose at the bottom.
Remedy: Dealers will inspect and repair as required free of charge. The safety recall began on December 1, 2010. Owners May contact Volvo trucks at 1-800-528-6586.
Service brakes, air
Volvo trucks is recalling 366 my 2006-2009 vnl trucks equipped with super single tires, bendix brake cam tubes, and Volvo air suspension. The vibration frequency from the suspension with super single tires May result in a fatigue crack of the mounting brackets for the brake cam tube.
Remedy: Dealers will add a support bracket to the brake cam tube. The recall began on June 30, 2009. Owners May contact Volvo trucks at 1-800-528-6586.
2008 Volvo VNL recalls (12)
Power train › Clutch assembly
Volvo Trucks North America (Volvo) is recalling certain model year 2007-2014 VAH, VHD, VNL, VNM, and VT models. The affected vehicles were built without a redundant clutch disengagement switch.
Remedy: Volvo Trucks will notify owners and dealers will inspect and repair the vehicles if necessary. The recall began on August 26, 2013. Volvo's recall number is RVXX1303. Owners may contact Volvo at 1-336-393-2000.
Equipment › Other › Labels
Volvo is recalling certain model year 2008-2011 vhd, vnl, vnm, as well as 2008-2010 vt vehicles for failing to comply with the requirements of part 567, "certification." the tire description May be incorrect on the vehicle's certification label.
Remedy: Dealers will inspect and replace the labels free of charge. The safety recall began on February 25, 2011. Owners May contact Volvo at 1-800-458-1552.
Visibility › Windshield wiper/washer › Motor
Volvo trucks is recalling 127,764 my 2001-2008 vhd, vnl, vnm, and my 2005-2008 vt trucks. A seal May fail allowing water and contaminants to seep into the windshield wiper motor.
Remedy: Volvo will replace the wiper motor free of charge. Since this recall involves a large number of vehicles, Volvo will release the recall in stages as parts are received.
Service brakes, air
Volvo trucks is recalling 366 my 2006-2009 vnl trucks equipped with super single tires, bendix brake cam tubes, and Volvo air suspension. The vibration frequency from the suspension with super single tires May result in a fatigue crack of the mounting brackets for the brake cam tube.
Remedy: Dealers will add a support bracket to the brake cam tube. The recall began on June 30, 2009. Owners May contact Volvo trucks at 1-800-528-6586.
Show 8 more recalls
Engine and engine cooling › Engine › Diesel
On certain trucks, an incorrect software parameter was loaded which resulted in the diesel particulate filter (DPF) 'inhibit' function being disabled. The 'inhibit' function is a means for the driver to stop a DPF regeneration from occurring if a vehicle is in a location that May present a hazardous situation.
Remedy: Dealers will change the control parameters. The recall began on February 15, 2008. Owners May contact Volvo trucks at 1-800-528-6586.
Electrical system › Wiring › Fuses and circuit breakers
On certain heavy duty trucks, the circuit protection (I.e. Automatic circuit breakers) used to protect the vehicle lighting system May not provide adequate protection.
Remedy: Dealers will replace the circuit breakers with fuses. The recall began on February 25, 2008. Owners May contact Volvo trucks at 1-800-528-6586.
Steering › Gear box (other than rack and pinion)
On certain trucks, the bolts that attach the steering gear to the frame May not have been tightened to the specified torque.
Remedy: Dealers will tighten the bolts free of charge. The recall began on December 3, 2007. Owners May contact Volvo trucks at 1-800-528-6586.
Trailer hitches › Fifth wheel assembly
On certain trucks equipped with a saf holland simplex fifth wheel, the lever arm pivot bolt May have been over tightened. An over tightened pivot bolt can distort the pivot bolt spacer sleeve, which May prevent the fifth wheel latch jaw from closing and latching securely around the trailer king pin.
Remedy: Dealers will replace the pivot bolt and sleeve with a hex head shoulder bolt and washer free of charge. The recall began on January 28, 2008. Owners May contact Volvo trucks at 1-800-528-6586.
Structure › Body › Hood › Hinge and attachments
On certain trucks, the hood restraint cylinder does not contain enough dampening to adequately restrain the hood.
Remedy: Dealers will replace the hood restraint cylinders free of charge. The recall began on October 15, 2007. Owners May contact Volvo trucks at 1-800-528-6586.
Fuel system, diesel
On certain trucks, an unprotected lead in the thermoswitch of the heater May make contact with another post possibly creating a short circuit, which can result in continuous operation of the heating element.
Remedy: Dealers will inspect the thermoswitch and will replace it if necessary. The recall began on September 10, 2007. Owners May contact Volvo trucks at 1-800-528-6586.
Steering
On certain trucks, the nut used to retain the steering shaft May or May not be a lock nut that has the locking feature. A lock nut is required to provide additional resistance to ensure that the nut does not come loose.
Remedy: Dealers will replace the steering shaft pinch bolts and locknuts free of charge. The recall began on August 24, 2007. Owners May contact Volvo trucks at 1-800-528-6586.
Power train › Axle assembly
On certain trucks, the axle housings May have been manufactured with steel that was out of specification which could result in a fatigue failure over time.
Remedy: Dealers will repair and inspect the axles and replace them free of charge. The recall began on April 9, 2007. Owners May contact Volvo trucks at 1-800-528-6586.
2007 Volvo VNL recalls (9)
Power train › Clutch assembly
Volvo Trucks North America (Volvo) is recalling certain model year 2007-2014 VAH, VHD, VNL, VNM, and VT models. The affected vehicles were built without a redundant clutch disengagement switch.
Remedy: Volvo Trucks will notify owners and dealers will inspect and repair the vehicles if necessary. The recall began on August 26, 2013. Volvo's recall number is RVXX1303. Owners may contact Volvo at 1-336-393-2000.
Visibility › Windshield wiper/washer › Motor
Volvo trucks is recalling 127,764 my 2001-2008 vhd, vnl, vnm, and my 2005-2008 vt trucks. A seal May fail allowing water and contaminants to seep into the windshield wiper motor.
Remedy: Volvo will replace the wiper motor free of charge. Since this recall involves a large number of vehicles, Volvo will release the recall in stages as parts are received.
Service brakes, air
Volvo trucks is recalling 366 my 2006-2009 vnl trucks equipped with super single tires, bendix brake cam tubes, and Volvo air suspension. The vibration frequency from the suspension with super single tires May result in a fatigue crack of the mounting brackets for the brake cam tube.
Remedy: Dealers will add a support bracket to the brake cam tube. The recall began on June 30, 2009. Owners May contact Volvo trucks at 1-800-528-6586.
Electrical system › Wiring › Fuses and circuit breakers
On certain heavy duty trucks, the circuit protection (I.e. Automatic circuit breakers) used to protect the vehicle lighting system May not provide adequate protection.
Remedy: Dealers will replace the circuit breakers with fuses. The recall began on February 25, 2008. Owners May contact Volvo trucks at 1-800-528-6586.
Show 5 more recalls
Trailer hitches › Fifth wheel assembly
On certain trucks equipped with a saf holland simplex fifth wheel, the lever arm pivot bolt May have been over tightened. An over tightened pivot bolt can distort the pivot bolt spacer sleeve, which May prevent the fifth wheel latch jaw from closing and latching securely around the trailer king pin.
Remedy: Dealers will replace the pivot bolt and sleeve with a hex head shoulder bolt and washer free of charge. The recall began on January 28, 2008. Owners May contact Volvo trucks at 1-800-528-6586.
Fuel system, diesel
On certain trucks, an unprotected lead in the thermoswitch of the heater May make contact with another post possibly creating a short circuit, which can result in continuous operation of the heating element.
Remedy: Dealers will inspect the thermoswitch and will replace it if necessary. The recall began on September 10, 2007. Owners May contact Volvo trucks at 1-800-528-6586.
Steering
On certain trucks, the nut used to retain the steering shaft May or May not be a lock nut that has the locking feature. A lock nut is required to provide additional resistance to ensure that the nut does not come loose.
Remedy: Dealers will replace the steering shaft pinch bolts and locknuts free of charge. The recall began on August 24, 2007. Owners May contact Volvo trucks at 1-800-528-6586.
Power train › Axle assembly
On certain trucks, the axle housings May have been manufactured with steel that was out of specification which could result in a fatigue failure over time.
Remedy: Dealers will repair and inspect the axles and replace them free of charge. The recall began on April 9, 2007. Owners May contact Volvo trucks at 1-800-528-6586.
Power train › Driveline
On certain trucks equipped with arvinmeritor rpl20 high angle interaxle driveshafts, an improper seated or missing snap ring can result in the bearing cup to separate from the slip yoke sub-assembly. The universal joint cross could then contact the slip yoke casting and eventually cause the ear work to fracture.
Remedy: Dealers will inspect the driveshafts and replace them as needed. The recall began on October 23, 2006. Owners May contact Volvo trucks at 1-800-528-6586.
2006 Volvo VNL recalls (7)
Steering › Linkages › Drag › Link › Connection
Volvo trucks is recalling certain model year 2001-2006 vnl and vnm trucks manufactured with a trw sealed drag links. Certain factors can exist, which if left untreated May result in a ball socket separation.
Remedy: Dealers will inspect and repair the ball socket or the drag link as required if necessary. As parts are limited, Volvo trucks mailed an interim owner letter on September 2, 2010.
Visibility › Windshield wiper/washer › Motor
Volvo trucks is recalling 127,764 my 2001-2008 vhd, vnl, vnm, and my 2005-2008 vt trucks. A seal May fail allowing water and contaminants to seep into the windshield wiper motor.
Remedy: Volvo will replace the wiper motor free of charge. Since this recall involves a large number of vehicles, Volvo will release the recall in stages as parts are received.
Service brakes, air
Volvo trucks is recalling 366 my 2006-2009 vnl trucks equipped with super single tires, bendix brake cam tubes, and Volvo air suspension. The vibration frequency from the suspension with super single tires May result in a fatigue crack of the mounting brackets for the brake cam tube.
Remedy: Dealers will add a support bracket to the brake cam tube. The recall began on June 30, 2009. Owners May contact Volvo trucks at 1-800-528-6586.
Electrical system › Wiring › Fuses and circuit breakers
On certain heavy duty trucks, the circuit protection (I.e. Automatic circuit breakers) used to protect the vehicle lighting system May not provide adequate protection.
Remedy: Dealers will replace the circuit breakers with fuses. The recall began on February 25, 2008. Owners May contact Volvo trucks at 1-800-528-6586.
Show 3 more recalls
Engine and engine cooling › Exhaust system
On certain trucks equipped with d12d engines, the exhaust gas recirculation (EGR) cooler inlet pipes or the pipes that connect the EGR valves to the cooler May crack or break.
Remedy: Dealers will inspect and repair the EGR cooler pipes as required and install a heat shield free of charge. An interim owner letter was mailed on February 17, 2006, to advise on precautions that the owner can take until…
Wheels
Certain trucks equipped with front steer axle air suspension May develop a front wheel wobble when the tires become worn.
Remedy: Dealers will repair and replace the front vertical shocks on each side of the front suspension and add a horizontal stabilizer. The recall began on February 20, 2006. Owners May contact Volvo trucks at 1-800-528-6586.
Equipment › Other › Labels
Certain heavy duty trucks fail to comply with the requirements of federal motor vehicle safety standard no. 120, "tire selection and rims for motor vehicles other than passenger cars." the tire size designation on the certification label is not shown.
Remedy: Dealers will replace the certification labels. The recall began on September 12, 2005. Owners May contact Volvo trucks at 1-800-528-6586.
2005 Volvo VNL recalls (6)
Steering › Linkages › Drag › Link › Connection
Volvo trucks is recalling certain model year 2001-2006 vnl and vnm trucks manufactured with a trw sealed drag links. Certain factors can exist, which if left untreated May result in a ball socket separation.
Remedy: Dealers will inspect and repair the ball socket or the drag link as required if necessary. As parts are limited, Volvo trucks mailed an interim owner letter on September 2, 2010.
Visibility › Windshield wiper/washer › Motor
Volvo trucks is recalling 127,764 my 2001-2008 vhd, vnl, vnm, and my 2005-2008 vt trucks. A seal May fail allowing water and contaminants to seep into the windshield wiper motor.
Remedy: Volvo will replace the wiper motor free of charge. Since this recall involves a large number of vehicles, Volvo will release the recall in stages as parts are received.
Electrical system › Wiring › Fuses and circuit breakers
On certain heavy duty trucks, the circuit protection (I.e. Automatic circuit breakers) used to protect the vehicle lighting system May not provide adequate protection.
Remedy: Dealers will replace the circuit breakers with fuses. The recall began on February 25, 2008. Owners May contact Volvo trucks at 1-800-528-6586.
Engine and engine cooling › Exhaust system
On certain trucks equipped with d12d engines, the exhaust gas recirculation (EGR) cooler inlet pipes or the pipes that connect the EGR valves to the cooler May crack or break.
Remedy: Dealers will inspect and repair the EGR cooler pipes as required and install a heat shield free of charge. An interim owner letter was mailed on February 17, 2006, to advise on precautions that the owner can take until…
Show 2 more recalls
Wheels
Certain trucks equipped with front steer axle air suspension May develop a front wheel wobble when the tires become worn.
Remedy: Dealers will repair and replace the front vertical shocks on each side of the front suspension and add a horizontal stabilizer. The recall began on February 20, 2006. Owners May contact Volvo trucks at 1-800-528-6586.
Equipment › Other › Labels
Certain heavy duty trucks fail to comply with the requirements of federal motor vehicle safety standard no. 120, "tire selection and rims for motor vehicles other than passenger cars." the tire size designation on the certification label is not shown.
Remedy: Dealers will replace the certification labels. The recall began on September 12, 2005. Owners May contact Volvo trucks at 1-800-528-6586.
2004 Volvo VNL recalls (6)
Steering › Linkages › Drag › Link › Connection
Volvo trucks is recalling certain model year 2001-2006 vnl and vnm trucks manufactured with a trw sealed drag links. Certain factors can exist, which if left untreated May result in a ball socket separation.
Remedy: Dealers will inspect and repair the ball socket or the drag link as required if necessary. As parts are limited, Volvo trucks mailed an interim owner letter on September 2, 2010.
Visibility › Windshield wiper/washer › Motor
Volvo trucks is recalling 127,764 my 2001-2008 vhd, vnl, vnm, and my 2005-2008 vt trucks. A seal May fail allowing water and contaminants to seep into the windshield wiper motor.
Remedy: Volvo will replace the wiper motor free of charge. Since this recall involves a large number of vehicles, Volvo will release the recall in stages as parts are received.
Electrical system › Wiring › Fuses and circuit breakers
On certain heavy duty trucks, the circuit protection (I.e. Automatic circuit breakers) used to protect the vehicle lighting system May not provide adequate protection.
Remedy: Dealers will replace the circuit breakers with fuses. The recall began on February 25, 2008. Owners May contact Volvo trucks at 1-800-528-6586.
Engine and engine cooling › Exhaust system
On certain trucks equipped with d12d engines, the exhaust gas recirculation (EGR) cooler inlet pipes or the pipes that connect the EGR valves to the cooler May crack or break.
Remedy: Dealers will inspect and repair the EGR cooler pipes as required and install a heat shield free of charge. An interim owner letter was mailed on February 17, 2006, to advise on precautions that the owner can take until…
Show 2 more recalls
Wheels
Certain trucks equipped with front steer axle air suspension May develop a front wheel wobble when the tires become worn.
Remedy: Dealers will repair and replace the front vertical shocks on each side of the front suspension and add a horizontal stabilizer. The recall began on February 20, 2006. Owners May contact Volvo trucks at 1-800-528-6586.
Equipment › Other › Labels
Certain heavy duty trucks fail to comply with the requirements of federal motor vehicle safety standard no. 120, "tire selection and rims for motor vehicles other than passenger cars." the tire size designation on the certification label is not shown.
Remedy: Dealers will replace the certification labels. The recall began on September 12, 2005. Owners May contact Volvo trucks at 1-800-528-6586.
2003 Volvo VNL recalls (9)
Steering › Linkages › Drag › Link › Connection
Volvo trucks is recalling certain model year 2001-2006 vnl and vnm trucks manufactured with a trw sealed drag links. Certain factors can exist, which if left untreated May result in a ball socket separation.
Remedy: Dealers will inspect and repair the ball socket or the drag link as required if necessary. As parts are limited, Volvo trucks mailed an interim owner letter on September 2, 2010.
Visibility › Windshield wiper/washer › Motor
Volvo trucks is recalling 127,764 my 2001-2008 vhd, vnl, vnm, and my 2005-2008 vt trucks. A seal May fail allowing water and contaminants to seep into the windshield wiper motor.
Remedy: Volvo will replace the wiper motor free of charge. Since this recall involves a large number of vehicles, Volvo will release the recall in stages as parts are received.
Electrical system › Wiring › Fuses and circuit breakers
On certain heavy duty trucks, the circuit protection (I.e. Automatic circuit breakers) used to protect the vehicle lighting system May not provide adequate protection.
Remedy: Dealers will replace the circuit breakers with fuses. The recall began on February 25, 2008. Owners May contact Volvo trucks at 1-800-528-6586.
Engine and engine cooling › Exhaust system
On certain trucks equipped with d12d engines, the exhaust gas recirculation (EGR) cooler inlet pipes or the pipes that connect the EGR valves to the cooler May crack or break.
Remedy: Dealers will inspect and repair the EGR cooler pipes as required and install a heat shield free of charge. An interim owner letter was mailed on February 17, 2006, to advise on precautions that the owner can take until…
Show 5 more recalls
Wheels
Certain trucks equipped with front steer axle air suspension May develop a front wheel wobble when the tires become worn.
Remedy: Dealers will repair and replace the front vertical shocks on each side of the front suspension and add a horizontal stabilizer. The recall began on February 20, 2006. Owners May contact Volvo trucks at 1-800-528-6586.
Equipment › Recreational vehicle/trailer
On certain heavy-duty trucks, when the bunk is raised into the stored position, an object left on the bunk May inadvertently turn on a bunk lamp.
Remedy: Dealers will install a bunk lamp with a push button on/off switch. Owner notification began on December 24, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive…
Electrical system › Wiring
On certain trucks, the wiring harness connected to the chassis mounted electrical inverter May allow water to enter the inverter and cause an electrical short in the inverter.
Remedy: Dealers will replace the wiring harness on these vehicles. Owner notification is expected to begin during August 2003. Owners should contact Volvo trucks at 1-800-528-6586.
Trailer hitches › Fifth wheel assembly
On certain heavy duty trucks equipped with jost international jsk 37u series fifth wheels, a fatigue crack can develop in the bracket pin weld under certain loading conditions.
Remedy: Dealers will replace the bracket pins and repair instructions free of charge. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable…
Visibility › Glass, side/rear
On certain heavy duty class 8 trucks, the sleeper section upper side window glass May de-bond from the window opening slide track mechanism.
Remedy: Dealers will replace the window. Owner notification began on February 26, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a…
2002 Volvo VNL recalls (7)
Steering › Linkages › Drag › Link › Connection
Volvo trucks is recalling certain model year 2001-2006 vnl and vnm trucks manufactured with a trw sealed drag links. Certain factors can exist, which if left untreated May result in a ball socket separation.
Remedy: Dealers will inspect and repair the ball socket or the drag link as required if necessary. As parts are limited, Volvo trucks mailed an interim owner letter on September 2, 2010.
Visibility › Windshield wiper/washer › Motor
Volvo trucks is recalling 127,764 my 2001-2008 vhd, vnl, vnm, and my 2005-2008 vt trucks. A seal May fail allowing water and contaminants to seep into the windshield wiper motor.
Remedy: Volvo will replace the wiper motor free of charge. Since this recall involves a large number of vehicles, Volvo will release the recall in stages as parts are received.
Equipment › Recreational vehicle/trailer
On certain heavy-duty trucks, when the bunk is raised into the stored position, an object left on the bunk May inadvertently turn on a bunk lamp.
Remedy: Dealers will install a bunk lamp with a push button on/off switch. Owner notification began on December 24, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive…
Electrical system › Wiring
On certain trucks, the wiring harness connected to the chassis mounted electrical inverter May allow water to enter the inverter and cause an electrical short in the inverter.
Remedy: Dealers will replace the wiring harness on these vehicles. Owner notification is expected to begin during August 2003. Owners should contact Volvo trucks at 1-800-528-6586.
Show 3 more recalls
Trailer hitches › Fifth wheel assembly
On certain heavy duty trucks equipped with jost international jsk 37u series fifth wheels, a fatigue crack can develop in the bracket pin weld under certain loading conditions.
Remedy: Dealers will replace the bracket pins and repair instructions free of charge. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable…
Suspension › Front
On certain trucks equipped with truck hub units manufactured by skf exclusively for use on arvinmeritor's ff98x series non-drive steer axles, the hub unit bearings can wear prematurely.
Remedy: Dealers will replace all front axle hubs. An interim notice to owners was mailed on June 25, 2003. Final owner notification began on October 6, 2003.
Exterior lighting › Tail lights › Switch
Certain heavy duty class 8 trucks fail to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." the two tail lamps, back-up lamp,and license tag lamp were mounted on insufficiently rigid mounts.
Remedy: Dealers will attach the two tail lamps, back-up lamp, and the license tap lamp on stiffer brackets. Owner notification began October 31, 2002.
2001 Volvo VNL recalls (8)
Steering › Linkages › Drag › Link › Connection
Volvo trucks is recalling certain model year 2001-2006 vnl and vnm trucks manufactured with a trw sealed drag links. Certain factors can exist, which if left untreated May result in a ball socket separation.
Remedy: Dealers will inspect and repair the ball socket or the drag link as required if necessary. As parts are limited, Volvo trucks mailed an interim owner letter on September 2, 2010.
Visibility › Windshield wiper/washer › Motor
Volvo trucks is recalling 127,764 my 2001-2008 vhd, vnl, vnm, and my 2005-2008 vt trucks. A seal May fail allowing water and contaminants to seep into the windshield wiper motor.
Remedy: Volvo will replace the wiper motor free of charge. Since this recall involves a large number of vehicles, Volvo will release the recall in stages as parts are received.
Trailer hitches › Fifth wheel assembly
On certain heavy duty trucks equipped with jost international jsk 37u series fifth wheels, a fatigue crack can develop in the bracket pin weld under certain loading conditions.
Remedy: Dealers will replace the bracket pins and repair instructions free of charge. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable…
Suspension › Front
On certain trucks equipped with truck hub units manufactured by skf exclusively for use on arvinmeritor's ff98x series non-drive steer axles, the hub unit bearings can wear prematurely.
Remedy: Dealers will replace all front axle hubs. An interim notice to owners was mailed on June 25, 2003. Final owner notification began on October 6, 2003.
Show 4 more recalls
Exterior lighting › Tail lights › Switch
Certain heavy duty class 8 trucks fail to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." the two tail lamps, back-up lamp,and license tag lamp were mounted on insufficiently rigid mounts.
Remedy: Dealers will attach the two tail lamps, back-up lamp, and the license tap lamp on stiffer brackets. Owner notification began October 31, 2002.
Service brakes, air › Antilock
Certain heavy duty class 8 vehicles fail to comply with federal motor vehicle safety standard no. 121, "air brake systems", s5.1.6.3, "antilock power for towed vehicles." electrical power for the trailer anti-lock braking system (ABS) can be disrupted when a switch located on the vehicle instrument panel is activated to control…
Remedy: Dealers will install a wiring harness which will provide continuous electrical power to the trailer ABS whenever the ignition switch is in the on or run position. Owner notification began April 29, 2002.
Service brakes, air › Supply › Check valve
On certain heavy duty trucks equipped with meritor wabco pneumatic anitlock brake system (ABS) valve packages, the assembly bolts on these valve packages were not tightened correctly.
Remedy: Dealers will tighten the fasteners to the proper specification. Owner notification began February 27, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the…
Steering › Gear box (other than rack and pinion)
Vehicle description: heavy duty class 8 trucks. The wrong steering column to steering gear shaft May have been installed in these vehicles. Using the shorter vnm steering shaft could result in steering shaft being operated (steering column extended adjustment) outside the normal operating range of the steering shaft.
Remedy: Dealers will install the correct lower steering shaft. Owner notification began June 27, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy…
2000 Volvo VNL recalls (4)
Suspension › Front
On certain trucks equipped with truck hub units manufactured by skf exclusively for use on arvinmeritor's ff98x series non-drive steer axles, the hub unit bearings can wear prematurely.
Remedy: Dealers will replace all front axle hubs. An interim notice to owners was mailed on June 25, 2003. Final owner notification began on October 6, 2003.
Exterior lighting › Tail lights › Switch
Certain heavy duty class 8 trucks fail to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." the two tail lamps, back-up lamp,and license tag lamp were mounted on insufficiently rigid mounts.
Remedy: Dealers will attach the two tail lamps, back-up lamp, and the license tap lamp on stiffer brackets. Owner notification began October 31, 2002.
Service brakes, air › Antilock
Certain heavy duty class 8 vehicles fail to comply with federal motor vehicle safety standard no. 121, "air brake systems", s5.1.6.3, "antilock power for towed vehicles." electrical power for the trailer anti-lock braking system (ABS) can be disrupted when a switch located on the vehicle instrument panel is activated to control…
Remedy: Dealers will install a wiring harness which will provide continuous electrical power to the trailer ABS whenever the ignition switch is in the on or run position. Owner notification began April 29, 2002.
Service brakes, air › Antilock
Vehicle description: heavy duty trucks built with bendix air ABS with an ec-17 1030r electronic control unit (ECU), there have been reports of unwanted ABS activation at low speeds caused by 1) chafed ABS wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of…
Remedy: Dealers will replace the ABS ECU.
1999 Volvo VNL recalls (5)
Suspension › Front
On certain trucks equipped with truck hub units manufactured by skf exclusively for use on arvinmeritor's ff98x series non-drive steer axles, the hub unit bearings can wear prematurely.
Remedy: Dealers will replace all front axle hubs. An interim notice to owners was mailed on June 25, 2003. Final owner notification began on October 6, 2003.
Exterior lighting › Tail lights › Switch
Certain heavy duty class 8 trucks fail to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." the two tail lamps, back-up lamp,and license tag lamp were mounted on insufficiently rigid mounts.
Remedy: Dealers will attach the two tail lamps, back-up lamp, and the license tap lamp on stiffer brackets. Owner notification began October 31, 2002.
Service brakes, air › Antilock
Certain heavy duty class 8 vehicles fail to comply with federal motor vehicle safety standard no. 121, "air brake systems", s5.1.6.3, "antilock power for towed vehicles." electrical power for the trailer anti-lock braking system (ABS) can be disrupted when a switch located on the vehicle instrument panel is activated to control…
Remedy: Dealers will install a wiring harness which will provide continuous electrical power to the trailer ABS whenever the ignition switch is in the on or run position. Owner notification began April 29, 2002.
Service brakes, air › Antilock
Vehicle description: heavy duty trucks built with bendix air ABS with an ec-17 1030r electronic control unit (ECU), there have been reports of unwanted ABS activation at low speeds caused by 1) chafed ABS wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of…
Remedy: Dealers will replace the ABS ECU.
Show 1 more recall
Tires › Bead
Vehicle description: heavy duty trucks equipped with continental general s380a 295/75r22.5 lr g tires, serial nos. A3371e5488 through a3371e5089. These tires have been overcured.
Remedy: Continental general is conducting the owner notification and remedy for this campaign. Dealers will exchange the tire for an identical or reasonably equivalent tire.
1998 Volvo VNL recalls (5)
Suspension › Front
On certain trucks equipped with truck hub units manufactured by skf exclusively for use on arvinmeritor's ff98x series non-drive steer axles, the hub unit bearings can wear prematurely.
Remedy: Dealers will replace all front axle hubs. An interim notice to owners was mailed on June 25, 2003. Final owner notification began on October 6, 2003.
Exterior lighting › Tail lights › Switch
Certain heavy duty class 8 trucks fail to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." the two tail lamps, back-up lamp,and license tag lamp were mounted on insufficiently rigid mounts.
Remedy: Dealers will attach the two tail lamps, back-up lamp, and the license tap lamp on stiffer brackets. Owner notification began October 31, 2002.
Service brakes, air › Antilock
Certain heavy duty class 8 vehicles fail to comply with federal motor vehicle safety standard no. 121, "air brake systems", s5.1.6.3, "antilock power for towed vehicles." electrical power for the trailer anti-lock braking system (ABS) can be disrupted when a switch located on the vehicle instrument panel is activated to control…
Remedy: Dealers will install a wiring harness which will provide continuous electrical power to the trailer ABS whenever the ignition switch is in the on or run position. Owner notification began April 29, 2002.
Service brakes, air › Antilock
Vehicle description: heavy duty trucks built with bendix air ABS with an ec-17 1030r electronic control unit (ECU), there have been reports of unwanted ABS activation at low speeds caused by 1) chafed ABS wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of…
Remedy: Dealers will replace the ABS ECU.
Show 1 more recall
Tires › Bead
Vehicle description: heavy duty trucks equipped with continental general s380a 295/75r22.5 lr g tires, serial nos. A3371e5488 through a3371e5089. These tires have been overcured.
Remedy: Continental general is conducting the owner notification and remedy for this campaign. Dealers will exchange the tire for an identical or reasonably equivalent tire.
1997 Volvo VNL recalls (4)
Exterior lighting › Tail lights › Switch
Certain heavy duty class 8 trucks fail to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." the two tail lamps, back-up lamp,and license tag lamp were mounted on insufficiently rigid mounts.
Remedy: Dealers will attach the two tail lamps, back-up lamp, and the license tap lamp on stiffer brackets. Owner notification began October 31, 2002.
Service brakes, air › Antilock
Certain heavy duty class 8 vehicles fail to comply with federal motor vehicle safety standard no. 121, "air brake systems", s5.1.6.3, "antilock power for towed vehicles." electrical power for the trailer anti-lock braking system (ABS) can be disrupted when a switch located on the vehicle instrument panel is activated to control…
Remedy: Dealers will install a wiring harness which will provide continuous electrical power to the trailer ABS whenever the ignition switch is in the on or run position. Owner notification began April 29, 2002.
Service brakes, air › Antilock
Vehicle description: heavy duty trucks built with bendix air ABS with an ec-17 1030r electronic control unit (ECU), there have been reports of unwanted ABS activation at low speeds caused by 1) chafed ABS wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of…
Remedy: Dealers will replace the ABS ECU.
Suspension › Front › Wheel bearing
Vehicle description: class 8 heavy duty trucks. The steer axle wheel bearing jam nut lock washer May not have been bent over the jam nut after the wheel bearings were adjusted.
Remedy: Dealers will inspect the steering axle wheel bearing jam nut lock washer to determine if it is bent over the jam nut, and if not, repair as required.
Frequently asked questions
How many recalls does the Volvo VNL have?
NHTSA lists 107 recalls for the Volvo VNL across 31 model years, 2 of them with a do-not-drive or park-outside warning.
How do I know if my Volvo VNL has an open recall?
Enter your 17-character VIN in our VIN decoder & recall check or on nhtsa.gov/recalls. Dealers fix recalls for free, even if you are not the original owner.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.