Most common 2010 Toyota Highlander problems
Share of the 216 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Toyota Highlander complaints by model year
Best Highlander years: 2025, 2016, 2014. Years to avoid: 2021, 2019, 2023, 2022, 2020. Compare all years →
2010 Toyota Highlander recalls (10)
Seats › Front assembly › Seat heater/cooler
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010…
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016.
Visibility › Power window devices and controls
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles.
Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge.
Seats › Front assembly › Seat heater/cooler
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge.
Air bags › Frontal › Driver side › Inflator module
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable…
Remedy: Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall.
Equipment › Other › Labels
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011…
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed.
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and…
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013.
Show 4 more recalls
Equipment › Other › Labels
Gulf states Toyota is recalling certain model year 2005-2010 vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold between September 1, 2005 and June 2, 2008 without the requisite load carrying capacity modification labels.
Remedy: Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. Dealers will also correct the owner's manual.
Equipment › Other › Labels
Southeast Toyota is recalling certain model year 2005-2011 passenger vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold without the requisite load carrying capacity modification labels.
Remedy: Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. The safety recall began on May 27, 2010.
Vehicle speed control › Accelerator pedal
Toyota is recalling certain model year 2008-2010 highlander, model year 2009-2010 corolla, venza and matrix passenger vehicles. The accelerator pedal can get stuck in the wide open position due to its being trapped by an unsecured or incompatible driver's floor mat.
Remedy: Toyota will modify or replace the accelerator pedals on the subject vehicles. Floor surface modifications are also being considered and will be included for any model for which it is deemed appropriate.
Vehicle speed control › Accelerator pedal
Toyota is recalling certain model year 2005-2010 avalon, model year 2007-2010 camry, model year 2009-2010 corolla, corolla matrix, rav4, model year 2010 highlander, model year 2008-2010 sequoia, and model year 2007-2010 tundra vehicles.
Remedy: Dealers will install a reinforcement bar in the accelerator pedal which will allow the pedal to operate smoothly. GM will notify owners for the Pontiac vibe please see 10v-018.
NHTSA defect investigations
Federal safety investigators have looked into 2 possible defects involving the 2010 Toyota Highlander:
Upper Steering Column Separation
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion.
Steering Column Separation
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism.
What 2010 Toyota Highlander owners say
Electrical system all 53 →
The contact owns a 2010 Toyota Highlander. The contact stated that while driving 40 MPH, the vehicle lost automotive power and started to drift to the right side of the road. The brake pedal was depressed, and the vehicle was able to come to a complete stop. The contact mentioned she waited for AAA for roadside assistance. The vehicle was towed to an independent mechanic, where it was diagnosed alternator needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure but offered no assistance. The failure mileage was approximately 185,420.
When applying the brake slowly all of a sudden the car went full acceleration and crashed 500ft away at high speed. The car is crashed but available for inspection for a short period of time until the insurance company takes full posession. There are not open recalls. The only lights on the dash were for TPMS sensor.
Windows, wipers & sunroof all 42 →
Sun roof glass exploded while driving on a highway at about 60 to 65 miles per hour. We had the sun shade closed so we did not know the sun roof glass had exploded. Pulled off the road, no other car or truck was near us, and discovered the sun roof glass had exploded and glass was prevented from entering the passenger compartment because the shade was closed. Went to a Toyota dealer about 10 miles away and they said it was probably caused by a rock. I said no one was near us, front or back, and they said we might have had a chip in the sun roof glass from before this happened. It was a nice day, no rain, not too hot, around 65 degrees, comfortable, sun was out. They taped the glass that was still together so we could drive home and have it repaired. They did not have the glass and would take several days. This happened in July, 2012.
Tl* the contact owns a 2010 Toyota Highlander. The contact stated that the passenger side visor was fractured. The vehicle was not taken to the dealer the vehicle was not diagnosed or repaired. The dealer was contacted and stated that they would not repair the vehicle free of charge since the VIN was not included in a related recall. The dealer advised the contact to call the manufacturer. The manufacturer was made aware of the failure and informed the contact that the repairs would not be free of charge. The manufacturer also advised the contact to call the NHTSA hotline and provided case number 1705112724. The failure mileage was 137,300. Updated 06/29/17 the consumer requested to dismiss this case as it has been resolved by the manufacturer. Updated 07/11/2017
Brakes all 30 →
The brake actuator (4405048320) and brake booster pump (4707048020) malfunctioned. The ABS warning came on the display, as well as a warning saying "Brake Malfunction: pull over car immediately." The traction control light, ABS light, warning light, and parking brake light also came on. The computer code was C1391. This controls the brakes and anti-lock brake system. This is a serious and known safety issue. It is well-documented online, and in 2019 Toyota acknowledged this widespread issue with a Customer Support Program ZKC. However, this program only applied for a limited time, and since then more vehicles have had this same issue with faulty parts. Even vehicles under 150,000 miles no longer qualify for free replacement despite this being a known and widespread issue.
When traveling a slow speeds (less than 15 mph) and needing to stop, the brakes are pressed but do not respond. This has happened on several occasions and has caused two separate accidents where the Highlander has failed to stop and it runs into the car in front. After the first accident, we looked for recalls (2015) and there were none for any model Toyota for brakes or brake systems. We brought the car in to the mechanic and had all the brakes and pads replaced, although they said nothing was wrong with the shoes nor pads. Now, years later, another accident in the exact same way. Luckily, due to the slow speed, no one was hurt but this is definitely a problem with the car. There have never been any warning lights, or sounds that would indicate an issue.
2010 Toyota Highlander engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 3.3L 6-cyl hybrid | CVT | AWD | 27 / 25 / 26 |
| 2.7L 4-cyl | 6-speed automatic | FWD | 20 / 27 / 22 |
| 3.5L 6-cyl | 5-speed automatic | FWD | 18 / 24 / 20 |
| 3.5L 6-cyl | 5-speed automatic | AWD | 17 / 23 / 19 |
EPA ratings. Class: SUV.
Frequently asked questions
Is the 2010 Toyota Highlander a good car?
Based on 216 owner complaints filed with NHTSA, the 2010 Highlander rates average: about as many complaints as a typical year of the Highlander at the same age. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2010 Toyota Highlander?
The electrical system — 53 complaints, 25% of all complaints for this model year, most often about 12v/24v/48v battery. Next are the windows, wipers & sunroof (42) and brakes (30).
How many recalls does the 2010 Toyota Highlander have?
There are 10 recalls for the 2010 Toyota Highlander, the most recent from June 2, 2016 (seat heater/cooler). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Toyota Highlander?
The best years by complaints, compared at the same age, are 2025, 2016 and 2014. Years to avoid or approach with caution: 2021, 2019, 2023, 2022 and 2020. See the full Toyota Highlander years comparison.
At what mileage do 2010 Toyota Highlander problems happen?
The median mileage reported in complaints is about 54,000 miles; 43% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.