Most common 2014 Volvo VNL problems
Share of the 8 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Volvo VNL complaints by model year
Best VNL years: 2017, 2020, 2021. Years to avoid: 2016, 2007. Compare all years →
2014 Volvo VNL recalls (12)
Service brakes, air
Volvo Trucks North America (Volvo) is recalling certain model year 2013-2017 VNL and VNM trucks and certain model year 2017 VNX trucks. In the affected vehicles, incorrect software for controlling the electronic air dryer may result in oil and water contaminating the brake system.
Remedy: Volvo will notify owners, and dealers will reprogram the vehicle control module and replace the air dryer filter, free of charge. The recall began on February 16, 2017.
Electrical system
Volvo Trucks North America (Volvo) is recalling certain model year 2012-2014 Volvo VNL trucks manufactured December 1, 2011, to September 1, 2013, equipped with certain Electric Auxiliary Power Units (APU), part number BA600, manufactured by Idle Free Systems (IFS).
Remedy: Volvo will notify owners and IFS dealers will inspect the APU for damage and, where needed, install a welded gusset upgrade kit to strengthen the APU C-channels. All units will receive stronger clamping brackets.
Service brakes
Volvo Trucks North America (Volvo) is recalling certain model year 2012-2015 VNL and VNM trucks manufactured May 31, 2011, to December 1, 2014. In the affected trucks, the trailer hand brake handle may not to return to the off position due to being restricted by the cut out in the trim panel.
Remedy: Volvo will notify owners, and dealers will inspect the trim panel slot and make it longer, as necessary, free of charge. The recall began on October 19, 2015. Owners may contact Volvo customer service at 1-800-258-6586.
Power train › Automatic transmission
Volvo Trucks North America (Volvo) is recalling certain model year 2012, 2014-2015 VHD, 2012-2015 VNL, and 2014-2015 VNM trucks manufactured June 16, 2011, to August 18, 2014, and equipped with the Eco-Roll option. The affected trucks may fail to re-engage the vehicle drivetrain after using the Eco-Roll feature.
Remedy: Volvo has notified owners, and dealers will update the Eco-Roll software, free of charge. The recall began on December 10, 2014. Owners may contact Volvo customer service at 1-800-528-6586.
Tires
Volvo Trucks North America (Volvo) is recalling certain model year 2011-2014 VAH and VNL trucks manufactured May 12, 2010, to October 31, 2014. The affected vehicles may experience premature tire failure during certain operating conditions such as high speeds, heavy load, and high road temperature.
Remedy: Volvo will notify owners, and dealers will replace the tires and set the road speed limiter, free of charge. The recall began on January 16, 2015. Owners may contact Volvo customer service at 1-800-528-6586.
Service brakes, air › Disc › Caliper
Volvo Trucks North America (Volvo) is recalling certain model year 2014-2015 VAH, VNL, and VNM trucks manufactured March 4, 2013, to April 28, 2014. Due to the bolts holding the disc brake caliper to the backing plate not being tightened to the specified torque, the disc brake caliper may detach from the backing plate.
Remedy: Volvo will notify owners, and dealers will inspect and tighten the bolts to specification, as necessary, free of charge. The recall began October 10, 2014. Owners may contact Volvo customer service at 1-800-528-6586.
Show 6 more recalls
Forward collision avoidance › Adaptive cruise control
Volvo Trucks of North America (Volvo) is recalling certain model year 2011-2015 VNL and 2014-2015 VNM trucks manufactured November 17, 2010, through February 5, 2014, and equipped with enhanced cruise control and without side fairings.
Remedy: Volvo will notify owners, and dealers will update the control unit software, free of charge. The recall began on August 12, 2014. Owners may contact Volvo customer service at 1-800-528-6586.
Engine and engine cooling › Engine
Volvo Trucks North America (Volvo) is recalling certain model year 2013-2015 VNL trucks, and 2013-2014 VNM trucks equipped with certain Cummins Westport Model ISL G and ISX12 G engines.
Remedy: Cummins Inc. and Cummins Wesport Inc. will notify owners, and authorized Cummins service facilities will upload a new ECM calibration, free of charge. The recall began on April 12, 2014.
Seat belts
Volvo Trucks North America (Volvo) is recalling certain model year 2014 VAH, VHD, VNL, and VNM trucks manufactured August 12, 2013, through November 14, 2013; and equipped with IMMI-brand L9 seat belt buckles.
Remedy: Volvo will notify owners, and dealers will inspect and replace the seat belt buckle, as necessary, free of charge. The recall began on January 27, 2014. Owners may contact Volvo at 1-336-393-2000.
Power train › Driveline › Driveshaft
Volvo Trucks North America is recalling certain model year 2013-2014 VNL vehicles manufactured April 2, 2012, through May 3, 2013; and equipped with a Meritor RPL-20 driveline transmission. The driveshaft is too weak for this application and may fail.
Remedy: Volvo will notify owners, and dealers will replace the driveshaft, free of charge. The recall began on October 9, 2013. Owners may contact Volvo at 1-336-393-2000. Volvo's recall number is RVXX1305.
Power train › Clutch assembly
Volvo Trucks North America (Volvo) is recalling certain model year 2007-2014 VAH, VHD, VNL, VNM, and VT models. The affected vehicles were built without a redundant clutch disengagement switch.
Remedy: Volvo Trucks will notify owners and dealers will inspect and repair the vehicles if necessary. The recall began on August 26, 2013. Volvo's recall number is RVXX1303. Owners may contact Volvo at 1-336-393-2000.
Electrical system › 12V/24V/48V battery › Cables
Volvo is recalling certain model year 2012-2014 VHD, VNL, and VNM trucks, manufactured from April 18, 2011, through March 14, 2013, and equipped with a horizontally mounted remote battery disconnect switch. The remote battery disconnect switch was manufactured with incorrect hardware allowing the cables to loosen.
Remedy: Volvo will send owners an interim letter and dealers will replace and relocate the remote battery disconnect switch. The recall began on May 7, 2013.
NHTSA defect investigations
Federal safety investigators have looked into 3 possible defects involving the 2014 Volvo VNL:
Stop Lamp Switch Signal
The Office of Defects Investigation (ODI) received Early Warning Reporting (EWR) data from the manufacturer that indicated some number of subject vehicles equipped with the subject automated manual transmission had allegedly experienced a condition where the clutch failed to automatically disengage the transmission from the engine as intended.
Ride Quality
The Office of Defects Investigation (ODI) opened this Defect Petition (DP) assessment in response to a defect petition received from owners of a 2015 Volvo VNL 780 tractor.Prior to submitting the letter the owners had submitted two Vehicle Owner Questionnaires (VOQ).Their concerns included: cab sway, cab alignment , and loss of control.The petitioners further allege that due to a failure of the suspension system…
Discrepancies in Required CFR Reporting
On October 22, 2018, an Audit Query (AQ18-005) was opened to assess the completeness and timeliness of Volvo Group's early warning reporting, safety recalls, and communications submissions to the agency.NHTSA's investigation determined that Volvo Group failed to recall vehicles in a timely fashion and to comply with other recall and reporting requirements, including notifying owners of recalls and reporting death…
What 2014 Volvo VNL owners say
Engine & cooling
The affected component is part of the exhaust aftertreatment system, also known as the selective catalytic reduction (SCR) system. These systems were implemented in nearly all Class 8 truck engines in the U.S. to meet 2010 emissions standards. The degradation could put the engines out of compliance with emissions standards. This is a very costly repair in excess of $10,000 in a truck with only 466,000 miles on it. we have had in many times and lots of repair cost to try to keep the truck in compliance and continues to go in Derate.
Tl* the contact owns a 2014 Volvo VNL. While driving at a low speed, the contact noticed coolant leaking underneath the vehicle. In addition, the contact noticed that the grill was bent from the continual opening and closing of the hood. The dealer diagnosed that a valve and the grill needed to be replaced. The vehicle was repaired; however, the failure recurred. The contact stated that the grill was never properly attached. The manufacturer was not notified of the failure. The failure mileage was 390,000.
Frequently asked questions
Is the 2014 Volvo VNL a good car?
Based on 8 owner complaints filed with NHTSA, the 2014 VNL rates average: 1.5× as many complaints as a typical year of the VNL at the same age. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2014 Volvo VNL?
The engine & cooling — 3 complaints, 38% of all complaints for this model year. Next are the windows, wipers & sunroof (1) and transmission & drivetrain (1).
How many recalls does the 2014 Volvo VNL have?
There are 12 recalls for the 2014 Volvo VNL, the most recent from December 22, 2016 (service brakes, air). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Volvo VNL?
The best years by complaints, compared at the same age, are 2017, 2020 and 2021. Years to avoid or approach with caution: 2016 and 2007. See the full Volvo VNL years comparison.
At what mileage do 2014 Volvo VNL problems happen?
The median mileage reported in complaints is about 100,000 miles; 40% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.