2015 Volkswagen Golf Fuel System Problems

Mileage when the problem started

• Under 25k
  330%
• 25k–50k
  00%
• 50k–75k
  440%
• 75k–100k
  110%
• 100k–150k
  220%
• 150k+
  00%

Owner reports

Selected complaints filed with NHTSA by 2015 Volkswagen Golf owners, lightly cleaned up (personal details are redacted by NHTSA).

The contact owns a 2015 Volkswagen Golf. The contact noticed that the fuel pump would frequent stop while fueling the vehicle. The contact then stated that while his vehicle was being driven by a valet, fuel began to pour out of the fuel tank while on an incline. The valet attendant managed to drive the vehicle down a decline which stopped the leak. Despite the failure, the contact was able to drive the vehicle home. The vehicle was then driven to a dealer where a diagnostic test was performed. The dealer informed the contact that the suction pump, seal, and emission filter needed to be replaced. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 16V647000 (Fuel System, Gasoline, Engine and Engine Cooling) however, the VIN was not included in the recall. The manufacturer was notified of the failure and informed him that the vehicle was no longer under warranty. …

The contact owns a 2015 Volkswagen Golf. The contact stated while driving at an undisclosed speed, the fuel gauge level dropped quickly, and there was an abnormal fuel odor before the vehicle shutoff in the middle of the roadway. The contact stated that the check engine warning light was illuminated. The contact exited the vehicle and push the vehicle to the side of the road. The contact stated that while checking underneath the vehicle, the contact became aware of a fuel leak. The vehicle was towed to an independent mechanic to be diagnosed. The independent mechanic confirmed the fuel leak and referred the contact to the dealer for assistance with the repair. The vehicle was not yet repaired. The contact referenced NHTSA Campaign Number: 24V110000 (FUEL SYSTEM, GASOLINE) as a possible cause for the failure. The manufacturer was not notified of the failure. …

The contact owns a 2015 Volkswagen Golf. The contact received notification of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while refueling the vehicle, there was fuel leaking from the vehicle, making it impossible to fill the fuel tank. The dealer was contacted. The manufacturer was not made aware of the issue. The failure mileage was 73,780. VIN tool confirms parts not available.

Vehicle had recall for "leaking fuel fire risk" Strong smell of fuel inside car. Manufacturer recall #20UF NHTSA recall 24V110 There has not been a fix yet available. Dealer (Team Volkswagen Merrillville IN) replaced the Jet fuel pump. Problem continued, VW engineering said bring the car back and replace the entire fuel tank. Completed. Problem returned 2 weeks later ([redacted]). While driving home from work noticed extremely strong fuel odor in car. Pulled off in a store parking lot, someone ran up and told me my car was leaking fuel. Gas was literally pouring out, I lost 1/4 tank of fuel on way home. The fuel was leaking under hood, under fuel tank area and under the rear passenger seat. I had the car towed to the dealer. Volkswagen does not have an actual fix for the problem. I should be given a replacement car due to Volkswagen being unable to correct this serious safety issue. …

I was putting gas and it started shooting out gas from the tank fuel. I had filled up 2 gallons and the entire two gallons ended up on the floor of the gas station. I took the car to an old Volkswagen specialist and he suggested I get an evap system smoke test to determine what the problem is. I did the test and it came back as a faulty evap canister. That the evap vent valve is stuck closed and purge is allowing fuel into the canister. So I bought an oem canister and replaced the old one. For one day the car drove fine with no issue putting gas or any leaks. The next day I noticed the smell of gas and saw that it was leaking gas from behind the rear wheel. I took it to a local mechanic and the car leaked the remaining 60 miles of gas on the floor. Also the new canister is filled with gas again.

I brought my 2015 Volkswagen (with only 50,000 miles) to Island Volkswagen in NY for a fuel system recall repair. Before this, the car had no fuel smell, no leaks, and was driving normally. Immediately after the recall work, I began smelling fuel. The dealership told me the fuel line is leaking and needs to be replaced. I never had this issue before, and it's clearly related to the repair they performed. I'm now being told I must pay $550 out of pocket for something I believe was caused by their handling of the fuel system during the recall. This is a serious safety concern. If I drive this car and something goes wrong, it could result in a fire. I believe this issue deserves review, especially if other drivers experience similar problems after this recall.

The contact owns a 2015 Volkswagen Golf. The contact received notification of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that parts were not yet available. The manufacturer was made aware of the issue and informed the contact that a second notice would be mailed when parts became available. The contact had not experienced a failure. VIN tool confirms parts not available.

I was driving to my grandparents house and once i got to the house there was gasoline dripping from the back of car, from the area of the tank. "61821 SE VERIFICO UNIDAD CON LIQUEO DE GASOLINA , SE VERIFICO Y SE ENCONTRO CHARCOL CANISTER LLENO DE GASOLINA , SE HIZO TEST PLAN Y SE ENCONTRO VALVULA INTERNA DEL TANQUE DE LA GASOLINA TRANCADA Y ESTO OCASIONANDO LIQUEO DE GASOLINA , SE REMOVIO Y SE INSTALO TANQUE DE GASOLINA NUEVO Y CANISTER DE LOS GASES NUEVO Y VALVULA N80 NUEVA Y SE LIMPIARON TODAS LAS LINES DEL SISTEMA , SE HIZO TEST Y NO PRESENTO LIQUEO DE GASOLINA" - Mecanic

Alarm went off in car - said coolant was low - had to pull over. Luckily was in neighborhood but could have been on highway. Gas station confirmed issue and let me know that the water pump and entire thermostat housing system had to be replaced - very expensive repair and dangerous issue. If it had happened on highway, would have had to pull over immediately there.

Suction pump recall was completed by Karmart the dealership I purchased the vehicle from. Suction pump continues to be an issue with fuel purging or leaking. This has been an ongoing issue for the past 5 months. Most recently a few days ago.

Related recalls

NHTSA investigations

Fuel System complaints in other Golf years