Which parts fail
Components named in complaints (doors, hood, frame, rust, paint and trim).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2020 Toyota Highlander owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact's wife owns a 2020 Toyota Highlander. The contact stated while the vehicle was parked, his wife noticed that the front passenger's side carpeting was extremely wet. Upon investigating the failure, both the contact and his wife noticed that the carpeting underneath was extremely soaked. The contact stated that both he and his wife used towels to soak up the water. The vehicle was taken to an independent mechanic where it was diagnosed that the HVAC evaporator drain hose was clogged, which caused water to leak into the front passenger's side of the vehicle. The independent mechanic informed the contact that the failure was related to Toyota Technical Service Bulletin Number: 0080-19 (HVAC Evaporator Drain Hose Clogged Due to Insect Intrusion) and referred the contact to the dealer for the repair. …
The contact owns a 2020 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V720000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the front lower bumper cover had detached on the front passenger's side and was swinging while driving. The vehicle was taken to the dealer, who informed the contact that the vehicle needed to be repaired at an auto body collision shop due to a crack on the front lower bumper cover, prior to the recall repair. The contact stated that the dealer failed to honor the recall repair because the recall repair involved repairing or replacing the upper and lower front bumper covers as necessary, free of charge. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. …
The contact owns a 2020 Toyota Highlander. The contact stated while driving approximately 50 MHP, the contact's husband became aware that there was unknown part had loosened on the front of the vehicle. The contact pulled over to the side of the road and upon inspecting the vehicle, the contact became aware that the front bumper assembly was detaching. The vehicle was taken to an independent mechanic however, the vehicle was not repaired due to the cost. The contact then received notification of NHTSA Campaign Number: 23V720000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 30,000. Parts distribution disconnect.
The contact owns a 2020 Toyota Highlander. The contact stated while inspecting the vehicle after an oil change, she noticed that the front lower bumper assembly was detached and was hanging down. Additionally, there was an abnormal sound coming from the front of the vehicle while driving. The contact received notification of NHTSA Campaign Number: 23V720000 (Structure) and the vehicle was taken to the dealer for the recall repair; however, the dealer informed the contact that the recall repair could not be performed unless she paid a fee to repair a scratch on the bumper. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 7,000. Parts distribution disconnect.
The contact owns a 2020 Toyota Highlander. The contact stated while driving at approximately 65 MPH, the front lower bumper cover detached from the vehicle, causing debris to scatter onto the highway, while the damaged bumper cover was dragged underneath the vehicle. During the failure, the vehicle sustained excessive front-end damage, and damages to the undercarriage and fender liners. The vehicle was taken to the local dealer who confirmed that the failure was related to NHTSA Campaign Number: 23V720000 (Structure). The contact stated that the vehicle had experienced the failure listed in the recall. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 51,260.
Several times pulling out from stop signs I failed to see cars coming from the passenger side. On August 4th 2021 I failed to see a car until it was directly in front of me and I collided with it. Wondering how I could have failed to see it I started doing research on the internet. I discovered others had this same problem also involving an accident. It was brought to my attention the mirrors are large and placed high in regards to the passenger window. I noted others sighted their height as part of the problem. I have a bad back and kept my seat low to ease getting in and out of the vehicle. My vehicle was totaled but the air bags never deployed and no one was injured.
The contact owns a 2020 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V720000 (Structure). The contact stated while driving at approximately 40 MPH, the front bumper detached from the vehicle. The vehicle was taken to a dealer where it was diagnosed that the upper and lower bumper, underpinning, wheel well assembly covers, and other unknown parts needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 89,000.
It's been a known issue that Toyota Highlander has transmission problems under 100k miles from 2016-2021 or later (social media sites confirmed such). My vehicle require a trans axle replacement as well as the struts are leaking oil and my vehicle has less than 62k miles and is only 5 years old. This is being covered under my extended warranty but parts are on back order After doing research many owners complain about a whining noise showing acceleration of vehicle . If left unfixed this leads to transmission gears slipping and eventually needing an entire replacement Some owners also complain about leaky struts. My car has an issue with leaky struts and is being fixed under warranty Some owners say they need an entire new transmission and after that is replaced the rear transaxle goes and needs replacement Toyota is not putting a recall on this but it's a known issue. …
While driving on a 75 MPH highway, the lower bumper cover, windscreen, and interior wheel well components spontaneously detached from the vehicle and got stuck under the car. There were no warming lamps, messages, or other symptoms; the vehicle was driving fine before the detachment. The vehicle has never been in a collision and had no visible damage to the bumper prior to the incident. The detachment was very quick and could have caused an accident, as it was quite physically jarring; additionally, the components got between the vehicle and the highway which caused them to smoke/burn as I tried to quickly slow and pull into the shoulder. A prior recall (#23TB12 / 23TA12) was for a very similar situation. The dealership had allegedly performed the recall fix in March 2025. When I took the vehicle back to the dealership, they said this was independent of the recall. …
About once or twice a week as I'm slowly braking to make a turn or stop, the car will surge forward. I have to depress the brake harder, and it does stop or keep slowing. I'm very concerned that if this happens as I'm stopping at a cross walk, someone could be hurt. I took it to the dealer who couldn't replicate it, so said it wasn't a safety issue. There are lots of forums that describe this with highlanders. My partner can feel it happen too. I'm not sure if it's the braking system or engine. My guess is engine because it seems to be a power surge. It's inconsistent, and happens in all kinds of weather, hot/cold, dry/wet. No warning lights, or messages. Happens a lot, but I'm using the example of earlier this week. You're welcome to inspect if you want. …
Related recalls
Structure › Body › Bumpers
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2023 Highlander & Highlander Hybrid vehicles. During normal vehicle operation, minor impact to the front lower bumper cover may result in the cover coming loose or detaching.
Remedy: Dealers will repair or replace the upper and lower front bumper covers as necessary, free of charge. Owner letters were mailed April 22, 2024. Owners may contact Toyota customer service at 1-800-331-4331.
Body complaints in other Highlander years
Frequently asked questions
How common are body problems on the 2020 Toyota Highlander?
NHTSA has 30 complaints about the body & structure of the 2020 Toyota Highlander, 9% of the model year's 321 complaints. The component named most often is body (18 mentions).
Is there a recall for 2020 Toyota Highlander body problems?
Yes — NHTSA recall 23V-720 (bumpers, Oct 26, 2023). Recall repairs are free at authorized dealers.
At what mileage do 2020 Toyota Highlander body problems start?
Half of the complaints with a recorded mileage happened before about 30,000 miles, and 50% before 25,000 miles.
Is it dangerous?
Owners linked 1 crash, 0 fires and 0 injuries to body & structure problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.